warning DODGE POWER WAGON 2006 2.G Owners Manual

The brake master cylinder has a translucent plastic
reservoir. On the outboard side of the reservoir, there is a
“MAX” dot and an “MIN” dot. The fluid level must be
kept within these two dots. Do not add fluid above the
MAX mark, because leakage may occur at the cap.
With disc brakes the fluid level can be expected to fall as
the brake linings wear. However, an unexpected drop in
fluid level may be caused by a leak and a system check
should be conducted.
Refer to Fluids, Lubricants and Genuine Parts for the
correct Fluid type.
WARNING!
Use of a brake fluid that may have a lower initial
boiling point, or is unidentified as to specification,
may result in sudden brake failure during hard
prolonged braking. You could have an accident.
WARNING!
Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts and the
brake fluid catching fire.
Use only brake fluid that has been in a tightly closed
container to avoid contamination from foreign matter or
moisture.
CAUTION!
Do not allow a petroleum-base fluid to contaminate
the brake fluid. Seal damage may result.
390 MAINTAINING YOUR VEHICLE

WARNING!
Do not use volatile solvents for cleaning purposes.
Many are potentially flammable, and if used in
closed areas they may cause respiratory harm.
Glass Surfaces
All glass surfaces should be cleaned on a regular basis
with Mopar Glass Cleaner or any commercial household-
type glass cleaner. Never use an abrasive type cleaner.
Use caution when cleaning the inside rear window
equipped with electric defrosters or the right rear quarter
window equipped with the radio antenna. Do not use
scrapers or other sharp instruments which may scratch
the elements. When cleaning the rear view mirror, spray
cleaner on the towel or rag that you are using. Do not
spray cleaner directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft rag. A mild soap solution may be
used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
rag.
2. Dry with a soft tissue.
Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the car to
wash them.
404 MAINTAINING YOUR VEHICLE

Miles 102,000 108,000 114,000 120,000
(Kilometers) (170 000) (180 000) (190 000) (200 000)
[Months] [102] [108] [114] [120]
Replace spark plugs.X
Inspect PCV Valve, replace as necessary.** X
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
**This maintenance is recommend, but not required.
WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
442 SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Adding Fuel........................319,347
Air Cleaner, Engine (Engine Air Cleaner Filter) . 375,398
Air Conditioner Maintenance............... 379
Air Conditioning Refrigerant.............379,380
Air Conditioning System................216,379
Air Conditioning System, Zone Control........ 219
Air Pressure, Tires....................306,314
Airbag.............................. 45,51
Airbag Light......................... 72,169
Airbag On/Off Switch..................... 51
Airbag, Side............................ 54
Alarm .............................. 29,171
Alignment and Balance................... 313
Alterations/Modifications, Vehicle............. 7
Antifreeze (Engine Coolant)..............387,417
Anti-Lock Warning Light...............173,294
Anti-Theft System..................... 29,171
Appearance Care........................ 401
Ashtray............................... 152Automatic Transmission
Adding Fluid......................... 394
Fluid and Filter Changes................. 395
Fluid Level Check...................... 393
FluidType ........................395,419
Shift Indicator........................ 171
Shifting ............................. 280
Special Additives...................... 395
AxleFluid ..........................391,419
Axle Lubrication........................ 391
BallJoints ............................. 380
Battery............................... 378
Emergency Starting..................... 356
Saving Feature (Protection)............... 122
Bearings.............................. 396
Belts,Drive ............................ 374
Belts, Seat.............................. 34
Body Mechanism Lubrication............... 382
452 INDEX

B-Pillar Location........................ 301
Brake Fluid............................ 419
Brake System........................293,389
Anti-Lock........................... 294
Disc Brakes.......................... 389
Hoses.............................. 391
Master Cylinder....................... 389
Parking............................. 292
Warning Light........................ 173
Break-In Recommendations, New Vehicle........ 69
Bulb Replacement....................... 407
Bulbs,Light ............................ 406
Cab Top Clearance Lights.................. 414
Calibration, Compass..................... 139
Camper............................... 160
Capacities, Fluid........................ 417
Caps, Filler
Oil (Engine).......................... 373Power Steering........................ 380
Car Washes............................ 401
Carbon Monoxide Warning............ 71,162,322
CargoLight ............................ 125
Cassette Tape and Player Maintenance......... 211
Catalytic Converter....................323,376
CD Player.......................177,182,195
Cellular Phone.......................... 90
Center High Mounted Stop Light............ 412
Center Lap Belts......................... 42
Center Seat Storage Compartment............ 154
Certification Label....................... 324
Chart, Tire Sizing........................ 298
Check Engine Light (Malfunction Indicator Light) . 172
Child Restraint........................ 57,58
Child Restraint Tether Anchors............. 62,65
Child Seat............................ 58,64
Cigar Lighter........................... 152
Climate Control......................... 213
INDEX 453
10

Disposal
Engine Oil........................... 388
Door Ajar............................. 176
Door Locks............................. 17
Door Opener, Garage..................... 142
DriveBelts ............................ 374
Driving
Off-Pavement......................... 235
Off-Road............................ 235
Electric Rear Window Defrost.......... 88,219,223
Electrical Power Outlets................... 151
Electronic Speed Control................... 130
Emergency Brake........................ 292
Emergency, In Case of
Freeing Vehicle When Stuck............... 359
Hazard Warning Flasher................. 346
Jacking............................. 350
Jump Starting......................... 356Tow Hooks.......................... 360
Towing ............................. 360
Emission Control System Maintenance......... 422
Emission Related Components.............. 378
Engine............................... 366
Air Cleaner.......................... 375
Break-In Recommendations................ 69
Compartment Identification............... 366
Coolant (Antifreeze).................387,418
Exhaust Gas Caution.................... 322
Flooded, Starting...................... 278
Fuel Requirements..................... 417
Oil ...........................370,417,418
Oil Filler Cap......................... 373
Oil Selection.......................372,417
Oil Synthetic......................... 373
Temperature Gauge..................... 170
Equipment Identification Plate.............. 344
Ethylene Glycol Antifreeze................. 387
INDEX 455
10

GasCap .............................. 320
Gasoline.............................. 317
Gasoline, Reformulated................... 317
Gauges............................... 168
Coolant Temperature.................... 170
Fuel................................ 175
Oil Pressure.......................... 169
Speedometer......................... 169
Tachometer.......................... 168
Voltmeter............................ 168
Gear Ranges........................... 280
Gear Ratios............................. 80
Glass Cleaning.......................... 404
Gross Axle Weight Rating.................. 328
Gross Vehicle Weight Rating................ 327
GVWR ............................... 324
Hands-Free Phone........................ 90
Hazard Warning Flasher................... 346Head Restraints......................... 115
Headlights............................ 407
High Beam........................... 127
High Beam/Low Beam Select Switch........ 127
Lights On Reminder.................... 124
Passing............................. 126
Switch .............................. 123
Heated Mirrors.................... 88,219,223
Heated Seats........................... 118
Heater............................... 216
High Beam/Low Beam Select (Dimmer) Switch . . 127
Hitches
TrailerTowing ........................ 330
Hoisting .............................. 356
Homelink Transmitter.................... 142
Hood Release.......................... 119
Hoses................................ 389
Hub Caps............................. 354
INDEX 457
10

Ignition............................. 15,275
Key ............................... 12,15
Lock................................ 15
Infant Restraint........................ 57,58
Inflation Pressure Tires.................... 314
Inside Rearview Mirror.................... 84
Instrument Cluster....................167,168
Instrument Panel and Controls.............. 166
Instrument Panel Lens Cleaning............. 404
Interior Appearance Care.................. 403
Interior Lights.......................... 121
Intermittent Wipers...................... 128
Introduction............................. 4
Jack Location........................... 348
Jack Operation.......................... 350
Jump Starting.......................... 356
Key, Replacement........................ 13Key, Sentry............................. 13
Key-In Reminder......................... 12
Keyless Entry System...................... 22
Keys................................ 12,17
Lane Change and Turn Signals.............. 125
LapBelts .............................. 42
Lap/Shoulder Belts....................... 34
LATCH (Lower Anchors and Tether for CHildren) . 62
Lights .............................. 72,121
Airbag............................ 55,169
Anti-Lock Warning..................173,294
Brake Warning........................ 173
Bulb Replacement...................406,407
Cap Top Clearance..................... 414
Cargo .............................. 125
Center Mounted Stop................... 412
Check Engine......................... 172
Courtesy/Reading..................... 134
458 INDEX

Cruise .............................. 176
Daytime Running...................... 124
Fog ..........................124,174,415
Four-Wheel Drive Indicator............... 290
Hazard Warning Flasher................. 346
Headlights........................... 123
High Beam........................127,169
High Beam Indicator.................... 169
High Beam/Low Beam Select............. 127
Instrument Cluster..................... 168
Intensity Control....................... 122
Interior..........................121,134
Lights On Reminder.................... 124
Passing............................. 126
Seat Belt Reminder..................... 169
Service...........................406,407
Transfer Case......................... 290
Transmission Warning................... 175
Turn Signal..................125,168,407,410Warning (Instrument Cluster Description)..... 168
Limited-Slip Differential................291,392
Loading Vehicle......................... 324
Tires ............................... 301
Locks................................. 17
Child Protection........................ 21
Door................................ 17
Ignition.............................. 15
Keys................................ 12
Power Door........................... 18
Steering Wheel......................... 15
Lower Anchors and Tether for CHildren (LATCH) . 62
Lubricants............................. 396
Lubrication, Body....................... 382
LugNuts ............................. 353
Lumbar Support........................ 116
Maintenance........................... 370
Maintenance Free Battery.................. 378
INDEX 459
10

Fluid ............................... 419
Transmission
Automatic........................280,393
Fluid ............................... 419
Maintenance.......................392,393
Manual........................277,285,392
Shifting ..........................280,286
Transmitter, Garage Door Opener............ 142
Tread Wear Indicators..................... 311
Trip Computer.......................... 135
Trip Odometer.......................171,175
Turn Signals...................125,168,407,410
Underhood Fuses........................ 405
Universal Transmitter..................... 142
Variance, Compass....................... 140
Vehicle Identification Number................ 6
Vehicle Loading......................302,324Vehicle Modifications/Alterations.............. 7
Vehicle Storage......................... 405
Voltmeter............................. 168
Warning Lights (Instrument Cluster Description) . 168
Warnings and Cautions..................... 5
Warranty Information..................... 447
Washers, Windshield..................128,383
Washing Vehicle......................... 401
Wheel Alignment and Balance............... 313
Wheel and Wheel Trim.................... 402
Wheel Changing........................ 349
Wheel Flares............................ 82
Wheel Mounting........................ 350
Wheel Nut Torque....................353,355
Wheels................................ 83
Winch .............................. 81,256
Accessories.......................... 260
Operation........................... 261
466 INDEX