radiator DODGE JOURNEY 2009 1.G User Guide

•Maintain coolant concentration at 50% HOAT engine
coolant (minimum) and distilled water for proper
corrosion protection of your engine, which contains
aluminum components.
•Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean, also.
•Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory coolant performance, poor gas
mileage, and increased emissions.
Hoses and Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber
Pay particular attention to the hoses nearest to high heat
sources such as the exhaust manifold. Inspect hose rout-
ing to be sure hoses do not touch any heat source or
moving component that may cause heat damage or
mechanical wear.
Ensure nylon tubing in these areas has not melted or
collapsed
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of wear or damage that could cause failure.
MAINTAINING YOUR VEHICLE 445
7

CavityCartridge
Fuse Mini-
Fuse Description
J7 30 Amp Pink —Anti-Lock Brake Sys-
tem (ABS) Valve/
Electronic Stability
Program (ESP)
J8 40 Amp Green —Power Memory Seat -
if equipped
J9 40 Amp Green —Flex Fuel/PZEV Mo-
tor - if equipped
J10 30 Amp Pink —(If Equipped) Head-
lamp Washer Relay-
(BUX), Manual Tun-
ing Valve
J11 30 Amp Pink —(If Equipped) Sway
Bar/Thatchum Secu-
rity (BUX)/Power
Sliding DoorCavity
Cartridge
Fuse Mini-
Fuse Description
J13 60 Amp Yellow —Ignition Off Draw
(IOD) Main
J14 40 Amp Green —Electric Back Light
(EBL)
J15 30 Amp Pink —Rear Blower - if
equipped
J17 40 Amp Green —Starter Solenoid
J18 20 Amp Yellow — NGC (Powertrain
Control Module)/
Transmission Range
J19 60 Amp Yellow —Radiator Fan Motor
J20 30 Amp Pink —Front Windshield
Wiper Hi/Low
J21 20 Amp Blue —Front/Rear Washer
MAINTAINING YOUR VEHICLE 459
7

CavityCartridge
Fuse Mini-
Fuse Description
M37
—10 Amp
Red
Anti-Lock Brake Sys-
tem (ABS), Electronic
Stability Program
(ESP), STOP LIGHT
Switch
M38 —25 Amp
Natural Lock/Unlock Motors
K1
—— Ignition Run/
Accessory Relay
K2 — — Ignition Run Relay
K3 — — Starter Solenoid Relay
K4 —— Ignition Run/Start
Relay
K5 —— (NGC) Powertrain
Control Module Relay
K6 —— Electric Back Light
(EBL) Relay
K7 — — —
K8 — — —
K9 — — Rear Blower Relay
K10 —— ASD Relay (Feed for
M19 and M21)
K11 —— Radiator Fan Relay
Low Speed
VEHICLE STORAGE
If you will not be using your vehicle for more than 21
days you may want to take steps to preserve your battery.
You may:
•Remove the IOD (Ignition Off-Draw) mini-fuses from
the Totally Integrated Power Module located in the
engine compartment.
•Or, disconnect the batter negative cable.
464 MAINTAINING YOUR VEHICLE

Brake Assist System...................... 330
Brake Assist Warning Light ................. 216
Brake Control System, Electronic ............. 328
Brake Fluid ............................ 476
Brake, Parking .......................... 323
Brake System ........................ 326,446
Anti-Lock (ABS) .................... 327,328
Fluid Check ....................... 447,476
Hoses .............................. 446
Master Cylinder ....................... 447
Parking ............................. 323
Warning Light ........................ 217
Brakes ............................. 326,446
Brake/Transaxle Interlock .................. 312
Break-In Recommendations, New Vehicle ........ 77
Brightness, Interior Lights .................. 152
Bulb Replacement ..................... 465,466
Bulbs, Light .......................... 81,465Calibration, Compass
.................. 219,228
Camera, Rear ........................... 92
Capacities, Fluid ........................ 472
Caps, Filler Fuel ................................ 372
Oil (Engine) .................. 418,419,420,427
Radiator (Coolant Pressure) ............... 442
Car Washes ............................ 452
Carbon Monoxide Warning ...............79,372
Cargo Area Cover ....................... 191
Cargo Area Features ...................... 188
Cargo Compartment ...................... 188
Light ............................ 151,188
Luggage Carrier ....................... 196
Cargo Light ............................ 151
Cargo Load Floor ........................ 188
Cargo Management System ................. 188
Rollaway Tonneau Cover ................. 191
Tri-Fold Load Floor ..................... 188
498 INDEX

Console, Overhead....................... 162
Contract, Service ........................ 489
Converter, Catalytic ...................... 429
Coolant Pressure Cap (Radiator Cap) .......... 442
Cooler, Beverage ........................ 180
Cooling System ......................... 440
Adding Coolant (Antifreeze) .............. 442
Coolant Capacity ...................... 472
Coolant Level ...................... 440,443
Disposal of Used Coolant ................ 443
Drain, Flush, and Refill .................. 441
Inspection ........................... 443
Points to Remember .................... 444
Pressure Cap ......................... 442
Radiator Cap ......................... 442
Selection of Coolant (Antifreeze) ......441,472,474
Temperature Gauge ..................... 205
Corrosion Protection ..................... 452
Cruise Control (Speed Control) .............. 159Cruise Light
........................... 212
Cup Holder ......................... 178,457
Customer Assistance ..................... 487
Customer Programmable Features ............ 230
Data Recorder, Event ...................... 63
Daytime Brightness, Interior Lights ........... 153
Daytime Running Lights ................... 148
Dealer Service .......................... 424
Defroster, Rear Window ................... 195
Defroster, Windshield ................80,286,287
Delay (Intermittent) Wipers ................. 155
Diagnostic System, Onboard ................ 421
Digital Video Disc (DVD) Player ..........234,266
Dimmer Control ........................ 152
Dimmer Switch, Headlight ................. 150
Dipsticks Automatic Transaxle .................... 449
Oil (Engine) .......................... 424
500 INDEX

Phone, Cellular.................... 93,266,267
Phone, Hands-Free (UConnect) ........ 93,266,267
Placard, Tire and Loading Information ......... 341
Port Universal Serial Bus (USB) .............234,266
USB ............................. 234,266
Power Brakes .............................. 326
Distribution Center (Fuses) ............... 457
Door Locks ........................... 30
Inverter ............................. 176
Mirrors .............................. 90
Outlet (Auxiliary Electrical Outlet) .......... 174
Seats ............................... 129
Steering ............................. 336
Steering, Checking ..................... 436
Sunroof ............................. 170
Windows ............................. 34
Windows, Express Down ................. 25 Power Steering Fluid
.................. 436,476
Power Transfer Unit ...................... 476
Pregnant Women and Seat Belts .............. 50
Preparation for Jacking .................... 397
Pretensioners Seat Belts ............................. 47
Programmable Electronic Features ............ 230
Programming Transmitters
(Remote Keyless Entry) .................... 20
Radial Ply Tires ......................... 349
Radiator Cap (Coolant Pressure Cap) .......... 442
Radio Broadcast Signals ................... 233
Radio, Navigation ....................... 266
Radio Operation ................... 235,267,284
Radio Remote Controls .................... 282
Radio, Satellite ............ 234,235,266,267,271,276
Radio (Sound Systems) .................234,266
Rear Camera ............................ 92
INDEX 511
10