spark plugs DODGE JOURNEY 2009 1.G Owners Manual
[x] Cancel search | Manufacturer: DODGE, Model Year: 2009, Model line: JOURNEY, Model: DODGE JOURNEY 2009 1.GPages: 523
Page 417 of 523
MAINTAINING YOUR VEHICLE
CONTENTS
2.4L Engine Compartment ................418
2.7L Engine Compartment ................419
3.5L Engine Compartment ................420
Onboard Diagnostic System — OBD II ........421
▫ Loose Fuel Filler Cap Message ............421
Emissions Inspection And Maintenance
Programs ............................422
Replacement Parts ......................423
Authorized Dealer Service ................424
Maintenance Procedures ..................424
▫ Engine Oil ..........................424
▫ Engine Oil Filter ......................428
▫ Drive Belts — Check Condition And Tension . . 428
▫ Spark Plugs .........................429
▫ Engine Air Cleaner Filter ................429
▫ Catalytic Converter ....................429
▫ Maintenance-Free Battery ................431
▫ Air Conditioner Maintenance .............433
7
Page 431 of 523
Spark Plugs
Spark plugs must fire properly to assure engine perfor-
mance and emissions control. New plugs should be
installed at the specified mileage. The entire set should be
replaced if there is any malfunction due to a faulty spark
plug. Refer to “Fluids, Lubricants, and Genuine Parts” in
this section for the proper type of spark plug for use in
your vehicle.
Engine Air Cleaner Filter
Refer to the Maintenance Schedule in Section 8 for engine
air cleaner filter service intervals.
NOTE:Be sure to follow the “dusty or off-road condi-
tions” maintenance interval if applicable.
WARNING!
The air induction system (air cleaner, hoses, etc.,) can
provide a measure of protection in the case of engine
backfire. Do not remove the air induction system (air
cleaner, hoses, etc.,) unless such removal is necessary
for repair or maintenance. Make sure that no one is
near the engine compartment before starting the
vehicle with the air induction system (air cleaner,
hoses, etc.,) removed. Failure to do so can result in
serious personal injury.
Catalytic Converter
The catalytic converter requires the use of unleaded fuel
only. Leaded gasoline will destroy the effectiveness of the
catalyst as an emissions control device.
MAINTAINING YOUR VEHICLE 429
7
Page 476 of 523
FLUIDS, LUBRICANTS, AND GENUINE PARTS
Engine
ComponentFluids, Lubricants, and Genuine Parts
Engine Coolant Mopar
Antifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid
Organic Additive Technology) or equivalent
Engine Oil (2.4L) Use API Certified SAE 5W-20 Engine Oil meeting the requirements of
Chrysler Material Standard MS-6395. Refer to the engine oil fill cap for cor-
rect SAE grade.
Engine Oil (2.7L) Use API Certified SAE 5W-20 Engine Oil meeting the requirements of
Chrysler Material Standard MS-6395. Refer to the engine oil fill cap for cor-
rect SAE grade.
Engine Oil (3.5L) Use API Certified SAE 10W-30 Engine Oil meeting the requirements of
Chrysler Material Standard MS-6395. Refer to the engine oil fill cap for cor-
rect SAE grade.
Oil Filter (2.4L) Mopar04884900AB or equivalent
Oil Filter (2.7L) Mopar04884899AB or equivalent
Oil Filter (3.5L) Mopar04884899AB or equivalent
Spark Plugs (2.4L) ZFR5F-11 (Gap.044 in [1.12 mm])
474 MAINTAINING YOUR VEHICLE
Page 477 of 523
ComponentFluids, Lubricants, and Genuine Parts
Spark Plugs (2.7L) TE10MCC5 (Gap.050 in [1.27 mm])
Spark Plugs (3.5L) ZFR5LP-13G (Gap.050 in [1.27 mm])
Fuel Selection (2.4L) 87 Octane
Fuel Selection (2.7L) 87 Octane
Fuel Selection (2.7L - EXCEPT CALI-
FORNIA EMISSION STATES) E-85 Ethanol
Fuel Selection (3.5L) 87 to 89 Octane
MAINTAINING YOUR VEHICLE 475
7
Page 484 of 523
Perform Maintenance Every(Where time and mileage
are listed, follow the interval that occurs first.)
Maintenance Items MilesKilometers or Months
Replace the spark plugs on 2.4L and 2.7L engines. 30,00050 000 30
Change Rear Drive Assembly (RDA) fluid. 60,000100 000 60
Change Power Transfer Unit (PTU) fluid. 60,000100 000 60
Change the automatic transaxle fluid and filter if us-
ing your vehicle for any of the following: police, taxi,
fleet, or frequent trailer towing. 60,000
100 000 60
Inspect and replace PCV valve if necessary. † 90,000150 000 90
Flush and replace the engine coolant. 102,000170 000 60
Replace the spark plugs on 3.5L engines. 102,000170 000 102
Replace the timing belt on 3.5L engines. 102,000170 000 102
Change the automatic transaxle fluid and filter. 120,000200 000 120
Replace the accessory drive belt on 2.4L and 2.7L en-
gines. 120,000
200 000 120
482 MAINTENANCE SCHEDULES
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S
Page 516 of 523
Security Alarm (Theft Alarm).............18,208
Selection of Coolant (Antifreeze) ..........441,474
Selection of Oil ......................... 426
Sentry Key (Immobilizer) ................... 15
Sentry Key Programming ................... 17
Sentry Key Replacement ................... 16
Service Assistance ....................... 487
Service Contract ......................... 489
Service Engine Soon Light
(Malfunction Indicator) .................... 215
Service Manuals ........................ 492
Setting the Clock ................ 236,240,255,267
Settings, Personal ........................ 230
Shifting Automatic Transaxle .................... 311
Shoulder Belt Upper Anchorage .............. 46
Shoulder Belts ........................... 41
Side Airbag ........................... 52,58
Side Curtain (Window Airbag) ............... 52Side View Mirror Adjustment
................ 89
Side Window Demisters (Defrosters) .......... 301
Signals, Turn ................... 81,149,207,468
Sirius Backseat TV™ ..................... 276
Slippery Surfaces, Driving On ............... 320
Snow Chains (Tire Chains) ................. 355
Snow Tires ............................ 355
Sound Systems (Radio) .................234,266
Spare Tire ....................... 349,350,397
Spark Plugs ......................... 429,474
Specifications Fuel (Gasoline) ........................ 474
Oil .............................. 426,474
Speed Control (Cruise Control) .............. 159
Speedometer ........................... 207
Starting ............................. 27,307
Automatic Transmission ................. 308
Cold Weather ......................... 309
Emergency (Jump Starting) ............... 407
514 INDEX