ignition DODGE RAM 1500 GAS 2005 3.G Manual Online

WARNING!
A hot exhaust system can start a fire if you park over
materials that can burn. Such materials might be
grass or leaves coming into contact with your ex-
haust system. Do not park or operate your vehicle in
areas where your exhaust system can contact any-
thing that can burn.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may indicate severe
and abnormal catalyst overheating. If this occurs, the
vehicle should be stopped, the engine shut off and the
vehicle allowed to cool. Thereafter, service, including a
tune-up to manufacturer’s specifications, should be ob-
tained immediately.To minimize the possibility of catalyst damage:
•Do not shut off the engine or interrupt the ignition
when the transmission is in gear and the vehicle is in
motion.
•Do not try to start engine by pushing or towing the
vehicle.
•Do not idle the engine with any spark plug wires
disconnected or removed, such as when diagnostic
testing, or for prolonged periods during very rough
idling or malfunctioning operating conditions.
360 MAINTAINING YOUR VEHICLE

2. Use specified fuses only.
3. Always properly reinstall the cover.
VEHICLE STORAGE
If you are storing your vehicle for more than 21 days, we
recommend that you take the following steps to mini-
mize the drain on your vehicle’s battery:
•Disconnect the Ignition-Off Draw fuse (I.O.D.) fuse
located in the Fuse and Relay Center, located in the
engine compartment. The I.O.D. cavity includes a
snap-in retainer that allows the fuse to be discon-
nected, without removing it from the fuse block.
•The electronic shift transfer case should be placed in
the 4HI mode and kept in this position to minimize the
battery drain.
•As an alternative to the above steps you may, discon-
nect the negative cables from both batteries.
REPLACEMENT LIGHT BULBS
LIGHT BULBS — Inside Bulb No.
Overhead Console Lights............... TS212-2
Dome Light............................7679
All of the inside bulbs are brass or glass wedge base.
Aluminum base bulbs are not approved.
LIGHT BULBS — Outside Bulb No.
Back-Up..............................3057
Center High Mounted Stop Lamp............. 912
Fog Lamp...........................9006LL
Headlamp (Halogen)...................9007QL
Park & Turn Signal...................3157NAK
Rear License Plate Lamp................... 168
Rear Cargo Light......................... 912
Tail & Stop............................3057
Cab Clearance Lights...................... 168
Dual Rear Wheel Sidemarker Light............ 168
Dual Rear Wheel Tailgate ID Lights (3)......... 168
390 MAINTAINING YOUR VEHICLE

Miles 48,000 51,000 54,000 57,000 60,000
(Kilometers) (77 000) (82 000) (86 000) (91 000) (96 000)
Inspect engine air cleaner filter, replace if neces-
sary.X
Replace spark plugs.X
Replace ignition cables.X
Inspect PCV valve, replace as necessary. **X
Drain and refill automatic transmission fluid and
change main sump filter*.X
416 SCHEDULE “B”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 105,000 108,000 111,000 114,000 117,000 120,000
(Kilometers) (168 000) (173 000) (178 000) (182 000) (187 000) (192 000)
Replace spark plugs.X
Replace ignition cables.X
Inspect PCV valve, replace as necessary. **X
Inspect auto tension drive belt and replace if
required (3.7L/4.7L/5.7L).XX
Drain and refill automatic transmission fluid
and change main sump and spin-on cooler
return filter (if equipped)*.X
Flush and replace engine coolant at 120
months if not replaced at 102,000 miles (192
000 km).X
*
This applies only if the vehicle is used for frequent trailer
towing, snowplowing, fleet vehicle or commercial service.
** This maintenance is recommended by the manufac-
turer to the owner, but not required to maintain the
emissions warranty.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE “B” 421
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 36,000 42,000 48,000 54,000 60,000 66,000
(Kilometers) (58 000) (67 000) (77 000) (84 000) (96 000) (106 000)
[Months] [36] [42] [48] [54] [60] [66]
Change engine oil and engine oil filter. X X X X X X
Rotate tires. X X X X X X
Check transfer case fluid level (4X4). X
Lubricate outer tie rod ends 2500/3500 (4X4)
models only.X X XXXX
Flush and replace engine coolant at 60
months, if not replaced at 102,000 miles (163
000 km).X
Inspect brake linings. X X
Inspect engine air cleaner filter. Replace if
necessary.X
Replace spark plugs.X
Inspect PCV valve, replace as necessary. **X
Replace ignition cables.X
SCHEDULE “A” 423
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 102,000 108,000 114,000 120,000
(Kilometers) (163 000) (173 000) (182 000) (192 000)
[Months] [102] [108] [114] [120]
Change engine oil and engine oil filter. X X X X
Rotate tires. X X X X
Drain and refill transfer case fluid (4X4). X
Flush and replace engine coolant, if not replaced at 60
months.X
Flush and replace engine coolant at 120 months, if not
replaced at 102,000 miles (163 000 km).X
Lubricate outer tie rod ends 2500/3500 (4X4) models only. X X X X
Inspect brake linings. X
Inspect auto tension drive belt and replace if required
(3.7L/4.7L/5.7L).XX
Replace ignition cables.X
SCHEDULE “A” 425
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Hood Release.......................... 113
Hoses................................ 372
Hub Caps............................. 333
Ignition.............................13,228
Key ............................... 11,13
Lock................................ 13
Infant Restraint.......................... 56
Inflation Pressure Tires.................... 277
Inside Rearview Mirror.................... 78
Instrument Cluster....................164,165
Instrument Panel and Controls.............. 163
Instrument Panel Lens Cleaning............. 389
Interior Appearance Care.................. 387
Intermittent Wipers...................... 121
Introduction............................. 4
Jack Location........................... 322
Jack Operation.......................... 327Jump Starting.......................... 337
Key, Replacement........................ 12
Key, Sentry............................. 11
Key-In Reminder......................... 11
Keyless Entry System...................... 22
Keys................................ 11,15
Lane Change and Turn Signals.............. 119
Lap Belts.............................. 42
Lap/Shoulder Belts....................... 34
LATCH (Lower Anchors and Tether for CHildren) . 60
Lights..............................71,115
Airbag............................55,166
Anti-Lock Warning..................170,258
Battery Saver......................... 116
Brake Warning........................ 170
Bulb Replacement...................390,391
Cap Top Clearance..................... 398
442 INDEX

Center Mounted Stop................... 397
Check Engine......................... 165
Courtesy/Reading..................... 129
Cruise.............................. 169
Daytime Running...................... 118
Dual Wheel Assembly Rear............... 400
Fog ............................. 118,402
Four-Wheel Drive Indicator............... 245
Hazard Warning Flasher................. 320
Headlights........................... 117
High Beam........................120,166
High Beam Indicator.................... 166
High Beam/Low Beam Select............. 120
Instrument Cluster..................... 165
Intensity Control....................... 116
Interior........................... 115,129
Lights On Reminder.................... 118
Low Washer Fluid..................... 172
Passing............................. 120Seat Belt Reminder..................... 166
Service...........................390,391
Side Marker.......................... 401
Transfer Case......................... 245
Transmission Warning................173,304
Turn Signal.................. 119,166,391,395
Warning (Instrument Cluster Description)..... 165
Limited-Slip Differential................253,375
Loading Vehicle......................... 293
Tires ............................... 264
Locks................................. 15
Child Protection........................ 20
Door................................ 15
Ignition.............................. 13
Keys................................ 11
Power Door........................... 16
Steering Wheel......................... 13
Lower Anchors and Tether for CHildren (LATCH) . 60
Lubricants............................. 380
INDEX 443
10