automatic transmission DODGE POWER WAGON 2005 2.G Owner's Guide

Selection Of Lubricant
Refer to Recommended Fluids, Lubricants and Genuine
Parts for correct fluid type. It is important that the
transmission fluid be maintained at the prescribed level
using the recommended fluid.
CAUTION!
Using a transmission fluid other than the manufac-
turers recommended fluid may cause deterioration
in transmission shift quality and/or torque converter
shudder. Using a transmission fluid other than the
manufacturers recommended fluid will result in
more frequent fluid and filter changes. Refer to
Recommended Fluids, Lubricants and Genuine Parts
for correct fluid type.
Automatic Transmission Fluid and Filter Change
To obtain best performance and long life for automatic
transmissions, the manufacturer recommends that they
be given regular maintenance service by an Authorized
Dodge Dealer or Service Center.
It is important that proper lubricant is used in the
transmission. Refer to Recommended Fluids, Lubricants
and Genuine Parts for correct fluid type.
The fluid and filter(s) should be changed as specified in
the Maintenance Schedule (Section 8).
NOTE:If the transmission is disassembled for any
reason, the fluid and filter(s) should be changed.
382 MAINTAINING YOUR VEHICLE

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission MoparATF+4, Automatic Transmission Fluid
Transfer Case MoparATF+4, Automatic Transmission Fluid
Manual Transmission Fluid (G-56) MoparATF+4, Automatic Transmission Fluid
Front Driveshaft Grease Fitting. Use Mopartype MS-6560 (lithium based grease), or equivalent.
Clutch Linkage Multipurpose Grease, NLGI Grade 2 E.P.
Front and Rear Axle Synthetic, GL-5 SAE, 75W-90. Limited-Slip 10.5/11.5 inch Rear AxlesDO
NOT REQUIREa limited slip additive.
Brake Master Cylinder MoparDOT 3 and SAE J1703 should be used. If DOT 3 brake fluid is not
available, then DOT 4 is acceptable. Use only recommended brake fluids.
Power Steering Reservoir MoparATF+4, Automatic Transmission Fluid
408 MAINTAINING YOUR VEHICLE

At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant bottle, brake master
cylinder, and transmission and add as needed.
•Check all lights and all other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Lubricate the driveshaft grease fitting and tie rod end
links.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints (if equipped) and front suspen-
sion components.
•Check the automatic transmission fluid level.
•Check the manual transmission fluid level.
•Check the coolant level, hoses, and clamps.
412 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Adding Fuel........................309,335
Air Cleaner, Engine (Engine Air Cleaner Filter) . 361,385
Air Conditioner Maintenance............... 365
Air Conditioning Refrigerant.............365,366
Air Conditioning System................203,365
Air Conditioning System, Zone Control........ 207
Air Pressure, Tires....................296,304
Airbag..............................47,53
Airbag Light.........................73,158
Airbag On/Off Switch..................... 53
Airbag, Side............................ 56
Alarm..............................31,161
Alignment and Balance................... 303
Alterations/Modifications, Vehicle............. 7
Antifreeze (Engine Coolant)..............374,406
Anti-Lock Warning Light...............162,284
Anti-Theft System.....................31,161
Appearance Care........................ 388
Ashtray............................... 140Automatic Transmission
Adding Fluid......................... 380
Fluid and Filter Changes................. 382
Fluid Level Check...................... 380
Fluid Type........................382,408
Shift Indicator........................ 161
Shifting............................. 270
Special Additives...................... 383
Axle Fluid.......................320,378,408
Axle Lubrication.....................320,378
Ball Joints............................. 367
Battery............................... 364
Emergency Starting..................... 344
Bearings.............................. 383
Belts, Drive............................ 360
Belts, Seat.............................. 36
Body Mechanism Lubrication............... 369
B-Pillar Location........................ 291
440 INDEX

Climate Control......................... 200
Clock................................ 165
Clutch............................... 377
Clutch Linkage Maintenance................ 378
Compact Disc Maintenance................. 199
Compact Disc Player..................172,179
Compact Spare Tire...................... 299
Compass...........................126,127
Compass Calibration..................... 127
Compass Variance....................... 128
Computer, Trip/Travel.................... 123
Console, Overhead....................... 122
Contract, Service........................ 432
Converter, Catalytic...................... 313
Cooling System......................... 371
Coolant Capacity...................... 406
Coolant Level......................... 372
Disposal of Used Coolant................ 375
Drain, Flush, and Refill.................. 372Inspection........................... 371
Radiator Cap......................372,375
Selection of Coolant...............374,406,407
Temperature Gauge..................... 160
Cruise Control (Speed Control).............. 118
Cup Holder............................ 141
Customer Assistance..................... 430
Daytime Running Lights................... 112
Dealer Service.......................... 355
Defroster, Rear Window..............88,207,211
Defroster, Windshield..................202,205
Delay (Intermittent) Wipers................. 116
Differential............................. 80
Differential, Limited-Slip.................. 281
Digital Video Disc Player................... 80
Dipsticks
Automatic Transmission................. 380
Power Steering........................ 367
442 INDEX

Ethylene Glycol Antifreeze................. 374
Exhaust Gas Caution..............72,150,313,371
Exhaust System....................72,370,371
Exterior Lighting........................ 111
Filters
Air Cleaner........................361,385
Engine Fuel.......................... 362
Engine Oil........................360,407
Engine Oil Disposal.................... 360
Flashers
Turn Signal.......................... 113
Flat Tire Stowage.....................337,343
Flooded Engine Starting................... 268
Fluid, Brake........................... 408
Fluid Capacities......................... 406
Fluid Level Checks
Automatic Transmission................. 380
Power Steering........................ 367Fog Lights.......................... 113,405
Fold Flat Load Floor..................... 144
Four Wheel Drive....................... 277
Four-Way Hazard Flasher.................. 334
Freeing A Stuck Vehicle................... 347
Front Axle............................. 378
Front Wheel Bearings..................... 383
Fuel................................. 307
Adding............................. 309
Filter............................... 362
Gauge.............................. 164
Octane Rating......................307,407
Requirements......................307,406
Tank Capacity........................ 406
Fueling............................... 309
Fuses................................ 393
Garage Door Opener..................... 130
GasCap .............................. 310
444 INDEX

ScheduleB.......................... 413
Malfunction Indicator Light................ 354
Manual, Service......................... 436
Manual Transmission..................275,379
Fluid Level Check...................... 379
Lubricant Selection..................379,408
Mirrors................................ 84
Automatic Dimming..................... 85
Electric Powered....................... 87
Outside.............................. 86
Rearview............................. 84
Trailer Towing......................88,326
Modifications/Alterations, Vehicle............. 7
Mopar Parts.........................356,435
Multi-Function Control Lever............... 113
Noise Control
Maintenance.......................... 384
Tampering Prohibited................384,385Noise Emission Warranty.................. 386
Occupant Restraints....................... 35
Octane Rating, Gasoline................... 307
Odometer..........................163,164
Trip .............................163,164
Off-Pavement Driving.................... 224
Off-Road Driving........................ 224
Oil, Engine.........................356,407
Capacity............................ 406
Change Interval....................... 357
Dipstick............................. 356
Disposal............................ 360
Filter............................360,407
Filter Disposal........................ 360
Identification Logo..................... 359
Materials Added to..................... 360
Pressure Gauge....................... 159
Recommendation...................358,406
448 INDEX

Extender............................. 47
Front Seat............................ 36
Pretensioners.......................... 45
Reminder............................ 159
Seats................................. 102
Adjustment.......................... 102
Child............................... 70
Folding Floor......................... 144
Heated............................. 107
Lumbar Support....................... 105
Power.............................. 105
Reclining............................ 103
Security Alarm (Theft Alarm).............31,161
Selection of Coolant...................... 407
Sentry Key............................. 13
Service Assistance....................... 430
Service Contract......................... 432
Service Manuals........................ 436
Setting the Clock........................ 165Shift Speeds........................... 276
Shifting............................... 270
Automatic Transmission................. 270
Manual Transmission................... 275
Transfer Case......................... 279
Transfer Case, Shifting into Transfer
Case Neutral (N)..................... 329
Transfer Case, Shifting out of Transfer
Case Neutral (N)..................... 330
Shoulder Belt Upper Anchorage.............. 43
Shoulder Belts........................... 36
Side Airbag............................. 56
Signals, Turn........................... 113
Skid Plates............................. 82
Snow Chains (Tire Chains)................. 304
Snow Plow............................ 328
Snow Tires............................ 305
Spare Tire..........................299,300
Spark Plugs............................ 361
INDEX 451
10

Speed Control.......................... 118
Speedometer........................... 159
Springs................................ 82
Stabilizer Bars, Electronic Disconnecting........ 81
Starting............................... 267
Automatic Transmission................. 268
Engine Fails to Start.................... 268
Manual Transmission................... 267
Steering
Column Controls...................... 113
Column Lock.......................... 15
Linkage............................. 368
Power...........................286,367
Wheel, Tilt........................... 117
Storage, Behind the Seat................... 142
Storage Compartment, Center Seat........... 142
Storage, Vehicle......................... 393
Storing Your Vehicle...................... 393
Sun Roof.............................. 136Supplemental Tire Pressure Information........ 304
Synthetic Engine Oil...................... 359
Tachometer............................ 158
Tailgate............................... 148
Tether Anchor, Child Restraint.............63,66
Tilt Steering Column..................... 117
Tire and Loading Information Placard....291,292,304
Tire Identification Number (TIN)............. 289
Tire Markings.......................... 286
Tire Safety Information.................... 286
Tires .............................74,82,295
Air Pressure.......................... 295
Alignment........................... 303
Chains.............................. 304
Changing............................ 337
Compact Spare........................ 299
General Information.................... 295
High Speed.......................... 298
452 INDEX

Inflation Pressures..................... 296
Jacking............................. 338
Load Capacity.....................291,292
Off-Road............................. 82
Radial.............................. 299
Replacement......................... 302
Rotation............................. 306
Safety...........................286,295
Sizes............................... 287
Snow Tires........................... 305
Spare Tire........................... 337
Spinning............................ 301
Tread Wear Indicators................... 302
Wheel Mounting....................... 338
Wheel Nut Torque..................... 341
Tongue Weight/Trailer Weight.............. 323
Torque Converter Clutch.................. 274
Tow Hooks, Emergency................... 347Towing
Disabled Vehicle....................... 348
Guide.............................. 325
Recreational.......................... 329
Trailering............................ 319
Weight.............................. 325
Traction.............................. 331
Trailer Towing.......................... 318
Hitches............................. 321
Mirrors...........................88,326
Tips ................................ 326
Trailer and Tongue Weight................ 323
Trailer Towing Guide..................... 325
Trailer Weight.......................... 325
Transfer Case........................... 379
Fluid............................... 408
Transmission
Automatic........................270,380
Fluid............................... 408
INDEX 453
10