transmission DODGE JOURNEY 2016 1.G Repair Manual

4. Place the shift lever momentarily into each gear posi-tion (allowing time for the transmission to fully en-
gage in each position), ending with the transmission in
PARK.
5. Wipe the area around the dipstick clean to prevent dirt from entering the transmission.
6. Remove the dipstick and determine if the fluid is hot or cold. You can also read the transmission fluid
temperature using the Vehicle Information display in
the Electronic Vehicle Information Center (EVIC) in
the instrument cluster. Refer to Electronic Vehicle
Information Center (EVIC) inUnderstanding Your
Instrument Panel for further information. Hot fluid is
approximately 180°F (82°C), which is the normal op-
erating temperature after the vehicle is driven at least
15 miles (24 km). Hot fluid cannot be held comfortably
between the fingertips. Cold fluid is at a temperature
of approximately 80°F (27°C). 7. Wipe the dipstick clean and reinsert it until seated.
Then, remove the dipstick and note the fluid level on
both sides. The fluid level reading is only valid if there
is a solid coating of oil on both sides of the dipstick.
Note that the holes in the dipstick will be full of fluid
if the actual level is at or above the hole.
• If the fluid is hot, the fluid level should be in the
crosshatched area marked “HOT” (between the up-
per two holes in the dipstick).
• If the fluid is cold, the fluid level should be between
the lower two holes in the area marked “COLD”.
If the fluid level is low, add fluid through the dipstick
tube to bring it to the proper level. Do not overfill. After
adding any quantity of oil through the dipstick tube, wait
at least two minutes for the oil to fully drain into the
transmission before rechecking the fluid level.
7
MAINTAINING YOUR VEHICLE 589

NOTE:If it is necessary to check the transmission below
the operating temperature, the fluid level should be
between the two COLD (lower) holes on the dipstick
with the fluid at approximately 80°F (27°C). If the fluid
level is correctly established at 80°F (27°C), it should be
between the HOT (upper) reference holes when the
transmission reaches 180°F (82°C). Remember it is best to
check the level at the normal operating temperature.
8. Check for leaks. Release the parking brake.CAUTION!
• Using a transmission fluid other than the manufac-
turer’s recommended fluid may cause deterioration
in transmission shift quality and/or torque con-
verter shudder, and will require more frequent
fluid and filter changes. Refer to “Fluids, Lubri-
cants, And Genuine Parts” in this section for fluid
specifications.
• Dirt and water in the transmission can cause seri-
ous damage. To prevent dirt and water from enter-
ing the transmission after checking or replenishing
fluid, make sure that the dipstick cap is re-seated
properly.
Fluid Level Check — Six-Speed Automatic
Transmission
The fluid level is preset at the factory and does not
require adjustment under normal operating conditions.
590 MAINTAINING YOUR VEHICLE

Routine fluid level checks are not required, therefore the
transmission filler tube is capped and no dipstick is
provided. Your authorized dealer can check your trans-
mission fluid level using a special service dipstick. If you
notice fluid leakage or transmission malfunction, visit
your authorized dealer immediately to have the trans-
mission fluid level checked. Operating the vehicle with
an improper fluid level can cause severe transmission
damage.
CAUTION!
If a transmission fluid leak occurs, visit your autho-
rized dealer immediately. Severe transmission dam-
age may occur. Your authorized dealer has the proper
tools to adjust the fluid level accurately.
Fluid And Filter Changes
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.In addition, change the fluid and filter if the fluid
becomes contaminated (with water, etc.), or if the trans-
mission is disassembled for any reason.
Rear Drive Assembly (RDA) – AWD Models Only
Lubricant Selection
Use only the manufacturer’s recommended fluid. Refer
to “Fluids, Lubricants, And Genuine Parts” in “Maintain-
ing Your Vehicle” for further information.
Fluid Level Check
Visually inspect the unit at each oil change for leakage. If
leakage is detected, check the fluid level by removing the
fill plug. The fluid level should be maintained between
the bottom of the fill hole to 1/8 inch (4 mm) below the
fill hole.
Add fluid, if necessary, to maintain the proper level.7
MAINTAINING YOUR VEHICLE 591

Chassis
ComponentFluid, Lubricant, or Genuine Part
Automatic Transmission Use only ATF+4 Automatic Transmission Fluid.
Failure to use ATF+4 fluid may affect the function or
performance of your transmission.
We recommend MOPAR ATF+4 fluid.
Power Transfer Unit (PTU) We recommend you use MOPAR Gear Lubricant 75W-
90.
Rear Drive Assembly (RDA) We recommend you use MOPAR Gear Lubricant 75W-
90.
Brake Master Cylinder We recommend you use MOPAR DOT 3, SAE J1703. If
DOT 3 brake fluid is not available, then DOT 4 is ac-
ceptable.
Power Steering Reservoir We recommend you use MOPAR Power Steering Fluid
+ 4, or MOPAR ATF+4 Automatic Transmission Fluid.
618 MAINTAINING YOUR VEHICLE

Once A Month Or Before A Long Trip:
•Check engine oil level.
• Check windshield washer fluid level.
• Check tire pressure and look for unusual wear or
damage. Rotate tires at the first sign of irregular wear,
even if it occurs before the oil indicator system turns
on.
• Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering and transmission (4-
speed only) and fill as needed.
• Check function of all interior and exterior lights.
Required Maintenance Intervals.
Refer to the Maintenance Schedules on the following
page for the required maintenance intervals.At Every Oil Change Interval As Indicated By Oil Change Indicator System:
•Change oil and filter.
• Rotate the tires. Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
• Inspect battery and clean and tighten terminals as
required.
• Inspect automatic transmission fluid if equipped
with dipstick.
• Inspect brake pads, shoes, rotors, drums, hoses
and park brake.
• Inspect engine cooling system protection and
hoses.
• Inspect exhaust system.
• Inspect engine air cleaner if using in dusty or
off-road conditions. 8
MAINTENANCE SCHEDULES 621

Alterations/Modifications, Vehicle...............7
Antifreeze (Engine Coolant) ...............580, 614
Disposal ............................. .583
Anti-Lock Brake System (ABS) ................450
Anti-Lock Warning Light ....................321
Appearance Care ........................ .592
Arming System (Security Alarm) ...............18
Assist, Hill Start ......................... .453
Auto Down Power Windows ..................42
Automatic Dimming Mirror ..................119
Automatic Door Locks ....................32, 33
Automatic Headlights ..................... .225
Automatic Oil Change Indicator ...............331
Automatic Transmission .................429, 587
Adding Fluid ...................588, 590, 618
Fluid And Filter Changes ..................591
Fluid Level Check ...................588, 590
Fluid Type ........................... .618
Gear Ranges .......................... .433Special Additives
...................... .588
Autostick .............................. .439
Auto Unlock, Doors ........................33
Auxiliary Electrical Outlet (Power Outlet) ........268
Auxiliary Power Outlet .....................268
Back-Up Lights .......................... .610
Battery ............................ .309, 569
Charging System Light ...................309
Keyless Transmitter Replacement (RKE) ........24
Location ............................. .569
Belts, Seat .............................. .109
Bluetooth Connecting To A Particular Mobile Phone Or
Audio Device After Pairing ................157
Connect Or Disconnect Link Between the Uconnect
Phone And Mobile Phone ..............143, 173
Pair (Link) Uconnect Phone To A Mobile
Phone ........................... .129, 153
10
INDEX 639

Body Mechanism Lubrication.................573
B-Pillar Location ......................... .470
Brake Assist System ...................... .453
Brake Control System, Electronic ..............450
Brake Fluid ............................ .618
Brake, Parking .......................... .446
Brakes ................................ .449
Brake System ........................ .449, 585
Fluid Check ....................... .586, 618
Master Cylinder ....................... .586
Parking ............................. .446
Warning Light ........................ .304
Brake/Transmission Interlock .................431
Brightness, Interior Lights ...................230
Bulb Replacement ..................... .606, 608
Bulbs, Light ..........................111,606
Camera, Rear ........................... .250
Capacities, Fluid ......................... .614Caps, Filler
Fuel ................................ .505
Oil (Engine) ....................... .559, 567
Power Steering ........................ .445
Radiator (Coolant Pressure) ................583
Carbon Monoxide Warning ...............108, 502
Cargo Area Cover ........................ .286
Cargo Area Features ...................... .282
Cargo Compartment ...................... .282
Light ............................... .282
Luggage Carrier ....................... .290
Cargo Load Floor ........................ .283
Cargo Management System ..................283
Rollaway Tonneau Cover ..................286
Tri-Fold Load Floor ..................... .283
Cargo Tie-Downs ........................ .284
Cargo (Vehicle Loading) .................283, 508
Car

Washes ............................ .593
Certification Label ........................ .508
640 INDEX

Cooling System.......................... .579
Adding Coolant (Antifreeze) ...............581
Coolant Capacity ...................... .614
Coolant Level ..................... .579, 584
Disposal Of Used Coolant .................583
Drain, Flush, And Refill ...................580
Inspection ........................... .584
Points To Remember .....................584
Pressure Cap ......................... .583
Radiator Cap ......................... .583
Selection Of Coolant (Antifreeze) ......580, 614, 616
Corrosion Protection ...................... .592
Cruise Light ............................ .325
Cupholders ......................... .274, 599
Customer Assistance ...................... .629
Data Recorder, Event .......................77
Daytime Brightness, Interior Lights .............231
Daytime Running Lights ....................226 Dealer Service
........................... .563
Defroster, Rear Window .....................290
Defroster, Windshield ..................... .109
Delay (Intermittent) Wipers ..................232
Diagnostic System, Onboard .................561
Dimmer Switch, Headlight ...................229
Dipsticks Automatic Transmission ...............588, 590
Oil (Engine) .......................... .565
Power Steering ........................ .445
Disabled Vehicle Towing ....................552
Disposal Antifreeze (Engine Coolant) ................583
Door Ajar .......................... .312, 313
Door Ajar Light ...................... .312, 313
Door Locks Door Locks ............................30
KeyFob...............................30
Remote ...............................30
642 INDEX

Flexible Fuel VehiclesCruising Range ........................ .505
Engine Oil ........................... .504
Fuel Requirements ...................502, 503
Maintenance .......................... .505
Replacement Parts ...................... .505
Starting ............................. .504
Flooded Engine Starting ....................427
Floor Console ........................... .277
Fluid, Brake ............................ .618
Fluid Capacities ......................... .614
Fluid Leaks ..............................111
Fluid Level Checks Automatic Transmission ...............588, 590
Brake ........................... .586, 618
Cooling System ........................ .579
Engine Oil ........................... .565
Power Steering ..................... .445, 618
Fluids, Lubricants And Genuine Parts ...........616Fog Lights
.......................... .227, 609
Fog Light Service ........................ .609
Folding Rear Seat ..................... .213, 220
Freeing A Stuck Vehicle .....................550
Fuel .................................. .498
Adding ............................. .505
Additives ............................ .500
Clean Air ............................ .498
Conserving ........................... .332
Ethanol .......................... .499, 502
Filler Cap (Gas Cap) .....................505
Gasoline ............................. .498
Light ............................... .322
Materials Added ....................... .500
Methanol ............................ .499
Octane Rating ..................... .498, 616
Requirements ......................... .498
Saver

Mode .......................... .332
Specifications ......................... .61610
INDEX 645

Rear Folding...................... .213, 220
Reclining ............................ .204
Reclining Rear ..................... .216, 220
Seatback Release .................206, 213, 220
Tilting .............................. .199
Security Alarm ........................ .18, 306
Selection Of Coolant (Antifreeze) ..............616
SENTRY KEY Key Programming .......................18
Sentry Key (Immobilizer) ....................16
Sentry Key Replacement .....................17
Service Assistance ........................ .629
Service Contract ......................... .631
Service Manuals ......................... .634
Shift Lever Override ...................... .551
Shoulder Belts ............................50
Side View Mirror Adjustment .................121
Signals, Turn ...................111, 228, 324, 610
Snow Chains (Tire Chains) ...................488 Snow Tires
............................. .480
Spare Tire .....................481, 482, 483, 533
Spark Plugs ............................ .616
Specifications Fuel (Gasoline) ........................ .616
Oil................................. .616
Speed Control Accel/Decel .......................... .241
Cancel .............................. .240
Resume ............................. .240
Speed Control (Cruise Control) ................238
Starting ............................. .26, 424
Automatic Transmission ..................424
Cold Weather ......................... .427
Engine Fails To Start .....................427
Remote ...............................26
Starting And Operating .....................424
Starting Procedures ....................... .424
10
INDEX 655