maintenance DODGE INTREPID 2004 2.G Owner's Guide

NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule “B” of the
Maintenance Schedulessection of this manual.
NOTE:Most vehicles are operated under the conditions
listed for ScheduleB.
Second is Schedule“A”. It is for vehicles that are not
operated under any of the conditions listed under Sched-
uleB.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
NOTE:Under no circumstances should oil change
intervals exceed 6000 miles (10 000 km) or 6 months
whichever comes first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
•
Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
MAINTENANCE SCHEDULES 213
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Once a Month
•
Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transaxle and add
as needed.
•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
At Each Oil Change
•
Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front and rear suspension
components.
•Check the automatic transmission fluid level.
•Check the coolant level, hoses, and clamps.
•Rotate the tires at each oil change interval shown on
Schedule “A” 6,000 miles (10 000 km) or every other
interval shown on Schedule “B” 6,000 miles (10 000
km).
214 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SCHEDULE “B”
Follow schedule “B” if you usually operate your vehicle
under one or more of the following conditions. Change
the automatic transmission fluid and filter every 60,000
miles (96 000 km) if the vehicle is usually operated under
one or more of the conditions marked with an.
•Day or night temperatures are below 32° F (0° C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16.2 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90° F (32° C).
•Trailer towing.
•Taxi, police or delivery service (commercial ser-
vices).
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule “B” of the
Maintenance Schedulessection of this manual.
SCHEDULE “B” 215
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 93,000 96,000 99,000 100,000 102,000 105,000
(Kilometers) (149 000) (154 000) (158 000) (160 000) (163 000) (168 000)
Change engine oil and engine oil filter. X X X X X
Inspect theair cleaner filterand replace if re-
quired.*XXX X
Replace theair cleaner filter.X
Inspect the front and rear brake linings and
rotors.X
Flush and replace the engine coolant. X
Replace theengine timing belt(Federal Emis-
sions).X
Replace theengine timing belt(California
Emissions).X
Replace thespark plugs.X
Adjust the drive belt tension.X
Change the differential fluid. X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE “B” 221
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 78,000 84,000 90,000 96,000 102,000
(Kilometers) (125 000) (134 000) (144 000) (154 000) (163 000)
[Months] [78] [84] [90] [96] [102]
Change engine oil and engine oil filter. X X X X X
Inspect theair cleaner filterand replace if re-
quired.*XX XX
Replace theair cleaner filter.*X
Adjust the drive belt tension. X
Inspect the front and rear brake linings and rotors. X
Replace thespark plugs.X
Check and replace, if necessary, thePCV valve.*‡ X
Replace theengine timing belt(Federal Emissions
equipped vehicles only).X
Replace theengine timing belt(California Emis-
sions equipped vehicles only).X
Flush and replace the engine coolant at 60 months
or 100,000 miles.X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
224 SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SUGGESTIONS FOR OBTAINING SERVICE FOR
YOUR VEHICLE
Prepare For The Appointment
If you’re having warranty work done, be sure to have the
right papers with you. Take your warranty folder. All
work to be performed may not be covered by the
warranty, discuss additional charges with the service
manager. Keep a maintenance log of your vehicle’s
service history. This can often provide a clue to the
current problem.
Prepare A List
Make a written list of your vehicle’s problems or the
specific work you want done. If you’ve had an accident,
or work done that is not on your maintenance log, let the
service advisor know.
Be Reasonable With Requests
If you list a number of items, and you must have your
vehicle by the end of the day, discuss the situation with
the service advisor and list the items in order of priority.
At many dealers you may obtain a rental vehicle at a
minimal daily charge. If you need a rental, it is advisableto make these arrangements when you call for an ap-
pointment.
IF YOU NEED ASSISTANCE
The manufacturer and its dealers are vitally interested in
your satisfaction. We want you to be happy with our
products and services.
Your selling dealer is best equipped and most anxious to
provide prompt resolution for any warranty issue or
related matter that you may experience. The manufactur-
er’s dealers have the facilities, factory-trained techni-
cians, special tools, and the latest information to assure
your vehicle is fixed correctly and in a timely manner.
The manufacturer has empowered its dealers to make
warranty and repair decisions that ensure you are not
inconvenienced. There is no need for you to wait for a
decision from the manufacturer. If a special circumstance
occurs that requires information from the manufacturer,
we have asked the dealer’s service management to make
the contact on your behalf.
228 IF YOU NEED CONSUMER ASSISTANCE

About Your Brakes...................... 134
ABS (Anti-Lock Brake) System...........91,134
Accident Damage....................... 199
Adding Engine Coolant (Antifreeze)......... 189
Adding Fuel.......................... 146
Air Cleaner, Engine..................... 180
Air Conditioner Maintenance.............. 182
Air Conditioning.................... 114,117
Air Conditioning Controls............. 114,117
Air Conditioning, Operating Tips........... 123
Air Conditioning Refrigerant.............. 182
Air Conditioning System................. 182
Air Pressure, Tires...................136,137
Airbag................................ 33
Airbag Deployment....................36,37
Airbag Light.....................37,40,48,90
Airbag Maintenance...................... 39
Alarm System.......................... 23
Alignment and Balance.................. 143
Antifreeze Disposal..................... 188
Antifreeze (Engine Coolant)............... 189
Anti-Lock Brake System.................. 134
Anti-Lock Warning Light.................. 91Anti-Theft Security Alarm................. 23
Anti-Theft System....................... 23
Appearance Care....................... 197
Auto Down Power Windows............... 25
Automatic Door Locks.................... 16
Automatic Mirrors....................... 53
Automatic Off, Interior Lights.............. 60
Automatic Temperature Control............ 117
Automatic Transaxle..................129,194
Fluid and Filter Changes................ 197
Fluid Level Check..................... 195
Reset Mode......................... 130
Selection Of Lubricant................. 194
Shifting............................ 130
Special Additives..................... 197
Backfire, Engine........................ 180
Ball Joints............................ 184
Battery............................158,181
Emergency Starting.................... 158
Gas Caution......................158,181
Jump Starting........................ 158
Keyless Transmitter Replacement.......... 22
238 INDEX

Location.........................159,181
Saving Feature....................60,61,63
Belts, Engine.......................... 180
Body Mechanism Lubrication.............. 184
Brake, Parking......................... 132
Brake System.......................134,192
Anti-Lock........................... 134
Fluid Check......................... 193
Hoses.............................. 192
Master Cylinder...................... 193
Warning Light.....................92,132
Brake/Transmission Interlock...........129,130
Break-In Recommendations, New Vehicle...... 47
Bulb Replacement...................... 204
Bulbs, Light........................... 204
Capacities, Fluid....................... 208
Capacity, Cargo Weight.................. 148
Car Washes........................198,199
Cargo Compartment
Capacity............................ 148
Luggage Carrier...................... 148
Carpeting............................. 199Cassette Tape and Player Maintenance....... 112
Cassette Tape Player................93,100,112
Catalytic Converter..................... 178
CD Changer.....................103,108,109
CD Player.......................98,105,107
Central Door Locks...................... 15
Chains, Tire........................... 140
Changing A Flat Tire.................... 153
Charging System Light................... 91
Checks, Safety.......................... 47
Child Restraint...................40,42,44,45
Child Restraint Tether Anchors...........43,44
Child Safety Locks....................... 16
Circuit Breakers........................ 202
Clean Air Gasoline...................... 144
Cleaning
Carpets............................. 199
Cloth.............................. 199
Glass.............................. 200
Headlights.......................... 200
Instrument Panel..................... 200
Seat Belts........................... 201
Vinyl.............................. 199
INDEX 239
10

Washing............................ 198
Waxing............................. 198
Wheels............................. 199
Windshield Wiper Blades............... 186
Climate Control........................ 114
Clock................................. 93
Coat Hook............................. 52
Compact Disc Maintenance............... 113
Compact Disc Player...................93,98
Compact Spare Tire..................... 139
Compass.............................. 79
Computer, Trip/Travel.................... 77
Console, Overhead....................... 70
Contract, Service....................... 230
Cooling System........................ 188
Adding Coolant (Antifreeze)............. 189
Coolant Level........................ 190
Disposal of Used Coolant............... 188
Drain, Flush, and Refill................. 188
Inspection........................... 188
Points to Remember................... 191
Pressure Cap........................ 189
Radiator Cap........................ 189Rubber and Plastic Components.......... 191
Selection of Coolant................... 189
Corrosion Protection.................... 197
Courtesy Lights......................... 61
Crankcase Emission Control System......... 180
Cruise Light........................... 89
Cup Holder............................ 52
Customer Assistance.................... 228
Daytime Running Lights.................. 63
Dealer Service......................... 171
Defroster, Rear Window.................. 117
Defroster, Windshield...............48,116,120
Diagnostic System, Onboard.............90,169
Dimmer Switch, Headlight................. 64
Disabled Vehicle Towing................. 163
Disposal
Antifreeze........................... 188
Engine Oil.......................... 177
Door Ajar Light......................... 89
Door Locks........................14,15,16
Door Locks, Automatic................... 16
Door Locks, Central...................... 15
240 INDEX

Door Opener, Garage..................... 70
Drive Belts............................ 178
Drive Shaft Universal Joints............... 184
Driving
On Slippery Surfaces.................. 161
With an Automatic Transaxle............ 129
Electric Remote Mirrors................... 54
Electronic Speed Control.................. 67
Emergency Flashers..................... 152
Emission Control System Maintenance. . 170,180,212
Engine
Air Cleaner.......................... 180
Block Heater......................... 129
Break-In Recommendations............... 47
Checking Oil Level.................... 172
Compartment.....................167,168
Cooling..........................89,188
Fails to Start......................... 128
Oil ..............................88,172
Oil Change Interval................... 174
Oil Selection......................... 175
Oil Synthetic......................... 177Overheating.......................89,152
Specifications........................ 208
Timing Belt.......................... 180
Entry System, Illuminated................. 14
Exhaust Gas Caution..................47,187
Exhaust System........................ 187
Exterior Lights.......................62,204
Filters
Air Cleaner.......................... 180
Automatic Transaxle................... 197
Engine Fuel......................... 180
Engine Oil.......................... 178
Flashers
Hazard Warning...................... 152
Flat Tire Changing...................... 153
Floor Shift Interlock...................... 13
Fluid Capacities........................ 208
Fluid Leaks............................ 48
Fog Lights............................. 63
Freeing A Stuck Vehicle.................. 162
Fuel...............................88,143
Adding............................. 146
INDEX 241
10