ECU DODGE JOURNEY 2009 1.G Service Manual

4. Tilt the retainer at the end of the winch cable and drop
it through the center of the wheel. Then place the spare
tire with the cable and retainer underneath the vehicle.5. Fit the assembled jack-handle over the winch drive
nut. Rotate the jack-handle assembly clockwise to raise
the spare tire into the storage area. Continue to rotate the
jack-handle assembly until you hear the winch mecha-
nism click three times. It cannot be over tightened. Push
against the tire several times to be sure it is held securely
in place.
Jacking Instructions
Spare Tire Retainer
Jack Warning Label
WHAT TO DO IN EMERGENCIES 401
6

WARNING!
Carefully follow these tire changing warnings to help prevent
personal injury or damage to your vehicle:
•Always park on a firm, level surface as far from the edge of
the roadway as possible before raising the vehicle.
• Block the wheel diagonally opposite the wheel to be raised.
• Set the parking brake firmly and set an automatic transaxle
in PARK; a manual transaxle in REVERSE.
• Never start or run the engine with the vehicle on a jack.
• Do not let anyone sit in the vehicle when it is on a jack.
• Do not get under the vehicle when it is on a jack.
• Only use the jack in the positions indicated and for lifting
this vehicle during a tire change.
• If working on or near a roadway, be extremely careful of
motor traffic.
• To assure that spare tires, flat or inflated are securely stowed,
spares must be stowed with the valve stem facing the
ground.
• Turn on the Hazard warning flasher.
1. Remove the spare tire, jack, and jack-handle from
stowage.
2. Loosen, but do not remove, the wheel nuts on the
wheel with the flat tire. Turn the wheel nuts counter-
clockwise one turn while the wheel is still on the ground.
3. Place the jack underneath the lift area that is closest to
the flat tire. Turn the jack screw clockwise to firmly
engage the jack saddle with the lift area of the sill flange.
402 WHAT TO DO IN EMERGENCIES

3. Pivot the glove box downward.
4. Disengage the two retaining tabs that secure the filter
cover to the HVAC housing and remove the cover.5. Remove the A/C air filter by pulling it straight out of
the housing.
6. Install the A/C air filter with the arrow on the filter
pointing toward the floor. When installing the filter
cover, make sure the retaining tabs fully engage the
cover.
Glove Box RemovalA/C Air Filter Replacement
MAINTAINING YOUR VEHICLE 435
7

•Maintain coolant concentration at 50% HOAT engine
coolant (minimum) and distilled water for proper
corrosion protection of your engine, which contains
aluminum components.
•Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean, also.
•Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory coolant performance, poor gas
mileage, and increased emissions.
Hoses and Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber
Pay particular attention to the hoses nearest to high heat
sources such as the exhaust manifold. Inspect hose rout-
ing to be sure hoses do not touch any heat source or
moving component that may cause heat damage or
mechanical wear.
Ensure nylon tubing in these areas has not melted or
collapsed
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of wear or damage that could cause failure.
MAINTAINING YOUR VEHICLE 445
7

Ensure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose clamps and couplings to make sure they
are secure and no leaks are present.
NOTE:
•Often, fluids such as oil, power steering fluid, and
brake fluid are used during assembly plant operations
to ease the assembly of hoses to couplings. Therefore,
oil wetness at the hose-coupling area is not necessarily
an indication of leakage. Actual dripping of hot fluid
when systems are under pressure (during vehicle
operation) should be noted before a hose is replaced
based on leakage.
•Inspect the brake hoses whenever the brake system is
serviced and at every engine oil change. Inspect hy-
draulic brake hoses for surface cracking, scuffing, or
worn spots. If there is any evidence of cracking,
scuffing, or worn spots, the hose should be replacedimmediately. Eventual deterioration of the hose can
take place, resulting in a possibility of a burst failure.
WARNING!
Worn brake hoses can burst and cause brake failure.
You could have an accident. If you see any signs of
cracking, scuffing, or worn spots, have the brake
hoses replaced immediately.
Master Cylinder - Brake Fluid Level Check
Check the fluid level in the master cylinder immediately
if the Brake System Warning Light indicates system
failure.
Check the fluid level in the master cylinder when per-
forming underhood services.
MAINTAINING YOUR VEHICLE 447
7

CavityCartridge
Fuse Mini-
Fuse Description
J7 30 Amp Pink —Anti-Lock Brake Sys-
tem (ABS) Valve/
Electronic Stability
Program (ESP)
J8 40 Amp Green —Power Memory Seat -
if equipped
J9 40 Amp Green —Flex Fuel/PZEV Mo-
tor - if equipped
J10 30 Amp Pink —(If Equipped) Head-
lamp Washer Relay-
(BUX), Manual Tun-
ing Valve
J11 30 Amp Pink —(If Equipped) Sway
Bar/Thatchum Secu-
rity (BUX)/Power
Sliding DoorCavity
Cartridge
Fuse Mini-
Fuse Description
J13 60 Amp Yellow —Ignition Off Draw
(IOD) Main
J14 40 Amp Green —Electric Back Light
(EBL)
J15 30 Amp Pink —Rear Blower - if
equipped
J17 40 Amp Green —Starter Solenoid
J18 20 Amp Yellow — NGC (Powertrain
Control Module)/
Transmission Range
J19 60 Amp Yellow —Radiator Fan Motor
J20 30 Amp Pink —Front Windshield
Wiper Hi/Low
J21 20 Amp Blue —Front/Rear Washer
MAINTAINING YOUR VEHICLE 459
7

About Your Brakes.................... 323,326
ABS (Anti-Lock Brake System) .........215,327,328
Adding Engine Coolant (Antifreeze) .......... 442
Adding Fuel ........................... 372
Adding Rear Washer Fluid ................. 194
Adding Washer Fluid ...............157,194,438
Additives, Fuel ......................... 371
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 429
Air Conditioner Maintenance ............... 433
Air Conditioning ..................... 288,289
Air Conditioning Controls ...............288,289
Air Conditioning Filter .................301,434
Air Conditioning, Operating Tips ............ 302
Air Conditioning Refrigerant .............433,434
Air Conditioning System ..........288,289,293,433
Air Pressure, Tires .................... 213,346
Airbag ................................ 50
Airbag Deployment ..................... 56,60
Airbag Light ..................... 57,63,80,218Airbag Maintenance
....................... 62
Airbag, Side .......................... 52,58
Airbag, Window (Side Curtain) .............52,58
Alarm, Panic ............................ 24
Alarm (Security Alarm) .................18,208
Alarm System (Security Alarm) ............... 18
Alignment and Balance ................... 354
All Wheel Drive (AWD) ................... 319
Alterations/Modifications, Vehicle ............. 7
Antenna, Satellite Radio ................... 272
Antifreeze (Engine Coolant) ...........441,442,472
Disposal ............................ 443
Anti-Lock Brake System (ABS) ............327,328
Anti-Lock Warning Light .............215,328,329
Anti-Theft Security Alarm (Theft Alarm) ........ 18
Anti-Theft System ....................... 208
Appearance Care ........................ 452
Arming Theft System (Security Alarm) ......... 18
Assistance Towing ....................... 106
496 INDEX

Security Alarm (Theft Alarm).............18,208
Selection of Coolant (Antifreeze) ..........441,474
Selection of Oil ......................... 426
Sentry Key (Immobilizer) ................... 15
Sentry Key Programming ................... 17
Sentry Key Replacement ................... 16
Service Assistance ....................... 487
Service Contract ......................... 489
Service Engine Soon Light
(Malfunction Indicator) .................... 215
Service Manuals ........................ 492
Setting the Clock ................ 236,240,255,267
Settings, Personal ........................ 230
Shifting Automatic Transaxle .................... 311
Shoulder Belt Upper Anchorage .............. 46
Shoulder Belts ........................... 41
Side Airbag ........................... 52,58
Side Curtain (Window Airbag) ............... 52Side View Mirror Adjustment
................ 89
Side Window Demisters (Defrosters) .......... 301
Signals, Turn ................... 81,149,207,468
Sirius Backseat TV™ ..................... 276
Slippery Surfaces, Driving On ............... 320
Snow Chains (Tire Chains) ................. 355
Snow Tires ............................ 355
Sound Systems (Radio) .................234,266
Spare Tire ....................... 349,350,397
Spark Plugs ......................... 429,474
Specifications Fuel (Gasoline) ........................ 474
Oil .............................. 426,474
Speed Control (Cruise Control) .............. 159
Speedometer ........................... 207
Starting ............................. 27,307
Automatic Transmission ................. 308
Cold Weather ......................... 309
Emergency (Jump Starting) ............... 407
514 INDEX

Engine Fails to Start.................... 310
Remote .............................. 27
Starting and Operating .................... 307
Starting Procedures ...................... 307
Steering Column Lock ......................... 157
Linkage ............................. 437
Power ........................... 336,436
Tilt Column .......................... 157
Wheel, Tilt ........................... 157
Steering Wheel Mounted Sound
System Controls ......................... 282
Storage ............................ 180,464
Storage Bin ............................ 180
Storage, Vehicle ......................... 300
Stuck, Freeing .......................... 410
Sun Roof .............................. 170
Sun Visor Extension ....................... 91
Sunglasses Storage ....................... 163 Sunroof Maintenance
..................... 173
Supplemental Restraint System - Airbag ........ 50
Sway Control, Trailer .................. 335,379
Synthetic Engine Oil ...................... 427
System, Navigation ...................... 266
System, Remote Starting .................... 27
Tachometer ............................ 208
Taillights .............................. 468
Telescoping Steering Column ............... 157
Temperature Control, Automatic (ATC) ........ 293
Temperature Gauge, Engine Coolant .......... 205
Tether Anchor, Child Restraint ............... 71
Theft Alarm (Security Alarm) ................ 18
Theft System (Security Alarm) ............... 18
Tie Down Hooks, Cargo ................... 189
Tilt Steering Column ..................... 157
Time Delay, Headlight .................... 147
Tip Start ............................... 14
INDEX 515
10

Uniform Tire Quality Grades................ 493
Universal Consumer Interface (UCI) Connector . . . 278
Universal Serial Bus (USB) Port ...........234,266
Universal Transmitter ..................... 163
Unleaded Gasoline ....................... 368
Untwisting Procedure, Seat Belt .............. 47
Upholstery Care ........................ 454
USB Port ........................... 234,266
Vacuum/Vapor Harnesses ................. 445
Vanity Mirrors ........................... 91
Variance, Compass .................... 219,229
Vehicle Certification Label ................. 375
Vehicle Identification Number (VIN) ............ 6
Vehicle Loading ................... 342,375,376
Vehicle Modifications/Alterations .............. 7
Vehicle Storage ....................... 300,464
Vehicle Theft Alarm (Security Alarm) .......... 18Video Entertainment System™
(Rear Seat Video System)
.................. 276
Viscosity, Engine Oil ...................... 427
Voice Recognition System (VR) .............. 120
Warning Flasher, Hazard .................. 394
Warning Lights
(Instrument Cluster Description) ............. 205
Warnings and Cautions ..................... 6
Warranty Information ..................... 490
Washer, Adding Fluid ...............157,194,438
Washers, Windshield ................ 153,156,438
Washing Vehicle ......................... 452
Water Driving Through ...................... 321
Wheel Alignment and Balance ............... 354
Wheel and Wheel Trim .................... 454
Wheel and Wheel Trim Care ................ 454
518 INDEX