Battery DODGE GRAND CARAVAN 2016 5.G Service Manual

Your vehicle has a simple ignition actuated test, which
you can use prior to going to the test station. To check if
your vehicle’s OBD II system is ready, you must do the
following:
1. Cycle the ignition switch to the ON position, but donot crank or start the engine.
NOTE: If you crank or start the engine, you will have to
start this test over.
2. As soon as you cycle the ignition switch to the ON position, you will see the Malfunction Indicator Light
(MIL) symbol come on as part of a normal bulb check.
3. Approximately 15 seconds later, one of two things will happen:
• The MIL will flash for about 10 seconds and then
return to being fully illuminated until you turn OFF the ignition or start the engine. This means that your
vehicle’s OBD II system is
not readyand you should
not proceed to the I/M station.
• The MIL will not flash at all and will remain fully
illuminated until you place the ignition in the off
position or start the engine. This means that your
vehicle’s OBD II system is readyand you can proceed
to the I/M station.
If your OBD II system is not ready,you should see your
authorized dealer or repair facility. If your vehicle was
recently serviced or had a battery failure or replacement,
you may need to do nothing more than drive your
vehicle as you normally would in order for your OBD II
system to update. A recheck with the above test routine
may then indicate that the system is now ready.
Regardless of whether your vehicle’s OBD II system is
ready or not, if the MIL is illuminated during normal
vehicle operation you should have your vehicle serviced
616 MAINTAINING YOUR VEHICLE

To minimize the possibility of catalytic converter dam-
age:
•Do not shut off the engine or interrupt the ignition,
when the transmission is in gear and the vehicle is in
motion.
• Do not try to start the engine by pushing or towing the
vehicle.
• Do not idle the engine with any spark plug wires
disconnected or removed, such as when diagnostic
testing, or for prolonged periods during very rough
idle or malfunctioning operating conditions.
Maintenance-Free Battery
Your vehicle is equipped with a maintenance-free battery.
You will never have to add water, nor is periodic main-
tenance required.
WARNING!
• Battery fluid is a corrosive acid solution and can
burn or even blind you. Do not allow battery fluid
to contact your eyes, skin, or clothing. Do not lean
over a battery when attaching clamps. If acid
splashes in eyes or on skin, flush the area imme-
diately with large amounts of water. Refer to
“Jump-Starting Procedures” in “What To Do In
Emergencies” for further information.
• Battery gas is flammable and explosive. Keep
flame or sparks away from the battery. Do not use
a booster battery or any other booster source with
an output greater than 12 Volts. Do not allow cable
clamps to touch each other.
• Battery posts, terminals, and related accessories
contain lead and lead compounds. Wash hands
after handling.
624 MAINTAINING YOUR VEHICLE

CAUTION!
•It is essential when replacing the cables on the
battery that the positive cable is attached to the
positive post and the negative cable is attached to
the negative post. Battery posts are marked positive
(+) and negative (-) and are identified on the
battery case. Cable clamps should be tight on the
terminal posts and free of corrosion.
• If a “fast charger” is used while the battery is in the
vehicle, disconnect both vehicle battery cables be-
fore connecting the charger to the battery. Do not
use a “fast charger” to provide starting voltage.
Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance test. Drive belt tension should also be checked at this
time.
WARNING!
•
Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause the
system to fail, requiring costly repairs. Refer to
Warranty Information Book, located on the DVD,
for further warranty information.
• The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced technician.
7
MAINTAINING YOUR VEHICLE 625

WARNING!(Continued)
material. Failure to use proper fuses may result in
serious personal injury, fire and/or property dam-
age.
• Before replacing a fuse, make sure that the ignition
is off and that all the other services are switched off
and/or disengaged.
• If the replaced fuse blows again, contact an autho-
rized dealer.
• If a general protection fuse for safety systems (air
bag system, braking system), power unit systems
(engine system, gearbox system) or steering system
blows, contact an authorized dealer.
Totally Integrated Power Module (Fuses)
The Totally Integrated Power Module is located in the
engine compartment near the battery. Refer to the appli-
cable “Engine Compartment” illustration in this section. This center contains cartridge fuses and mini-fuses. A
label that identifies each component may be printed or
embossed on the inside of the cover.
Totally Integrated Power Module
7
MAINTAINING YOUR VEHICLE 647

VEHICLE STORAGE
If you are leaving your vehicle dormant for more than 21
days, you may want to take steps to protect your battery.
You may do the following:
•Remove the 60 Amp cartridge in the Totally Integrated
Power Module (TIPM) labeled Ignition-Off Draw
(IOD). •
Or, disconnect the negative cable from the battery.
• Anytime you store your vehicle, or keep it out of
service for two weeks or more, run the air conditioning
system at idle for about five minutes in the fresh air
and high blower setting. This will ensure adequate
system lubrication to minimize the possibility of com-
pressor damage when the system is started again.
654 MAINTAINING YOUR VEHICLE

Once A Month Or Before A Long Trip:
•Check engine oil level.
• Check windshield washer fluid level.
• Check tire pressure and look for unusual wear or
damage. Rotate tires at the first sign of irregular wear,
even if it occurs before the oil indicator system turns
on. •
Check the fluid levels of the coolant reservoir, brake
master cylinder, and power steering and fill as needed.
• Check function of all interior and exterior lights.
Required Maintenance Intervals.
Refer to the maintenance schedules on the following
page for the required maintenance intervals.
At Every Oil Change Interval As Indicated By Oil Change Indicator System:
• Change oil and filter.
• Rotate the tires. Rotate at the first sign of irregular wear, even if it occurs before the oil indicator system
turns on.
• Inspect battery and clean and tighten terminals as required.
• Inspect brake pads, shoes, rotors, drums, hoses and park brake.
• Inspect engine cooling system protection and hoses.
• Inspect exhaust system.
• Inspect engine air cleaner if using in dusty or off-road conditions. 8
MAINTENANCE SCHEDULES 667

Anti-Lock Warning Light....................331
Appearance Care ........................ .640
Ashtray ............................... .276
Assistance Towing ........................ .160
Assist, Hill Start ......................... .492
Auto Down Power Windows ..................41
Automatic Dimming Mirror ..................132
Automatic Door Locks ......................37
Automatic Headlights ..................... .223
Automatic Temperature Control (ATC) ..........448
Automatic Transmission ..............468, 638, 639
Adding Fluid ......................... .639
Fluid And Filter Changes ..................639
Fluid Change ......................... .639
Fluid Level Check ...................... .639
Fluid Type ........................ .638, 663
Gear Ranges .......................... .473
Special Additives ...................... .638
Torque Converter ...................... .480Auto Up Power Windows
....................41
Battery ............................ .319, 624
Charging System Light ...................319
Jump Starting ......................... .600
Keyless Transmitter Replacement (RKE) ........28
Saving Feature (Protection) ................229
Belts, Seat .............................. .120
Body Mechanism Lubrication .................627
B-Pillar Location ......................... .507
Brake Assist System ...................... .491
Brake Control System, Electronic ..............488
Brake Fluid ............................ .663
Brake System ........................ .488, 635
Anti-Lock (ABS) ....................... .488
Fluid Check .......................... .636
Parking ............................. .485
Warning Light ........................ .317
Brake/T
ransmission Interlock .................470
10
INDEX 685

Key FobProgramming Additional Key Fobs ...........17
Programming Additional Transmitters .........17
Key-In Reminder ..........................15
Keyless Entry System .......................20
Key, Replacement ..........................16
Keys ...................................12
Key, Sentry (Immobilizer) ....................15
Lane Change Assist ....................... .228
Lap/Shoulder Belts .........................59
Latches ............................... .123
Hood ............................... .220
Lead Free Gasoline ....................... .536
Leaks, Fluid ............................ .123
Life Of Tires ............................ .522
Liftgate .................................51
Light Bulbs ............................. .122
Lights ............................. .122, 222AirBag ........................90, 120, 315
Automatic Headlights
....................223
Back-Up ............................. .658
Battery Saver ......................... .229
Brake Assist Warning ....................498
Brake Warning ........................ .317
Bulb Replacement ....................655, 657
Center Mounted Stop ....................659
Cruise .............................. .338
Daytime Running ...................... .224
Dimmer Switch, Headlight .................225
Engine Temperature Warning ...............322
Exterior ............................. .122
Fog............................. .225, 658
Hazard Warning Flasher ..................567
Headlights ........................... .657
Headlights On Reminder ..................224
High Beam/Low Beam Select ...............228
Illuminated Entry ........................19
10
INDEX 693

Interior............................. .225
License ............................. .659
Lights On Reminder .....................224
Low Fuel ............................ .328
Malfunction Indicator (Check Engine) .........329
Park ............................ .336, 657
Passing ............................. .229
Reading ............................. .250
Rear Servicing ........................ .658
Rear Tail Lamps ....................... .658
Seat Belt Reminder ..................... .316
Security Alarm ........................ .324
Service .......................... .655, 657
Side Marker .......................... .658
Tire Pressure Monitoring (TPMS) ............332
Traction Control ....................... .498
Turn Signal ..................122, 335, 657, 658
Warning (Instrument Cluster Description) . . .322, 335
Loading Vehicle ....................282, 546, 548 Capacities
........................... .548
Tires ............................... .507
Load Leveling System ..................... .291
Locks ..................................34
Door .................................34
Lubrication, Body ........................ .627
Luggage Rack (Roof Rack) ...................291
Lug Nuts .............................. .580
Maintenance Free Battery ....................624
Maintenance Procedures ....................617
Maintenance Schedule ..................... .666
Malfunction Indicator Light (Check Engine) . . .329, 615
Manual, Service ......................... .679
Map/Reading Lights ...................... .250
Memory Feature (Memory Seat) ...............216
Memory Seat ........................ .134, 216
Methanol .............................. .537
Mini-Trip Computer ...................... .347
694 INDEX

Towing............................... .549
24-Hour Towing Assistance ................160
Disabled Vehicle ....................... .607
Guide .............................. .553
Recreational .......................... .562
Weight .............................. .553
Towing Assistance ........................ .160
Towing Vehicle Behind A Motorhome ...........562
Traction ............................... .481
Traction Control ......................... .495
Trailer Sway Control (TSC) ..................500
Trailer Towing .......................... .549
Cooling System Tips .....................561
Hitches ............................. .551
Minimum Requirements ..................555
Tips................................ .560
Trailer And Tongue Weight ................554
Wiring .............................. .558
Trailer Towing Guide ...................... .553Trailer Weight
........................... .553
Transmission ........................... .638
Automatic ........................ .468, 638
Fluid ............................ .638, 663
Transmitter Battery Service (Remote Keyless Entry) . .28
Transmitter, Garage Door Opener (HomeLink) .....254
Transmitter, Remote Keyless Entry (RKE) .........20
Transporting Pets .........................117
Tread Wear Indicators ..................... .521
Turn Signals ..................... .335, 657, 658
UCI Connector .......................... .384
Uconnect Advanced Phone Connectivity ..............163
Uconnect 130 Operating Instructions Auxiliary Mode ........367
Operating Instructions CD Mode ............362
Operating Instructions Radio Mode ..........359
Playing MP3 Files ...................... .365
10
INDEX 701