oil DODGE NEON 1997 1.G Wiring Diagrams Workshop Manual
[x] Cancel search | Manufacturer: DODGE, Model Year: 1997, Model line: NEON, Model: DODGE NEON 1997 1.GPages: 256, PDF Size: 2.99 MB
Page 7 of 256
Downloaded from www.Manualslib.com manuals search engine ELECTROSTATIC DISCHARGE (ESD) SENSITIVE
DEVICES
All ESD sensitive components are solid state and a
symbol (Fig. 6) is used to indicate this. When han-
dling any component with this symbol comply with
the following procedures to reduce the possibility of
electrostatic charge build up on the body and inad-
vertent discharge into the component. If it is not
known whether the part is ESD sensitive, assume
that it is.
(1) Always touch a known good ground before han-
dling the part. This should be repeated while han-
dling the part and more frequently after sliding
across a seat, sitting down from a standing position,
or walking a distance.
(2) Avoid touching electrical terminals of the part,
unless instructed to do so by a written procedure.
(3) When using a voltmeter, be sure to connect the
ground lead first.
(4) Do not remove the part from its protective
packing until it is time to install the part.
(5) Before removing the part from its package,
ground the package to a known good ground on the
vehicle.
FASTENERS
CAUTION: At no time when servicing a vehicle, can
a sheet metal screw, bolt, or other metal fastener be
installed in the strut tower to take the place of an
original plastic clip. Also, NO holes can be drilled
into the front strut tower in the area shown in (Fig.
7) for the installation of any metal fasteners into the
strut tower. Because of the minimum clearance in
this area (Fig. 7) installation of metal fasteners
could damage the coil spring coating and lead to a
corrosion failure of the spring. If a plastic clip is
missing, or is lost or broken during servicing a
vehicle, replace only with the equivalent part listed
in the parts catalog.
POSITIVE TEMPERATURE COEFFICIENT
Positive Temperature Coefficient (PTC) devices are
being used for circuit protection. These PTC's act like
a solid state fuse. They are located in the junction
block, and are used to protect such items as: power
door lock motors, power windows, and various engine
solenoids.
A special symbol is used to identify these in the
wiring diagrams (Fig. 8).
DIAGNOSIS AND TESTING
TROUBLESHOOTING TOOLS
When diagnosing a problem in an electrical circuit
there are several common tools necessary. These tools
are listed and explained below.
²Jumper Wire - This is a test wire used to con-
nect two points of a circuit. It can be used to bypass
an open in a circuit.
WARNING: NEVER USE A JUMPER WIRE ACROSS
A LOAD, SUCH AS A MOTOR, CONNECTED
BETWEEN A BATTERY FEED AND GROUND.
Fig. 6 Electrostatic Discharge Symbol
Fig. 7 Shock Tower to Spring Minimum Clearance
Area
Fig. 8 Positive Temperature Coefficient Symbol
PL8W - 01 GENERAL INFORMATION 8W - 01 - 5
DESCRIPTION AND OPERATION (Continued)
Page 15 of 256
Downloaded from www.Manualslib.com manuals search engine 8W-02 COMPONENT INDEX
INDEX
page
SCHEMATICS AND DIAGRAMS........................................................... 1
DESCRIPTION AND OPERATION.......................................................... 3
Component Page
A/C Compressor Clutch.................8W-42
A/C Compressor Clutch Relay............8W-42
A/C Cycling Switch....................8W-42
A/C Heater Blower Motor................8W-42
A/C Heater Control Switch...............8W-42
A/C High Pressure Switch...............8W-42
A/C Low Pressure Switch................8W-42
ABS Hydraulic Modulator...............8W-35
ABS Pump Motor......................8W-35
ABS Pump Motor Relay.................8W-35
ABS Relay Box........................8W-35
ABS System Relay.....................8W-35
ABS Warning Lamp....................8W-35
Airbag Control Module..................8W-43
Airbag Impact Sensors..................8W-43
Airbag Warning Lamp..................8W-40
Antenna.............................8W-47
Anti-Lock Warning Lamp................8W-40
Ash Receiver Lamp....................8W-44
Automatic Shut Down Relay.............8W-30
Back-Up Lamp Switch..................8W-51
Back-Up Lamps.......................8W-51
Battery..............................8W-20
Battery Temperature Sensor.............8W-30
Blower Motor Resistor Block.............8W-42
Brake Warning Lamp...................8W-40
Brake Warning Lamp Switch.............8W-40
Camshaft Position (CMP) Sensor..........8W-30
Capacitor.........................8W-10, 20
Charge Indicator Lamp.................8W-40
Check Engine Lamp....................8W-40
Cigar Lighter Relay....................8W-41
Cigar Lighter/Power Outlet..............8W-41
Circuit Breaker.....................8W-11,62
Circuit Breaker (FB)...................8W-11
Clockspring..........................8W-41
Cluster Illumination Lamps..............8W-40
Clutch Pedal Position Switch..........8W-10, 21
Combination Flasher...................8W-52
Controller Anti-Lock Brake..............8W-35
Crankshaft Position (CKP) Sensor.........8W-30
Data Link Connector...................8W-30
Diode............................8W-15, 42
Dome Lamp..........................8W-44Component Page
Door Ajar Switches.....................8W-44
Door Jamb Switches....................8W-40
Door Lock Motors......................8W-61
Door Lock Switches....................8W-61
Door Speakers........................8W-47
Driver Side Airbag.....................8W-43
Duty Cycle Evap/Purge Solenoid..........8W-30
EGR Transducer Solenoid...............8W-30
Engine Coolant Temperature (ECT) Sensor . . 8W-30
Engine Coolant Temperature Gauge.......8W-40
Engine Oil Pressure Switch..............8W-40
Engine Starter Motor...................8W-21
Engine Starter Motor Relay..............8W-21
Fog Lamp Relay....................8W-50, 51
Fog Lamps........................8W-50, 51
Front Fog Lamp Switch.................8W-50
Fuel Gauge...........................8W-40
Fuel Injectors.........................8W-30
Fuel Pump Module.....................8W-30
Fuel Pump Relay......................8W-30
Fuse Block...........................8W-11
Fuses (FB)...........................8W-11
Fuses (PDC)..........................8W-10
Fusible Link.......................8W-20, 21
Generator............................8W-20
Glove Box Lamp And Switch.............8W-44
Ground Distribution....................8W-15
Headlamp Dimmer And Optical
Horn Switch........................8W-50
Headlamp Leveling Motors..............8W-50
Headlamp Leveling Switch...............8W-50
Headlamp Switch......................8W-50
Headlamps...........................8W-50
Heated Oxygen Sensors.................8W-30
High Beam Indicator Lamp..............8W-40
Horn Relay...........................8W-41
Horn Switches........................8W-41
Horns...............................8W-41
IAT/MAP Sensor......................8W-30
Idle Air Control (IAC) Motor.............8W-30
Ignition Coil Pack.....................8W-30
Ignition Switch........................8W-10
Immobilizer Engine Sensor..............8W-30
Immobilizer Sensor....................8W-30
PL8W - 02 COMPONENT INDEX 8W - 02 - 1
Page 16 of 256
Downloaded from www.Manualslib.com manuals search engine Component Page
Instrument Cluster....................8W-40
Instrument Panel Speakers..............8W-47
Intermittent Wipe/Wash Switch...........8W-53
Key-In Switch........................8W-40
Knock Sensor.........................8W-30
License Lamps........................8W-51
Low Oil Pressure Lamp.................8W-40
Map/Reading Lamps...................8W-44
Master Power Window Switch............8W-60
Mercury Switch.......................8W-44
Noise Supressor.......................8W-30
Park Brake Switch.....................8W-40
Park/Neutral Position Switch.............8W-51
Park/Turn Signal Lamps................8W-52
Passenger Side Airbag..................8W-43
Power Distribution Center...............8W-10
Power Folding Mirror Relay..............8W-62
Power Mirror Fuse Holder...............8W-62
Power Mirror Switch...................8W-62
Power Mirrors........................8W-62
Power Steering Pressure Switch..........8W-30
Power Sunroof Motor...................8W-64
Power Window Motors..................8W-60
Power Window Switches.................8W-60
Powertrain Control Module..............8W-30
PRNDL Lamp........................8W-44
Pump Motor Driver....................8W-35
Radiator Fan Motor....................8W-42Component Page
Radio...............................8W-47
Rear Fog Lamp Switch..................8W-51
Rear Window Defogger..................8W-48
Rear Window Defogger Switch............8W-48
Repeater Lamps....................8W-50, 52
Seat Belt Warning Lamp................8W-40
Solid State Fan Relay..................8W-42
Speakers............................8W-47
Splice Information.....................8W-30
Stop Lamp Switch.....................8W-30
Sunroof Slide Switch...................8W-64
Sunroof Vent Switch....................8W-64
Switch Illumination....................8W-48
Tail/Stop Lamps.......................8W-51
Throttle Position (TP) Sensor.............8W-30
Torque Converter Clutch Solenoid.........8W-30
Trunk Lamp..........................8W-44
Trunk Switch.........................8W-44
Turn Indicator Lamps..................8W-40
Turn Signal Lamps....................8W-52
Turn Signal/Hazard Switch..............8W-52
Underhood Lamp......................8W-44
Vapor Canister Leak Detector............8W-30
Vehicle Speed Sensor...................8W-30
Visor/Vanity Lamps....................8W-44
Wheel Speed Sensors...................8W-35
Windshield Washer Pump Motor..........8W-53
Wipe/Wash Switch.....................8W-53
Wiper Motor..........................8W-53
8W - 02 - 2 8W - 02 COMPONENT INDEXPL
SPECIAL TOOLS (Continued)
Page 19 of 256
Downloaded from www.Manualslib.com manuals search engine 8W-10 POWER DISTRIBUTION
INDEX
page
SCHEMATICS AND DIAGRAMS........................................................... 1
DESCRIPTION AND OPERATION......................................................... 13
Component Page
A/C Compressor Clutch..................8W-10-9
A/C Compressor Clutch Relay.............8W-10-9
ABS Relay Box........................8W-10-7
Automatic Shut Down Relay.............8W-10-10
Battery.............................8W-10-4
Capacitor...........................8W-10-10
Circuit Breaker.......................8W-10-6
Clutch Pedal Position Switch.............8W-10-12
Data Link Connector...................8W-10-10
Dome Lamp..........................8W-10-8
Downstream Heated Oxygen Sensor........8W-10-10
Engine Starter Motor...................8W-10-5
Engine Starter Motor Relay............8W-10-5, 12
Engine Starter Motor Relay...............8W-10-5
Fog Lamp Relay......................8W-10-11
Fuel Injector No. 1....................8W-10-10
Fuel Injector No. 2....................8W-10-10
Fuel Injector No. 3....................8W-10-10
Fuel Injector No. 4....................8W-10-10
Fuel Pump Module....................8W-10-10
Fuel Pump Relay.....................8W-10-10
Fuse 1 (FB)..........................8W-10-6
Fuse 2 (PDC).......................8W-10-4, 5
Fuse 3 (PDC).......................8W-10-4, 6
Fuse 4 (FB)..........................8W-10-6
Fuse 5 (FB)..........................8W-10-6
Fuse 5 (PDC).......................8W-10-4, 7
Fuse 6 (FB)..........................8W-10-6
Fuse 7 (FB)..........................8W-10-6
Fuse 8 (FB)..........................8W-10-6
Fuse 8 (PDC).......................8W-10-4, 7
Fuse 10 (FB).........................8W-10-12
Fuse 10 (PDC)......................8W-10-4, 7
Fuse 11 (FB).........................8W-10-12
Fuse 11 (PDC)......................8W-10-4, 5
Fuse 12 (FB).........................8W-10-12
Fuse 13 (PDC)......................8W-10-4, 8
Fuse 14 (FB).........................8W-10-12
Fuse 15 (FB).........................8W-10-12
Fuse 16 (FB).........................8W-10-12
Fuse 16 (PDC)......................8W-10-4, 11
Fuse 18 (PDC)......................8W-10-4, 9
Fuse 20 (PDC)......................8W-10-4, 9
Fuse 21 (PDC)......................8W-10-4, 10
Component Page
Fuse 23 (PDC)......................8W-10-4, 10
Fuse 25 (PDC)......................8W-10-4, 9
Fuse Block........................8W-10-6, 12
G204...............................8W-10-5
Generator...........................8W-10-10
Glove Box Lamp And Switch..............8W-10-8
Headlamp Switch......................8W-10-6
Horn No. 1...........................8W-10-9
Horn No. 2...........................8W-10-9
Horn Relay..........................8W-10-9
Ignition Coil Pack.....................8W-10-10
Ignition Switch...................8W-10-5, 6, 12
Instrument Cluster...................8W-10-5, 8
Left Fog Lamp.......................8W-10-11
Left Visor/Vanity Lamps.................8W-10-8
Map/Reading Lamps....................8W-10-8
Noise Supressor......................8W-10-10
Power Distribution Center...............8W-10-10
Power Distribution Center . . 8W-10-4, 5, 6, 7, 8, 9, 10, 11
Powertrain Control Module..............8W-10-10
Radiator Fan Motor....................8W-10-7
Radio...............................8W-10-8
Rear Fog Lamp Switch.................8W-10-11
Rear Window Defogger Switch.............8W-10-7
Right Fog Lamp......................8W-10-11
Right Visor/Vanity Lamps................8W-10-8
S105..............................8W-10-10
S115 ..............................8W-10-11
S121..............................8W-10-10
S122..............................8W-10-10
S131...............................8W-10-9
S134..............................8W-10-10
S202...............................8W-10-5
S203...............................8W-10-8
S208...............................8W-10-5
S213...............................8W-10-6
S217...............................8W-10-6
S309...............................8W-10-8
Solid State Fan Relay...................8W-10-7
Stop Lamp Switch.....................8W-10-9
Trunk Lamp..........................8W-10-8
Turn Signal/Hazard Switch...............8W-10-9
Underhood Lamp......................8W-10-8
Upstream Heated Oxygen Sensor..........8W-10-10
8W - 10 - 2 8W - 10 POWER DISTRIBUTIONPL
Page 28 of 256
Downloaded from www.Manualslib.com manuals search engine 21FUSE20A
21
52
55
60
57
BATT A0
POWER
DISTRIBUTION
CENTER
72
C14616
A14
16
RD/WT
A14
16
RD/WT
POWERTRAIN
CONTROL
MODULE
A14
18
RD/WT
6C105
A141
16
DG/WT
A141
18
DG/WT
4
FUEL
PUMP
MODULE
A142
18
DG/OR
S105
22
FUEL
PUMP
RELAYAUTOMATIC
SHUT
DOWN
RELAY
CONNECTORLINK DATA
6C161
DG/OR18 A142
GENERATOR
A142
18
DG/OR
SENSOR OXYGEN
HEATED
DOWNSTREAM
A142
18
DG/OR
POWERTRAIN
CONTROL
MODULE
SENSOR OXYGEN
HEATED
UPSTREAM
A142
18
DG/ORA142
18
DG/OR
A142
18
DG/OR
A142
18
DG/OR A142
18
DG/ORDG/OR18 A142
DG/OR18 A142 A142
18
DG/OR
IGNITION
COIL
PACKSUPRESSOR
NOISE
S134S121
S122
2
DG/OR18 A142
DG/OR14 A142
2222
1161C2
58
FUEL
INJECTOR
NO. 1 NO. 2INJECTOR
FUEL FUEL
INJECTOR
NO. 3FUEL
INJECTOR
NO. 4
CAPACITOR
(8W-30-2) (8W-30-10)(8W-10-4)
(8W-30-10)
(8W-30-2)(8W-10-4)
(8W-30-4)
(8W-20-2)
(8W-30-3)(8W-30-2)
(8W-30-3)
(8W-30-5) (8W-30-5) (8W-30-5) (8W-30-5) (8W-30-5)
(8W-30-5)
8W - 10 - 10 8W-10 POWER DISTRIBUTIONPL-RHD
978W-1PLR01009
Page 63 of 256
Downloaded from www.Manualslib.com manuals search engine 8W-21 STARTING SYSTEM
DESCRIPTION AND OPERATION
STARTING SYSTEM- MANUAL TRANSMISSION
The Power Distribution Center (PDC) supplies bat-
tery voltage to the engine starter motor solenoid
through circuit T40 when the coil side of the engine
starter motor relay energizes. Circut A1 supplies the
battery voltage for the contact side of the relay. Cir-
cuit A1 and circuit T40 are protected by a 30 amp
fuse and feeds the contact side of the engine starter
motor relay. Both the 30 amp fuse and the engine
starter motor relay are located in the PDC.
The ignition switch supplies battery voltage to the
coil side of the engine starter motor relay on circuit
A41 when the key is moved to the START position
and the operator has pressed the clutch pedal to
CLOSE the clutch pedal position switch. Circuit Z1
supplies the ground for the coil side of the engine
starter motor relay. When the coil side of the relay
energizes, the contacts CLOSE, supplying battery
voltage to the engine starter motor solenoid.
Circuit A0 (battery positive cable) supplies battery
voltage to the motor of the starter when the solenoid
energizes.
HELPFUL INFORMATION
²Check for blown engine starter motor fuse in the
PDC.
²Move ignition key to the START position and
with the clutch pedal pressed, listen for starter motor
relay to click. The engine starter motor relay is
located in the PDC.
²Check for a good ground at starter motor.
²The left headlamp ground is the end point for
the starter relay coil ground circuit and is located at
the left side of the radiator closure panel.
STARTING SYSTEM (AUTOMATIC TRANSMISSION)
The Power Distribution Center (PDC) supplies bat-
tery voltage to the engine starter motor solenoid
through circuit T40 when the coil side of the engine
starter motor relay energizes. Circuit A1 supplies
battery voltage to the contact side of the relay. Cir-
cuit A1 and circuit T40 are protected by a 30 amp
fuse and feeds the contact side of the engine starter
motor relay. Both the 30 amp fuse and the engine
starter motor relay are located in the PDC.
The ignition switch supplies battery voltage to the
coil side of the engine starter motor relay on circuit
A41 when the key is moved to the START position
and the park/neutral portion of the park/neutral posi-
tion switch (3 speed transmission) is CLOSED.
Ground for the coil side of the engine starter motor
relay is supplied by circuit T41.Circuit A0 (battery positive cable) supplies battery
voltage to the motor of the engine starter when the
solenoid energizes.
HELPFUL INFORMATION
²Check for blown engine starter motor fuse in the
PDC.
²With the gear selector in the Park or Neutral
position, move ignition key to the START position
and listen for engine starter motor relay to click. The
engine starter motor relay is located in the PDC.
²Check for a good ground at engine starter motor.
PL8W - 21 STARTING SYSTEM 8W - 21 - 3
Page 65 of 256
Downloaded from www.Manualslib.com manuals search engine 8W-30 FUEL/IGNITION SYSTEMS
INDEX
page
SCHEMATICS AND DIAGRAMS........................................................... 1
DESCRIPTION AND OPERATION......................................................... 14
Component Page
A/C Compressor Clutch Relay..........8W-30-11
A/C High Pressure Switch.............8W-30-11
Airbag Control Module................8W-30-4
Automatic Shut Down Relay..........8W-30-2, 3
Battery Temperature Sensor..........8W-30-3, 7
Camshaft Position Sensor...........8W-30-7, 13
Controller Anti-Lock Brake..........8W-30-4, 12
Crankshaft Position Sensor..........8W-30-7, 13
Data Link Connector................8W-30-2, 4
Downstream Heated Oxygen Sensor......8W-30-3
Duty Cycle Evap/Purge Solenoid.........8W-30-9
EGR Transducer Solenoid..............8W-30-9
Engine Coolant Temperature Sensor......8W-30-7
Fuel Injector No. 1...................8W-30-5
Fuel Injector No. 2...................8W-30-5
Fuel Injector No. 3...................8W-30-5
Fuel Injector No. 4...................8W-30-5
Fuel Pump Module..................8W-30-10
Fuel Pump Relay....................8W-30-10
Fuse 5 (FB)........................8W-30-12
Fuse 10 (FB).....................8W-30-9, 10
Fuse 10 (FB)........................8W-30-9
Fuse 21 (PDC)................8W-30-2, 3, 4, 10
Fuse 25 (PDC)......................8W-30-12
Fuse Block....................8W-30-9, 10, 12
G101..............................8W-30-3
G102.........................8W-30-2, 4, 12
G106..............................8W-30-2
G303.............................8W-30-10
Generator.........................8W-30-11
IAT/MAP Sensor.....................8W-30-6
Idle Air Control Motor.................8W-30-8
Ignition Coil Pack....................8W-30-5
Immobilizer Engine Sensor............8W-30-13
Immobilizer Sensor..............8W-30-3, 8, 13
Instrument Cluster...........8W-30-7, 8, 10, 11Component Page
Knock Sensor.......................8W-30-6
Noise Supressor.....................8W-30-5
Park/Neutral Position Switch..........8W-30-12
Power Distribution Center....8W-30-2, 3, 4, 10, 12
Power Steering Pressure Switch.........8W-30-4
Powertrain Control
Module . 8W-30-2, 3, 4, 5, 6, 7, 8, 9, 10, 11, 12, 13
S101.............................8W-30-12
S102..............................8W-30-4
S104...........................8W-30-2, 12
S104............................8W-30-2, 4
S105............................8W-30-2, 4
S106.............................8W-30-12
S107..............................8W-30-3
S109...........................8W-30-9, 10
S110 ......................8W-30-3, 6, 7, 8, 13
S118 ..........................8W-30-3, 7, 8
S119 ..............................8W-30-3
S120........................8W-30-3, 6, 7, 8
S121..............................8W-30-5
S122..........................8W-30-2, 3, 5
S123.............................8W-30-13
S123............................8W-30-7, 8
S124..............................8W-30-6
S126..............................8W-30-9
S127..............................8W-30-3
S129.............................8W-30-13
S134..............................8W-30-5
S211 .............................8W-30-12
Solid State Fan Relay................8W-30-11
Stop Lamp Switch...................8W-30-12
Throttle Position Sensor...............8W-30-6
Torque Converter Clutch Solenoid........8W-30-9
Upstream Heated Oxygen Sensor........8W-30-3
Vapor Canister Leak Detector...........8W-30-9
Vehicle Speed Sensor...............8W-30-8, 13
8W - 30 - 2 8W - 30 FUEL/IGNITION SYSTEMSPL
Page 69 of 256
Downloaded from www.Manualslib.com manuals search engine 1
2
2
1
2
1
2
1
FUEL
INJECTOR
A142
18
DG/ORA142
18
DG/ORA142
18
DG/ORA142
18
DG/ORA142
18
DG/OR
S122
S121
A142
18
DG/OR
S134
A142
18
DG/OR
1
2
IGNITION
COIL
PACK
3
SUPRESSOR NOISE
A142
14
DG/OR
C21317C27C216C22C23C2
IGNITION
COIL
DRIVERK17
18
DB/TNK19
18
BK/GY
K11
18
WT/DBK12
18
TNK13
18
YL/WTK14
18
LB/BR
FUEL
INJECTOR
NO. 1
MODULE CONTROL
POWERTRAIN NO. 1NO. 2 INJECTOR
FUELNO. 3 INJECTOR
FUELNO. 4 INJECTOR
FUELDRIVER DRIVERNO. 2 INJECTORFUEL
DRIVERNO. 3 INJECTORFUEL
DRIVERNO. 4 INJECTORFUEL
DRIVERCOIL IGNITION(8W-10-10)
PL-RHD8W-30 FUEL/IGNITION SYSTEM 8W - 30 - 5
PLR03004978W-1
Page 78 of 256
Downloaded from www.Manualslib.com manuals search engine 8W-30 FUEL/IGNITION SYSTEMS
INDEX
page page
DESCRIPTION AND OPERATION
AUTOMATIC SHUT DOWN RELAY.......... 15
BATTERY FEED........................ 14
BATTERY TEMPERATURE SENSOR......... 18
CAMSHAFT POSITION SENSOR........... 16
CRANKSHAFT POSITION SENSOR......... 16
DATA LINK CONNECTOR................. 15
DUTY CYCLE EVAP/PURGE SOLENOID...... 19
EGR TRANSDUCER (EET) SOLENOID....... 19
ENGINE COOLANT
TEMPERATURE SENSOR............... 16
FUEL INJECTORS....................... 18
FUEL PUMP MOTOR.................... 15
HEATED OXYGEN SENSORS.............. 16
IDLE AIR CONTROL MOTOR.............. 18
IGNITION COIL PACK.................... 18IGNITION SWITCH...................... 14
INTAKE AIR TEMPERATURE SENSOR....... 17
KNOCK SENSOR....................... 17
LOW FUEL DETECT INPUT............... 19
MANIFOLD ABSOLUTE
PRESSURE SENSOR.................. 17
PARK/NEUTRAL POSITION SWITCH INPUT
(3±SPD TRANSMISSION)................ 19
POWER (DEVICE) GROUND............... 14
POWER STEERING PRESSURE SWITCH..... 19
SIGNAL GROUND....................... 14
THROTTLE POSITION SENSOR............ 17
TORQUE CONVERTER CLUTCH SOLENOID
(TCC)............................... 19
VEHICLE SPEED SENSOR................ 15
DESCRIPTION AND OPERATION
IGNITION SWITCH
In the RUN position, the ignition switch connects
circuit A1 from the Power Distribution Center (PDC)
to circuit A21. A 30 amp fuse in the PDC protects cir-
cuits A1 and A21. Circuit A21 feeds a bus bar in the
fuse block. The bus bar feeds circuits G5, F12, and
F15.
²Circuit G5 powers the gauge cluster warning
lamps and the daytime running lamp (DRL) module.
Fuse cavity 11 (5 amp) in the fuse block protects cir-
cuit G5.
²Circuit F12 splices to the Powertrain Control
Module (PCM), duty cycle purge solenoid, EGR sole-
noid, ABS system, and a bus bar in the PDC. The
bus bar in the PDC feeds the coil side of the radiator
fan relay, A/C compressor clutch relay, and the fuel
pump relay. A 15 amp fuse in the fuse block, cavity
10, protects circuit F12.
²Circuit F15 feeds the Airbag Control Module
(ACM). A 10 amp fuse in the fuse block, cavity 9, pro-
tects circuit F15.
BATTERY FEED
Circuit A14 from the Power Distribution Center
(PDC) supplies battery voltage to cavity 46 of the
Powertrain Control Module (PCM). A 20 amp fuse in
the PDC protects circuit A14.
HELPFUL INFORMATION
Circuit A14 connects to a bus bar in the PDC that
the battery feeds. Circuit A14 powers the AutomaticShut Down (ASD) relay and fuel pump relay. The
A14 circuit also splices to the data link connector.
POWER (DEVICE) GROUND
Circuit Z12 connects to cavities 10 and 50 of the
Powertrain Control Module (PCM). The Z12 circuit
provides ground for PCM internal drivers that oper-
ate high current devices like the injectors and igni-
tion coils.
Internal to the PCM, the power (device) ground cir-
cuit connects to the PCM sensor return circuit (from
circuit K4) and the signal ground circuit (Z11).
HELPFUL INFORMATION
Circuit Z12 which supplies ground for the PCM
high current drivers, has the same termination point
as circuit Z11. The termination point is the left side
of the radiator closure panel.
If the system loses ground for the ganged circuits,
at the left side of the radiator closure panel, the vehi-
cle will not operate. Check the connection at the
ganged ground circuit eyelet.
SIGNAL GROUND
The signal ground circuit Z11 connects to cavity 47
of the PCM. The Z11 circuit provides ground for the
sensors that provide inputs to the PCM. Internal to
the PCM, the signal ground circuit connects to the
PCM sensor return circuit (from circuit K4) and the
power (device) ground circuit (Z12).
The termination point for circuit Z11 is an eyelet
attached to the left side of the radiator closure panel.
8W - 30 - 14 8W - 30 FUEL/IGNITION SYSTEMSPL
Page 79 of 256
Downloaded from www.Manualslib.com manuals search engine HELPFUL INFORMATION
Circuit Z12 which supplies ground for the PCM
high current drivers, has the same termination point
as circuit Z11. The termination point is the left side
of the radiator closure panel.
If the system loses ground for the ganged circuits,
at the left side of the radiator closure panel, the vehi-
cle will not operate. Check the connection at the
ganged ground circuit eyelet.
DATA LINK CONNECTOR
Circuit A14 supplies battery voltage to the univer-
sal data link connector. Circuit A14 originates in the
Power Distribution Center (PDC) and connects to a
battery fed bus bar. A 20 amp fuse protects circuit
A14.
A twisted pair of wires, circuits D1 and D2, from
the Airbag Control Module (ACM) connect to the uni-
versal data link connector.
Ground circuit Z12 splices to two cavities of the
data link connector. The Z12 circuit also connects to
cavities 10 and 50 of the PCM connector.
Circuit D20 connects to cavity 75 of the PCM and
to the universal data link connector. Circuit D20 is
the SCI receive circuit for the PCM.
Circuit D21 connects to cavity 65 of the PCM and
to the universal data link connector. Circuit D21 is
the SCI transmit circuit for the PCM. The D21 cir-
cuit splices to the ABS module.
HELPFUL INFORMATION
The grounding point for circuit Z12 is the left side
of the radiator closure panel.
Circuit Z12 also supplies ground for the PCM high
current drivers and has the same termination point
as circuit Z11.
If the system loses ground for the ganged circuits
at the left side radiator closure panel the vehicle will
not operate. Check the connection at the ganged
ground circuit eyelet.
AUTOMATIC SHUT DOWN RELAY
The Automatic Shut Down (ASD) relay is located
in the Power Distribution Center (PDC). Power for
the coil and contact side of the relay is supplied on
circuit A14. This circuit is HOT at all times and pro-
tected by a 20 amp fuse located in the PDC.
The Powertrain Control Module (PCM) controls the
ground path for the coil side of the relay on circuit
K51. This circuit connects to cavity 67 of the PCM.
When the PCM supplies the ground path on circuit
K51 the contacts in the relay CLOSE connecting cir-
cuits A14 and A142. The A142 circuit is spliced and
supplies power to the generator, fuel injectors, PCM,
ignition coil, and heated oxygen sensors.
HELPFUL INFORMATION
²Refer to group 14 Fuel System, for additional
information.
²Check the 20 amp fuse located in the PDC.
FUEL PUMP MOTOR
Circuit A14 is a bus bar in the Power Distribution
Center (PDC) and connects to battery voltage. The
contact side of the fuel pump relay connects circuit
A14 and circuit A141. A 20 amp fuse in the PDC pro-
tects circuits A14 and A142.
Circuit A141 supplies voltage for the fuel pump
motor. Circuit Z1 provides ground for the fuel pump
motor. The grounding point for circuit Z1 is the right
rear wheel house.
Circuit F12 supplies voltage to the coil side of the
fuel pump relay. The Powertrain Control Module
(PCM) controls the ground path circuit for the coil
side of the fuel pump relay on circuit K31. Circuit
K31 connects to cavity 74 of the PCM.
HELPFUL INFORMATION
Circuit F12 originates in the fuse block where it
connects to a bus bar fed by circuit A21. In the
START and RUN position, the ignition switch con-
nects circuit A1 from the PDC to circuit A21. A 30
amp fuse in the PDC protects circuits A1 and A21.
Circuit F12 splices to feed the ABS control module,
EGR solenoid, Torque Converter Clutch (TCC) sole-
noid, leak detection pump, and the EVAP/Purge sole-
noid.
Circuit F12 also connects to a bus bar in the PDC.
The bus bar supplies voltage to the coil side of radi-
ator fan relay and A/C clutch relay, as well as the
fuel pump relay.
VEHICLE SPEED SENSOR
Circuit K7 supplies 8 volts from the Powertrain
Control Module (PCM) to the Vehicle Speed Sensor
(VSS). The K7 circuit connects to cavity 44 of the
PCM connector.
Circuit G7 from the VSS provides an input signal
to the PCM. The G7 circuit connects to cavity 66 of
the PCM connector.
The PCM provides ground for the VSS signal (cir-
cuit G7) through circuit K4. Circuit K4 connects to
cavity 43 of the PCM connector.
HELPFUL INFORMATION
Circuit G7 splices to the speedometer and odome-
ter in the instrument cluster.
Circuit K7 splices to supply 8 volts to the camshaft
position sensor and crankshaft position sensor.
Circuit K4 splices to supply ground for the signals
from the following:
²Upstream heated oxygen sensor
²Downstream heated oxygen sensor
PL8W - 30 FUEL/IGNITION SYSTEMS 8W - 30 - 15
DESCRIPTION AND OPERATION (Continued)