steering DODGE MAGNUM 2007 1.G Owner's Guide

FREEING A STUCK VEHICLE
If your vehicle becomes stuck in mud, sand, or snow, it
can often be moved by a rocking motion. Turn your
steering wheel right and left to clear the area around the
front wheels. Then shift back and forth between Reverse
and Drive. Usually the least accelerator pedal pressure to
maintain the rocking motion without spinning the
wheels is most effective.
NOTE:Turn off the Electronic Stability Program (ESP)
— if equipped, or Traction Control System (TCS) — if
equipped before rocking the vehicle. For details, refer to
“Electronic Stability Program,” or “Traction Control Sys-
tem” in this manual.
CAUTION!
•When “rocking” a stuck vehicle by moving be-
tween “First” and R (Reverse), do not spin the
wheels faster than 15 mph (24 km/h), or drivetrain
damage may result.
•Racing the engine or spinning the wheels too fast
may lead to transmission overheating and failure.
It can also damage the tires. Do not spin the
wheels above 35 mph (55 km/h).
WARNING!
Fast spinning tires can be dangerous. Forces gener-
ated by excessive wheel speeds may cause tire dam-
age or failure. A tire could explode and injure
someone. Do not spin your vehicle’s wheels faster
than 35 mph (55 km/h) when you are stuck, and don’t
let anyone near a spinning wheel, no matter what the
speed.
WHAT TO DO IN EMERGENCIES 297
6

MAINTAINING YOUR VEHICLE
CONTENTS

2.7L Engine Compartment...............303

3.5L Engine Compartment...............304

5.7L Engine Compartment...............305

Onboard Diagnostic System — OBD II......306
▫Loose Fuel Filler Cap..................306

Emissions Inspection And Maintenance
Programs
............................307

Replacement Parts.....................308

Dealer Service........................308

Maintenance Procedures.................309
▫Engine Oil..........................309
▫Engine Oil Filter......................314▫Drive Belts — Check Condition And Tension . . 314
▫Spark Plugs.........................314
▫Engine Air Cleaner Filter................314
▫Fuel Filter..........................315
▫Catalytic Converter....................315
▫Maintenance-Free Battery................316
▫Air Conditioner Maintenance.............318
▫A/C Air Filter — If Equipped............319
▫Power Steering — Fluid Check............319
▫Front & Rear Suspension Ball Joints........320
▫Steering Linkage......................320
7

Refrigerant Recovery and Recycling
R-134a Air Conditioning Refrigerant is a hydrofluorocar-
bon (HFC) that is endorsed by the Environmental Pro-
tection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by dealers or other service facilities
using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C System
Sealers, Stop Leak Products, Seal Conditioners, Compres-
sor Oil, and Refrigerants.
A/C Air Filter — If Equipped
The filter is located in the fresh air inlet under the hood,
behind a removable panel in the cowl on the passenger
side of the vehicle, next to the windshield wipers. When
installing a new filter, ensure its proper orientation. To
replace the filter remove the access door in the cowl
screen by pressing the retaining clips. Slide the lid on the
filter adapter forward and down and remove used filter.
Install new filter with arrows pointing in the direction of
airflow, which is toward the rear of the vehicle (text and
arrows on the filter indicate this).Refer to the “Maintenance Schedule” in this manual for
the recommended air conditioning filter replacement
intervals.
Power Steering — Fluid Check
Checking the power steering fluid level at a defined
service interval is not required. The fluid should only be
checked if a leak is suspected, abnormal noises are
apparent, and/or the system is not functioning as antici-
pated. Coordinate inspection efforts through a certified
DaimlerChrysler Dealership.
WARNING!
Fluid level should be checked on a level surface and
with the engine off to prevent injury from moving
parts and to insure accurate fluid level reading. Do
not overfill. Use only manufacturer’s recommended
power steering fluid.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
MAINTAINING YOUR VEHICLE 319
7

surfaces. Refer to “Fluids, Lubricants, and Genuine
Parts” in this section for the correct fluid type.
Front & Rear Suspension Ball Joints
The suspension ball joints should be inspected for exter-
nal leakage or damage when other maintenance is per-
formed.
Steering Linkage
The tie rod end ball joints should be inspected for
external leakage or damage when other maintenance is
performed.
Body Lubrication
Locks and all body pivot points, including seat tracks,
door hinges, liftgate hinges, and hood hinges, should be
lubricated periodically to assure quiet, easy operation
and to protect against rust and wear. Prior to the appli-
cation of any lubricant, the parts concerned should be
wiped clean to remove dust and grit; after lubricating
excess oil and grease should be removed. Particular
attention should also be given to hood latching compo-
nents to insure proper function. When performing other
underhood services, the hood latch, release mechanism,
and safety catch should be cleaned and lubricated.The external lock cylinders should be lubricated twice a
year, preferably in the fall and spring. Apply a small
amount of a high quality lubricant such as MoparLock
Cylinder Lubricant or equivalent directly into the lock
cylinder.
Wiper Blades
Clean the rubber edges of the wiper blades and the
windshield and rear window periodically with a sponge
or soft cloth and a mild nonabrasive cleaner. This will
remove accumulations of salt or road film.
Operation of the wipers on dry glass for long periods
may cause deterioration of the wiper blades. Always use
washer fluid when using the wipers to remove salt or dirt
from a dry windshield or rear window.
Avoid using the wiper blades to remove frost or ice from
the windshield or rear window. Keep the blade rubber
out of contact with petroleum products such as engine
oil, gasoline, etc.
320 MAINTAINING YOUR VEHICLE

WARNING!
Riding the brakes can lead to brake failure and
possibly an accident. Driving with your foot resting
or riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You wouldn’t have your full
braking capacity in an emergency.
Brake and Power Steering Hoses
When the vehicle is serviced for scheduled maintenance,
inspect surface of hoses and nylon tubing for evidence of
heat and mechanical damage. Hard and brittle rubber,
cracking, tears, cuts, abrasion, and excessive swelling
indicate deterioration of the rubber. Particular attention
should be made to examining those hose surfaces nearest
to high heat sources, such as the exhaust manifold.
Insure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
NOTE:
•
Often, fluid such as oil, power steering fluid, and
brake fluid are used during assembly plant operations
to facilitate the assembly of hoses to couplings. There-
fore, oil wetness at the hose-coupling area is not
necessarily an indication of leakage. Actual dripping
of hot fluid when systems are under pressure (during
vehicle operation), should be noted before a hose is
replaced based on leakage.
•Inspect the brake hoses whenever the brake system is
serviced and at every engine oil change. Inspect hy-
draulic brake hoses for surface cracking, scuffing, or
worn spots. If there is any evidence of cracking,
scuffing, or worn spots, the hose should be replaced
immediately! Eventual deterioration of the hose can
take place resulting in a possibility of a burst failure.
328 MAINTAINING YOUR VEHICLE

Cavity Car-
tridge
FuseMini
FuseDescription
13*———
14 — 10 Amp
RedAC Heater Control/
Cluster/Sentry Key Re-
mote Keyless Entry
15 — 20 Amp
YellowTrailer Tow Brake Mod-
ule - if equipped
16 — 20 Amp
YellowRear Power Outlet
17 — 20 Amp
YellowCluster
18 — 20 Amp
YellowSelectable Power Outlet
19 — 10 Amp
RedStop Lights
20 — 20 Amp
YellowRear Wiper
21 — — —
22 — — —
23 — — —Cavity Car-
tridge
FuseMini
FuseDescription
24 — — —
25 — — —
26 — — —
27 — 10 Amp
RedAirbag/Airbag Control
Module (ACM)
28 — 10 Amp
RedCurtain Airbag - if
equipped
29 — 5 Amp
OrangeAnti-lock Brakes Module
- if equipped/Cluster/
Front Control Module
(FCM)/Powertrain Con-
trol Module (PCM)/
Sentry Key Remote Key-
less Entry/Stop Lights
30 — 10 Amp
RedDoor Modules/Power
Mirrors - if equipped/
Steering Control Module
31 — — —
32 — — —
MAINTAINING YOUR VEHICLE 341
7

Chassis
Component Fluids, Lubricants, and Genuine Parts
Automatic Transmission MoparATF+4 Automatic Transmission Fluid.
Brake Master Cylinder MoparDOT 3, SAE J1703 should be used. If DOT 3, SAE J1703 brake
fluid is not available, then DOT 4 is acceptable. Use only recommended
brake fluids.
Front Axle API Certified GL-5 SAE 75W90 Synthetic Gear Lubricant or equivalent.
Power Steering Reservoir MoparPower Steering Fluid + 4, MoparATF+4 Automatic Transmission
Fluid.
Rear Axle API Certified GL-5 SAE 75W140 Synthetic Gear Lubricant or equivalent.
Transfer Case MoparTransfer Case Lubricant LX, P/N 05170055AA, or equivalent.
352 MAINTAINING YOUR VEHICLE

Flooded, Starting..................... 209
Fuel Requirements.................261,350
Oil ..........................309,350,351
Oil Change Interval................... 311
Oil Filler Cap........................ 312
OilSelection ...................... 311,350
Oil Synthetic......................... 313
Overheating......................... 284
Temperature Gauge................... 141
Enhanced Accident Response Feature......... 48
Ethanol.............................. 262
Event Data Recorder..................... 49
Exhaust Gas Caution............. 32,60,264,321
Exhaust System...................... 60,321
ExteriorFoldingMirrors .................. 68
ExteriorLighting ........................ 96
Filters
Air Cleaner.......................... 314
Air Conditioning..................199,319
Engine Fuel......................... 315
Engine Oil.......................314,351
Engine Oil Disposal................... 313Flashers
Hazard Warning...................... 284
Turn Signal........................ 99,142
Flash-To-Pass........................... 99
Flat Tire Changing...................... 286
Flooded Engine Starting.................. 209
Floor Console.......................... 122
Fluid Capacities........................ 350
Fluid Leaks............................ 62
Fluid Level Checks
Brake .............................. 329
Cooling System....................... 322
Engine Oil.......................309,310
Power Steering....................... 319
Fluids ............................... 351
Fluids, Lubricants and Genuine Parts........ 351
FogLights .......................... 98,144
Folding Rear Seat....................... 94
FreeingAStuckVehicle .................. 297
Front Suspension Ball Joints............... 320
Front Wheel Bearings.................... 332
Fuel................................. 261
Adding............................. 265
386 INDEX

Odometer............................ 140
Trip ............................... 140
Oil, Engine.........................309,351
Capacity............................ 350
Change Interval...................... 311
Checking........................309,310
Dipstick .........................309,310
Disposal............................ 313
Filter...........................314,351
Filter Disposal....................... 313
Identification Logo.................... 312
Materials Added to.................... 313
Recommendation.................. 311,350
Synthetic........................... 313
Viscosity.........................312,350
Onboard Diagnostic System............306,307
Opener, Garage Door (HomeLink) ......... 110
Operating Precautions................... 306
Outside Rearview Mirrors................. 68
Overdrive............................ 216
Overhead Console...................... 109
Overheating, Engine..................141,284
Owner’s Manual (Operator Manual)......... 377Panic Alarm........................... 20
Parking Brake......................... 225
ParkingOnHill ........................ 225
Passing Light........................... 99
Pedals, Adjustable...................... 105
Personal Settings....................... 156
Pets .................................. 58
Phone, Cellular......................... 70
Phone, Hands-Free (UConnect™)............ 70
Placard, Tire and Loading Information....... 240
Power
Brakes............................. 226
Distribution Center (Fuses).............. 337
Door Locks.......................... 23
Mirrors ............................. 69
Outlet (Auxiliary Electrical Outlet)........ 118
Seats............................... 90
Steering .........................229,319
Steering, Checking.................... 319
Sunroof............................ 115
Windows............................ 27
Pregnant Women and Seat Belts............. 40
Preparation for Jacking................... 286
INDEX 391
10

Starting .............................. 208
Automatic Transmission................ 209
Engine Fails to Start................... 209
Starting and Operating................... 208
Starting Procedures..................... 208
Steering
Column Controls...................... 99
Linkage............................ 320
Power...........................229,319
TiltColumn ......................... 104
Wheel, Tilt.......................... 104
Steering Wheel Mounted Sound System
Controls.............................. 187
Storage...........................122,344
Storage, Vehicle.....................198,344
StoringYourVehicle ..................... 344
Sun Roof............................. 115
Sunglasses Storage...................... 109
Supplemental Restraint System - Airbag....... 41
Synthetic Engine Oil..................... 313
System, Navigation..................... 179
Tachometer........................... 140Telescoping Steering Column.............. 104
Temperature Control, Automatic (ATC)....... 193
Temperature Gauge, Engine Coolant......141,285
Tether Anchor, Child Restraint.............. 54
Theft Alarm (Security Alarm)............... 15
Theft System (Security Alarm).............. 15
Tie Down Hooks, Cargo.................. 128
TiltSteeringColumn .................... 104
Tire and Loading Information Placard....... 240
Tire Identification Number (TIN)........... 239
TireMarkings ......................... 236
TireSafetyInformation ................... 236
Tires ........................... 61,244,378
Aging(LifeofTires) ................... 250
Air Pressure......................... 244
Alignment.......................... 251
Chains............................. 252
Changing........................286,289
Compact Spare....................... 247
Flat Changing........................ 286
General Information................... 244
High Speed......................... 246
Inflation Pressures.................... 245
394 INDEX