cooling DODGE RAM 1500 GAS 2005 3.G User Guide

WARNING!
The warning words “DO NOT OPEN HOT” on the
radiator pressure cap are a safety precaution. Heat
causes pressure to build up in the cooling system. To
prevent scalding or injury, do not remove the pres-
sure cap.
Hoses And Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber.
Pay particular attention to those hoses nearest to high
heat sources such as the exhaust manifold. Inspect hose
routing to be sure hoses do not come in contact with any
heat source or moving component which may cause heat
damage or mechanical wear.Insure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of wear or damage that could cause failure.
Brake System
Power Disc Brakes (front and rear)
Disc brakes do not require periodic adjustment.
Brake Master Cylinder
The fluid level of the master cylinder should be checked
when performing under the hood service, or immedi-
ately if the brake system warning lamp indicates system
failure.
372 MAINTAINING YOUR VEHICLE

EXHAUST SYSTEM
•Removal or rendering inoperative exhaust system
components including the muffler or tailpipe.
ENGINE COOLING SYSTEM
•Removal or rendering inoperative the fan clutch.
•Removal of the fan shroud.
Noise Emission Warranty
The manufacturer warrants that this vehicle as manufac-
tured by the manufacturer, was designed, built and
equipped to conform at the time it left the manufacturers
control with all applicable U.S. EPA Noise Control Regu-
lations.This warranty covers this vehicle as designed, built and
equipped by the manufacturer, and is not limited to any
particular part, component or system of the vehicle
manufactured by the manufacturer. Defects in design,
assembly or in any part, component or system of the
vehicle as manufactured by the manufacturer, which, at
the time it left the manufacturers control, caused noise
emissions to exceed Federal standards, are covered by
this warranty for the life of the vehicle.
MAINTAINING YOUR VEHICLE 383
7

U.S. Metric
Engine Oil (with filter)
3.7L Engine V-6, SAE 5W-30, API Certified 5.0 qts. 4.7L
4.7L Engine V-8, SAE 5W-30, API Certified 6.0 qts. 5.7L
5.7L Engine V-8, SAE 5W-20, API Certified 7.0 qts. 6.6L
Cooling System
3.7L (MoparAntifreeze/Coolant 5 Year/100,000 Mile Formula) 17 qts. 16L
4.7L (MoparAntifreeze/Coolant 5 Year/100,000 Mile Formula) 17 qts. 16L
5.7L (MoparAntifreeze/Coolant 5 Year/100,000 Mile Formula) 18.7 qts. 17.7L
404 MAINTAINING YOUR VEHICLE

Child Seat............................56,62
Cigar Lighter........................... 148
Climate Control......................... 208
Clock................................ 173
Clutch............................... 374
Clutch Linkage Maintenance................ 374
Compact Disc Maintenance................. 207
Compact Disc Player..................180,187
Compact Spare Tire...................... 272
Compass...........................133,134
Compass Calibration..................... 134
Compass Variance....................... 136
Computer, Trip/Travel.................... 130
Console, Overhead....................... 129
Contract, Service........................ 430
Converter, Catalytic...................... 291
Cooling System......................... 368
Coolant Capacity...................... 403
Coolant Level......................... 369Disposal of Used Coolant................ 371
Drain, Flush, and Refill.................. 369
Inspection........................... 368
Radiator Cap......................369,371
Selection of Coolant...............370,403,405
Temperature Gauge..................... 168
Cruise Control (Speed Control).............. 125
Cup Holder............................ 149
Customer Assistance..................... 428
Daytime Running Lights................... 118
Dealer Service.......................... 352
Defroster, Rear Window..............81,214,218
Defroster, Windshield..................210,213
Delay (Intermittent) Wipers................. 121
Differential, Limited-Slip.................. 253
Dipsticks
Automatic Transmission................. 377
Power Steering........................ 363
438 INDEX