lights DODGE INTREPID 2004 2.G Owner's Manual

CAUTION!
The use of vinyl, leather or plastic protectants may
cause excessive gloss and/or discoloration of interior
trim parts.
Leather Seat Care and Cleaning
Leather is best preserved by regular cleaning with a
damp soft cloth. Small particles of dirt can act as an
abrasive and damage the leather surface and should be
removed immediately with a damp cloth. Stubborn soils
can be removed easily with a soft cloth and Mopar Total
Clean. Care should be taken to avoid soaking the leather
with any liquid. Please do not use polishes, oils, cleaning
fluids, solvents, detergents, or ammonia based cleaners
to clean the leather. Application of a leather conditioner is
not required to maintain the original condition.
Cleaning Headlights
Your vehicle has plastic headlights that are lighter and
less susceptible to stone breakage than glass headlights.
Plastic is not as scratch resistant as glass and therefore
different lens cleaning procedures must be followed.To minimize the possibility of scratching the lenses and
reducing light output, avoid wiping with a dry cloth. To
remove road dirt, wash with a mild soap solution fol-
lowed by rinsing.
Do not use abrasive cleaning components, solvents, steel
wool or other aggressive material to clean the lenses.
Glass Surfaces
All glass surfaces should be cleaned on a regular basis
with any commercial household-type glass cleaner.
Never use an abrasive type cleaner. Use caution when
cleaning inside rear windows equipped with electric
defrosters. Do not use scrapers or other sharp instru-
ments which may scratch the elements.
Instrument Panel Cover
The instrument panel cover has a low glare surface which
minimizes reflections in the windshield. Do not use
protectants or other products which may cause undesir-
able reflections. Use soap and warm water to restore the
low glare surface.
200 MAINTAINING YOUR VEHICLE

Underhood Fuses
A Power Distribution center is located in the engine
compartment. This center contains fuses and relays for
circuits that operate only under the hood. A label which
identifies these components is located on the underside
of the cover.CAUTION!
When replacing a blown fuse, it is important to use
only a fuse having the correct amperage rating. The
use of a fuse with a rating other than indicated may
result in a dangerous electrical system overload. If a
properly rated fuse continues to blow, it indicates a
problem in the circuit that must be corrected.
Interior Fuses
Cavity Fuse Circuits
1 10 Amp Red Transmission Controller,
Gauges, Autostick
2 10 Amp Red Right High Beam Headlight
3 10 Amp Red Left High Beam Headlight
4 10 Amp Red Radio, CD Player
5 10 Amp Red Washer Motor
6 15 Amp Lt. Blue Power Outlet
7 20 Amp Yellow Tail, License, Parking, Illu-
mination Lights, Instru-
ment Cluster
202 MAINTAINING YOUR VEHICLE

Cavity Fuse Circuits
8 10 Amp Red Airbag
9 10 Amp Red Turn Signal Lights, Turn
Signal/Hazard Indicator
10 15 Amp Lt. Blue Right Low Beam
11 20 Amp Yellow High Beam Relay, High
Beam Indicator, High Beam
Switch
12 15 Amp Lt. Blue Left Low Beam Headlight
13 10 Amp Red Fuel Pump Relay, Power
Train Control Module
14 10 Amp Red Cluster, Day/Night Mirror,
Sunroof, Overhead Console,
Garage Door Opener, Body
Control Module
15 10 Amp Red Daytime Running Light
Module (Canada)
16 20 Amp Yellow Fog Light Indicator
17 10 Amp Red ABS Control, Back Up
Lights, Daytime Running
Lights, A/C Heater Con-
trol,Cavity Fuse Circuits
18 20 Amp Yellow Power Amplifier, Horn
19 15 Amp Lt. Blue Overhead Console, Garage
Door Opener, Trunk, Over-
head, Rear Reading, and
Visor Vanity Lights, Trunk
Release Solenoid, Power
Mirrors, Power Door Locks,
Body Control Module, As-
pirator Motor
20 20 Amp Yellow Brake Lights
21 10 Amp Red Leak Detection Pump, Low
Rad Relay, High Rad Relay,
A/C Clutch Relay
22 10 Amp Red Airbag
23 30 Amp Green Blower Motor, ATC Power
Module
24 20 Amp
C/BRKRPower Window Motors
25 20 Amp
C/BRKRPower Door Lock Motors,
Power Seats
MAINTAINING YOUR VEHICLE 203
7

REPLACEMENT BULBS
Interior Light Bulbs Bulb No.
Cluster Illumination.....................PC194
Turn Signal...........................PC194
Climate Control.......................... 330
Overhead Console, Front Reading, Courtesy, Grab
Handle................................ 192
Trunk................................. 906
Exterior Light Bulbs Bulb No.
Low Beam Headlights....................9006
High Beam Headlights....................9005
Park, Turn, & Side Marker................3157A
Fog Light.............................. H-3
Center Stop Light........................ 922
Tail, Stop, & Turn........................3157
Rear Side Marker........................ 168
Back-Up..............................3157
License................................ 168
EXTERIOR LIGHT BULB SERVICE
Headlight Replacement
1. Open the hood and remove the headlight assembly
mounting screws.
2. Pull the headlight assembly forward to access the
bulbs.
3. Turn the bulb assembly retaining ring counterclock-
wise and pull the bulb and socket assembly from the
housing.
204 MAINTAINING YOUR VEHICLE

Tail, Stop, Back Up, and Turn Signal Lights
1. Open the trunk and remove the fasteners securing the
light housing to the body.
2. Pull the light housing from the body to expose the
wiring socket.
3. Turn the bulb socket counterclockwise to remove from
the housing. Pull the bulb from the socket.
4. Replace the bulb, reinstall the socket, and reattach the
light housing.
License Plate Light
1. Remove the screws securing the light to the rear fascia.
2. Remove the bulb and socket assembly and pull the
bulb from the socket.
3. Replace the bulb and reinstall the bulb and socket
assembly.
MAINTAINING YOUR VEHICLE 207
7

Once a Month
•
Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transaxle and add
as needed.
•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
At Each Oil Change
•
Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front and rear suspension
components.
•Check the automatic transmission fluid level.
•Check the coolant level, hoses, and clamps.
•Rotate the tires at each oil change interval shown on
Schedule “A” 6,000 miles (10 000 km) or every other
interval shown on Schedule “B” 6,000 miles (10 000
km).
214 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

About Your Brakes...................... 134
ABS (Anti-Lock Brake) System...........91,134
Accident Damage....................... 199
Adding Engine Coolant (Antifreeze)......... 189
Adding Fuel.......................... 146
Air Cleaner, Engine..................... 180
Air Conditioner Maintenance.............. 182
Air Conditioning.................... 114,117
Air Conditioning Controls............. 114,117
Air Conditioning, Operating Tips........... 123
Air Conditioning Refrigerant.............. 182
Air Conditioning System................. 182
Air Pressure, Tires...................136,137
Airbag................................ 33
Airbag Deployment....................36,37
Airbag Light.....................37,40,48,90
Airbag Maintenance...................... 39
Alarm System.......................... 23
Alignment and Balance.................. 143
Antifreeze Disposal..................... 188
Antifreeze (Engine Coolant)............... 189
Anti-Lock Brake System.................. 134
Anti-Lock Warning Light.................. 91Anti-Theft Security Alarm................. 23
Anti-Theft System....................... 23
Appearance Care....................... 197
Auto Down Power Windows............... 25
Automatic Door Locks.................... 16
Automatic Mirrors....................... 53
Automatic Off, Interior Lights.............. 60
Automatic Temperature Control............ 117
Automatic Transaxle..................129,194
Fluid and Filter Changes................ 197
Fluid Level Check..................... 195
Reset Mode......................... 130
Selection Of Lubricant................. 194
Shifting............................ 130
Special Additives..................... 197
Backfire, Engine........................ 180
Ball Joints............................ 184
Battery............................158,181
Emergency Starting.................... 158
Gas Caution......................158,181
Jump Starting........................ 158
Keyless Transmitter Replacement.......... 22
238 INDEX

Location.........................159,181
Saving Feature....................60,61,63
Belts, Engine.......................... 180
Body Mechanism Lubrication.............. 184
Brake, Parking......................... 132
Brake System.......................134,192
Anti-Lock........................... 134
Fluid Check......................... 193
Hoses.............................. 192
Master Cylinder...................... 193
Warning Light.....................92,132
Brake/Transmission Interlock...........129,130
Break-In Recommendations, New Vehicle...... 47
Bulb Replacement...................... 204
Bulbs, Light........................... 204
Capacities, Fluid....................... 208
Capacity, Cargo Weight.................. 148
Car Washes........................198,199
Cargo Compartment
Capacity............................ 148
Luggage Carrier...................... 148
Carpeting............................. 199Cassette Tape and Player Maintenance....... 112
Cassette Tape Player................93,100,112
Catalytic Converter..................... 178
CD Changer.....................103,108,109
CD Player.......................98,105,107
Central Door Locks...................... 15
Chains, Tire........................... 140
Changing A Flat Tire.................... 153
Charging System Light................... 91
Checks, Safety.......................... 47
Child Restraint...................40,42,44,45
Child Restraint Tether Anchors...........43,44
Child Safety Locks....................... 16
Circuit Breakers........................ 202
Clean Air Gasoline...................... 144
Cleaning
Carpets............................. 199
Cloth.............................. 199
Glass.............................. 200
Headlights.......................... 200
Instrument Panel..................... 200
Seat Belts........................... 201
Vinyl.............................. 199
INDEX 239
10

Washing............................ 198
Waxing............................. 198
Wheels............................. 199
Windshield Wiper Blades............... 186
Climate Control........................ 114
Clock................................. 93
Coat Hook............................. 52
Compact Disc Maintenance............... 113
Compact Disc Player...................93,98
Compact Spare Tire..................... 139
Compass.............................. 79
Computer, Trip/Travel.................... 77
Console, Overhead....................... 70
Contract, Service....................... 230
Cooling System........................ 188
Adding Coolant (Antifreeze)............. 189
Coolant Level........................ 190
Disposal of Used Coolant............... 188
Drain, Flush, and Refill................. 188
Inspection........................... 188
Points to Remember................... 191
Pressure Cap........................ 189
Radiator Cap........................ 189Rubber and Plastic Components.......... 191
Selection of Coolant................... 189
Corrosion Protection.................... 197
Courtesy Lights......................... 61
Crankcase Emission Control System......... 180
Cruise Light........................... 89
Cup Holder............................ 52
Customer Assistance.................... 228
Daytime Running Lights.................. 63
Dealer Service......................... 171
Defroster, Rear Window.................. 117
Defroster, Windshield...............48,116,120
Diagnostic System, Onboard.............90,169
Dimmer Switch, Headlight................. 64
Disabled Vehicle Towing................. 163
Disposal
Antifreeze........................... 188
Engine Oil.......................... 177
Door Ajar Light......................... 89
Door Locks........................14,15,16
Door Locks, Automatic................... 16
Door Locks, Central...................... 15
240 INDEX

Door Opener, Garage..................... 70
Drive Belts............................ 178
Drive Shaft Universal Joints............... 184
Driving
On Slippery Surfaces.................. 161
With an Automatic Transaxle............ 129
Electric Remote Mirrors................... 54
Electronic Speed Control.................. 67
Emergency Flashers..................... 152
Emission Control System Maintenance. . 170,180,212
Engine
Air Cleaner.......................... 180
Block Heater......................... 129
Break-In Recommendations............... 47
Checking Oil Level.................... 172
Compartment.....................167,168
Cooling..........................89,188
Fails to Start......................... 128
Oil ..............................88,172
Oil Change Interval................... 174
Oil Selection......................... 175
Oil Synthetic......................... 177Overheating.......................89,152
Specifications........................ 208
Timing Belt.......................... 180
Entry System, Illuminated................. 14
Exhaust Gas Caution..................47,187
Exhaust System........................ 187
Exterior Lights.......................62,204
Filters
Air Cleaner.......................... 180
Automatic Transaxle................... 197
Engine Fuel......................... 180
Engine Oil.......................... 178
Flashers
Hazard Warning...................... 152
Flat Tire Changing...................... 153
Floor Shift Interlock...................... 13
Fluid Capacities........................ 208
Fluid Leaks............................ 48
Fog Lights............................. 63
Freeing A Stuck Vehicle.................. 162
Fuel...............................88,143
Adding............................. 146
INDEX 241
10