clock DODGE NEON 1997 1.G Wiring Diagrams Workshop Manual
[x] Cancel search | Manufacturer: DODGE, Model Year: 1997, Model line: NEON, Model: DODGE NEON 1997 1.GPages: 256, PDF Size: 2.99 MB
Page 15 of 256

Downloaded from www.Manualslib.com manuals search engine 8W-02 COMPONENT INDEX
INDEX
page
SCHEMATICS AND DIAGRAMS........................................................... 1
DESCRIPTION AND OPERATION.......................................................... 3
Component Page
A/C Compressor Clutch.................8W-42
A/C Compressor Clutch Relay............8W-42
A/C Cycling Switch....................8W-42
A/C Heater Blower Motor................8W-42
A/C Heater Control Switch...............8W-42
A/C High Pressure Switch...............8W-42
A/C Low Pressure Switch................8W-42
ABS Hydraulic Modulator...............8W-35
ABS Pump Motor......................8W-35
ABS Pump Motor Relay.................8W-35
ABS Relay Box........................8W-35
ABS System Relay.....................8W-35
ABS Warning Lamp....................8W-35
Airbag Control Module..................8W-43
Airbag Impact Sensors..................8W-43
Airbag Warning Lamp..................8W-40
Antenna.............................8W-47
Anti-Lock Warning Lamp................8W-40
Ash Receiver Lamp....................8W-44
Automatic Shut Down Relay.............8W-30
Back-Up Lamp Switch..................8W-51
Back-Up Lamps.......................8W-51
Battery..............................8W-20
Battery Temperature Sensor.............8W-30
Blower Motor Resistor Block.............8W-42
Brake Warning Lamp...................8W-40
Brake Warning Lamp Switch.............8W-40
Camshaft Position (CMP) Sensor..........8W-30
Capacitor.........................8W-10, 20
Charge Indicator Lamp.................8W-40
Check Engine Lamp....................8W-40
Cigar Lighter Relay....................8W-41
Cigar Lighter/Power Outlet..............8W-41
Circuit Breaker.....................8W-11,62
Circuit Breaker (FB)...................8W-11
Clockspring..........................8W-41
Cluster Illumination Lamps..............8W-40
Clutch Pedal Position Switch..........8W-10, 21
Combination Flasher...................8W-52
Controller Anti-Lock Brake..............8W-35
Crankshaft Position (CKP) Sensor.........8W-30
Data Link Connector...................8W-30
Diode............................8W-15, 42
Dome Lamp..........................8W-44Component Page
Door Ajar Switches.....................8W-44
Door Jamb Switches....................8W-40
Door Lock Motors......................8W-61
Door Lock Switches....................8W-61
Door Speakers........................8W-47
Driver Side Airbag.....................8W-43
Duty Cycle Evap/Purge Solenoid..........8W-30
EGR Transducer Solenoid...............8W-30
Engine Coolant Temperature (ECT) Sensor . . 8W-30
Engine Coolant Temperature Gauge.......8W-40
Engine Oil Pressure Switch..............8W-40
Engine Starter Motor...................8W-21
Engine Starter Motor Relay..............8W-21
Fog Lamp Relay....................8W-50, 51
Fog Lamps........................8W-50, 51
Front Fog Lamp Switch.................8W-50
Fuel Gauge...........................8W-40
Fuel Injectors.........................8W-30
Fuel Pump Module.....................8W-30
Fuel Pump Relay......................8W-30
Fuse Block...........................8W-11
Fuses (FB)...........................8W-11
Fuses (PDC)..........................8W-10
Fusible Link.......................8W-20, 21
Generator............................8W-20
Glove Box Lamp And Switch.............8W-44
Ground Distribution....................8W-15
Headlamp Dimmer And Optical
Horn Switch........................8W-50
Headlamp Leveling Motors..............8W-50
Headlamp Leveling Switch...............8W-50
Headlamp Switch......................8W-50
Headlamps...........................8W-50
Heated Oxygen Sensors.................8W-30
High Beam Indicator Lamp..............8W-40
Horn Relay...........................8W-41
Horn Switches........................8W-41
Horns...............................8W-41
IAT/MAP Sensor......................8W-30
Idle Air Control (IAC) Motor.............8W-30
Ignition Coil Pack.....................8W-30
Ignition Switch........................8W-10
Immobilizer Engine Sensor..............8W-30
Immobilizer Sensor....................8W-30
PL8W - 02 COMPONENT INDEX 8W - 02 - 1
Page 103 of 256

Downloaded from www.Manualslib.com manuals search engine 8W-41 HORNS/CIGAR LIGHTER
INDEX
page
SCHEMATICS AND DIAGRAMS........................................................... 1
DESCRIPTION AND OPERATION.......................................................... 4
Component Page
Cigar Lighter Relay..................8W-41-3
Cigar Lighter/Power Outlet.............8W-41-3
Clockspring.........................8W-41-2
Fuse 1 (FB).........................8W-41-3
Fuse 3 (PDC)........................8W-41-3
Fuse 15 (FB)........................8W-41-3
Fuse 23 (PDC).......................8W-41-2
Fuse Block.........................8W-41-3
G101..............................8W-41-2
G103..............................8W-41-2
G204..............................8W-41-3
Horn No. 1.........................8W-41-2Component Page
Horn No. 2.........................8W-41-2
Horn Relay.........................8W-41-2
Left Horn Switch.....................8W-41-2
Power Distribution Center...........8W-41-2, 3
Right Horn Switch...................8W-41-2
S108..............................8W-41-2
S111 ..............................8W-41-2
S117 ..............................8W-41-2
S131..............................8W-41-2
S202..............................8W-41-3
S206..............................8W-41-3
S213..............................8W-41-3
8W - 41 - 2 8W - 41 HORNS/CIGAR LIGHTERPL
Page 104 of 256

Downloaded from www.Manualslib.com manuals search engine BATT A0
23FUSE10A
POWER
DISTRIBUTION
CENTER
RELAY HORN
6266
6365
CLOCKSPRING
1
SWITCH
HORN
LEFT
SWITCH HORN
RIGHT
5C101
X3
20
BK/RD
B A
BK14Z1
G101 S108
BK14Z1
S111
Z1
20
BK
X2
18
DG/RD
23
23
X3
18
BK/RD
DG/RD18 X2
BK20Z1
S117
Z1
14
BK
G103
A
B
S131
X2
18
DG/RD
HORN
NO. 1 NO. 2HORN
(8W-10-9)(8W-10-4)
(8W-10-4)
(8W-15-2) (8W-15-2) (8W-15-2)
(8W-15-4)
(8W-15-2)
8W - 41 - 2 8W-41 HORN/CIGAR LIGHTER/POWER OUTLETPL-RHD
978W-1PLR04101
Page 119 of 256

Downloaded from www.Manualslib.com manuals search engine 8W-43 AIRBAG SYSTEM
DESCRIPTION AND OPERATION
AIRBAG CONTROL MODULE (ACM)
Two different circuits supply battery voltage from
the fuse block to the Airbag Control Module (ACM),
F15 and F25. The F15 and F25 circuits are connected
to separate bus bars internal to the fuse block. Dif-
ferent circuits from the Power Distribution Center
(PDC) and ignition switch supply battery voltage to
the fuse block bus bars.
The F25 circuit supplies battery voltage to the
ACM only when the ignition switch is in the RUN
position. The F15 circuit powers the ACM when the
ignition switch is in either the START or RUN posi-
tion.
An internal bus bar in the ignition switch connects
the A1 circuit from the PDC to the A21 circuit when
the switch is either the START or RUN position. The
A21 circuit supplies battery voltage to the bus bar in
the fuse block that feeds the F15 circuit. A 30 amp
fuse in the PDC protects the A1 and A21 circuits. A
10 amp fuse in the fuse block, cavity 9, protects the
F15 circuit.
When the ignition switch is in the RUN position, it
connects the A2 circuit from the PDC to the A22 cir-
cuit. The A22 circuit supplies battery voltage to the
fuse block bus bar that feeds the F25 circuit. A 40
amp fuse in the PDC protects the A2 and A22 cir-
cuits. A 10 amp fuse in the fuse block, cavity 5, pro-
tects the F25 circuit.
Circuits D1 and D2 are connected to the CCD Bus
and the ACM. The CCD bus is used to provide com-
munications between modules and the universal data
link connector.
The ACM has a case ground and an external dedi-
cated ground, circuit Z6. The dedicated ground con-
nects to the instrument panel right center support.
AIRBAG IMPACT SENSOR
The Airbag system uses a sensor internal to the
Airbag Control Module (ACM) to detect impact. For
information regarding operation of this sensor, refer
to the appropriate group of the Service Manual.
AIRBAG SQUIB (AIRBAG IGNITER)
DRIVERS SIDE AIRBAG
Two circuits, R43 and R45, connect the ACM to the
drivers side airbag module squib (igniter) after pass-
ing through the clock spring connector. Circuit R43
from cavity 3 of the ACM 4-way connector connects
to the squib. Circuit R45 from cavity 4 of the ACM
4-way connector connects to the squib. R43 and R45
are a twisted pair of wires.
PASSENGERS SIDE AIRBAG
Two circuits, R42 and R44, connect the ACM to the
passengers side airbag module squib (igniter). Circuit
R42 from cavity 1 of the ACM 4-way connector con-
nects to the squib. Circuit R44 from cavity 2 of the
ACM 4- way connector connects to the squib. R42
and R44 are a twisted pair of wires.
Circuits R50 and R51 are connected from the ACM
to the passangers airbag. These circuits are used to
monitor the pressure switch.
AIRBAG WARNING LAMP
The Airbag Warning lamp is used to alert the oper-
ator of a problem with the Airbag system. The lamp
is illuminated when the Airbag Control Module
(ACM) grounds the R41 circuit. Refer to the appro-
priate section of the Service Manual or Diagnostic
Test Procedures Manual to diagnosis this system.
HELPFUL INFORMATION
²Check for blown fuses in the circuit that connect
to the ignition switch and those that connect to the
ACM.
²While the bus bars in the fuse block power the
ACM, they also feed additional components on sepa-
rate fuse protected circuits.
²The ACM has a case ground and an external
dedicated ground. The dedicated ground connects to
the instrument panel right center support.
PL8W - 43 AIRBAG SYSTEM 8W - 43 - 5
Page 189 of 256

Downloaded from www.Manualslib.com manuals search engine 8W-80 CONNECTOR PIN-OUTS
INDEX
page
SCHEMATICS AND DIAGRAMS........................................................... 1
Component Page
A/C Compressor Clutch................8W-80-4
A/C Cycling switch...................8W-80-4
A/C-Heater Blower Motor..............8W-80-4
A/C-Heater Control Switch.............8W-80-4
A/C High Pressure Switch..............8W-80-4
A/C Low Ptressure Switch..............8W-80-5
ABS Hydraulic Modulator..............8W-80-5
ABS Relay Box......................8W-80-5
Airbag Control Module................8W-80-5
Ash Receiver lamp...................8W-80-6
Back-Up Lamp Switch (MTX)...........8W-80-6
Battery Temperature Sensor............8W-80-6
Blower Motor Resister Block............8W-80-6
Brake Warning Lamp Switch...........8W-80-6
C101..............................8W-80-7
C102..............................8W-80-7
C103..............................8W-80-7
C105..............................8W-80-8
C108..............................8W-80-8
C160..............................8W-80-8
C161..............................8W-80-8
C203..............................8W-80-9
C205..............................8W-80-9
C206..............................8W-80-9
C225..............................8W-80-9
C230.............................8W-80-10
C231.............................8W-80-10
C241.............................8W-80-10
C301.............................8W-80-11
C303.............................8W-80-11
C309.............................8W-80-11
C315.............................8W-80-11
C323.............................8W-80-11
C324.............................8W-80-11
C325.............................8W-80-12
C340.............................8W-80-12
C341.............................8W-80-12
Camshaft Position Sensor.............8W-80-12
Clockspring........................8W-80-12
Clutch Pedal Position Switch (MTX).....8W-80-12
Controller Anti-Lock Brake............8W-80-13
Crankshaft Position Sensor............8W-80-14
Data Link Connector.................8W-80-14
Dome Lamp........................8W-80-14
Downstream Heated Oxygen Sensor.....8W-80-15Component Page
Driver Side Airbag..................8W-80-15
Duty Cycle Evap/Purge Solenoid........8W-80-15
EGR Transducer solenoid.............8W-80-15
Engine Coolant Temperature
Sensor (ECT).....................8W-80-15
Engine Oil Pressure Switch............8W-80-16
Front Fog Lamp Switch...............8W-80-16
Fuel Injector No.1...................8W-80-16
Fuel Injector No.2...................8W-80-16
Fuel Injector No.3...................8W-80-16
Fuel Injector No.4...................8W-80-16
Fuel Pump Module..................8W-80-17
Generator.........................8W-80-17
Glove Box Lamp and Switch...........8W-80-17
Headlamp Dimmer and Optical
Horn Switch.....................8W-80-17
Headlamp Leveling Switch............8W-80-17
Headlamp Switch...................8W-80-17
Horn No.1.........................8W-80-18
Horn No.2.........................8W-80-18
(IAT/Map) Sensor...................8W-80-18
Idle Air Control Motor (IAC)...........8W-80-18
Ignition Coil Pack...................8W-80-18
Ignition Switch.....................8W-80-19
Immobilizer Engine Sensor............8W-80-19
Immobilizer Sensor..................8W-80-19
Instument Cluster - C1...............8W-80-19
Instument Cluster - C2...............8W-80-19
Intermittent Wipe/Wash Switch........8W-80-20
Key-In Switch......................8W-80-20
Knock Sensor......................8W-80-20
Left Airbag Impact Sensor.............8W-80-20
Left Back-Up Lamp..................8W-80-20
Left Door Lock Switch................8W-80-21
Left Door Window Motor..............8W-80-21
Left Fog Lamp......................8W-80-21
Left Front Door Lock Motor...........8W-80-21
Left Front Door Speaker..............8W-80-21
Left Front Wheel Speed Sensor.........8W-80-22
Left Headlamp.....................8W-80-22
Left Headlamp Leveling Motor.........8W-80-22
Left Instrument Panel Speaker
(Premium).......................8W-80-22
Left License Lamp...................8W-80-22
Left Park/Turn Signal Lamp...........8W-80-22
8W - 80 - 2 8W - 80 CONNECTOR PIN-OUTSPL
Page 200 of 256

Downloaded from www.Manualslib.com manuals search engine 978W-1
PL-RHD 8W - 80 - 12 8W-80 CONNECTOR PIN-OUTS
PLR08012
CAV CIRCUIT FUNCTION
1 K7 20OR 8 VOLT SUPPLY
2 K4 20BK/LB SENSOR GROUND
3 K44 20TN/YL CAMSHAFT POSITION SENSOR SIGNAL
CAV CIRCUIT FUNCTION
1 X3 20BK/RD HORN RELAY CONTROL
2Ð Ð
3Ð Ð
4Ð Ð
NATURAL
1 4
CLOCKSPRING
CAV CIRCUIT FUNCTION
1 T141 14YL/RD CLUTCH PEDAL POSITION SWITCH SIGNAL
2 A41 14YL IGNITION SWITCH FEED
CLUTCH PEDAL
POSITION SWITCH (MTX)BLACK
1 2
BLACKBLACK
CAV CIRCUIT
1 P34 18PK/BK
2 P33 18OR/BK
CAV CIRCUIT
1 P34 18PK/BK
2 P33 18OR/BK 122 1
C325C325
CAMSHAFT
POSITION SENSOR
31
BLACK
CAV CIRCUIT
1 L1 18VT/BK
2 L7 18BK/YL
3 Z1 18BK
4 L38 18BR/WT
5 L50 18WT/TN
6 L63 18DG/RD
CAV CIRCUIT
1 L1 18VT/BK
2 L7 18BK/YL
3 Z1 18BK
4 L38 18BR/WT
5 L5018WT/TN
6 L63 18DG/RD
C340C340
CAV CIRCUIT
1 L1 18VT/BK
2 L7 18BK/YL
3 Z1 16BK
4 L38 18BR/WT
5 L50 18WT/TN
6 L62 18BR/RD
CAV CIRCUIT
1 L1 18VT/BK
2 L7 18BK/YL
3 Z1 18BK
4 L38 18BR/WT
5 L50 18WT/TN
6 L63 18DG/RD
C341C341
14
25
36
BLACK
41
52
63BLACK
14
25
36
BLACK
41
52
63BLACK
Page 225 of 256

Downloaded from www.Manualslib.com manuals search engine 8W-90 CONNECTOR/GROUND LOCATIONS
DESCRIPTION AND OPERATION
INTRODUCTION
This section provides illustrations identifying the
general location of components, grounds, and connec-
tors in the vehicle. A index is provided. Use the wir-
ing diagrams in each section for connector/groundnumber identification. Refer to the index for the
proper figure number.CONNECTOR/GROUND LOCATIONS
For items not shown in this section a N/S is placed
in the Fig. column.
Connector
Name/NumberColor Location Fig.
A/C Compressor
ClutchBK Top of
Compressor8
A/C Cycling Switch BK Center of HVAC
HousingN/S
A/C-Heater Blower
MotorBK RT Side of
HVAC HousingN/S
A/C-Heater Control
SwitchBK Rear of Control 13
A/C High Pressure
SwitchGY Top of A/C
Compressor8
A/C Low Pressure
SwitchBK LT Side of Cowl
PanelN/S
ABS Hydraulic
ModulatorDK/
GYTop of Hydraulic
UnitN/S
ABS Relay Box BK Top of Hydraulic
UnitN/S
Airbag Control
ModuleYL Rear of
Gearshift11
Ash Receiver Lamp BK At Lamp 13
Back-Up Lamp
SwitchGY Top of
Transmission3
Battetry
Temperature
SensorBK Bottom of
Battery Tray6
Blower Motor
Resistor BlockNAT Left Side Cowl
To pN/S
Brake Warning
Lamp SwitchBK Right Frame
RailN/S
C101 BR Top of I.P. 13
C102 BK Top of I.P. 13
C103 BL Top of I.P. 13
C105 BL Right Kick Panel N/S
C108 BK Left Lower Cowl N/S
C160 LT/
GYLeft Fender Side
Shield5Connector
Name/NumberColor Location Fig.
C161 BK Left Fender Side
Shield5
C203 BK Left Side of I.P. N/S
C205 BL Left Kick Panel 13
C206 BL Top Left of I.P. N/S
C225 RD Left Kick Panel 9
C230 GY Right Kick Panel 14
C231 BL Right Kick Panel N/S
C241 BK Right Side of I.P. N/S
C301 GY Right B-Pillar 15
C303 GY Right B-Pillar 15
C309 BK Left Trunk Area 18
Camshaft Position
SensorBK Left Side of
Engine7
Clockspring NAT Rear of
Clockspring10
Clutch Pedal
Position SwitchBK Top of Clutch
Pedal2
Controller Anti-Lock
BrakeBK Left Side Kick
PanelN/S
Crankshaft Position
SensorBK Rear of Engine 7
Datalink Connector BK Left Side of
Steering ColumnN/S
Dome Lamp BK Left C- Pillar 16
Downstream
Heated Oxygen
SensorBK Rear of Catalytic
ConverterN/S
Driver Side Airbag YL Rear of
Clockspring10
Duty Cycle/EVAP
Purge SolenoidGY Right Frame
Rail4
Engine Coolant
Temp SensorBK Left Side of
Engine7
PL8W - 90 CONNECTOR/GROUND LOCATIONS 8W - 90 - 1