steering DODGE RAM 1500 GAS 2007 3.G Service Manual

Brake System
Power Disc Brakes (front and rear)
Disc brakes do not require adjustment; however, several
hard stops during the break-in period are recommended
to seat the linings and wear off any foreign material.
Brake And Power Steering Hoses
When the vehicle is serviced for scheduled maintenance,
inspect surface of hoses and nylon tubing for evidence of
heat and mechanical damage. Hard and brittle rubber,
cracking, tears, cuts, abrasion, and excessive swelling
indicate deterioration of the rubber. Particular attention
should be made to examining those hose surfaces nearest
to high heat sources, such as the exhaust manifold.
Insure nylon tubing in these areas has not melted or
collapsed.Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
NOTE:Often, fluid such as oil, power steering fluid,
and brake fluid are used during assembly plant opera-
tions to facilitate the assembly of hoses to couplings.
Therefore, oil wetness at the hose-coupling area is not
necessarily an indication of leakage. Actual dripping of
hot fluid when systems are under pressure (during
vehicle operation), should be noted before hose is re-
placed based on leakage.
NOTE:Inspection of brake hoses should be performed
whenever the brake system is serviced and every engine
oil change. Inspect hydraulic brake hoses for surface
cracking, scuffing, or worn spots. If there is any evidence
of cracking, scuffing, or worn spots, the hose should be
replaced immediately! Eventual deterioration of the hose
can take place resulting in a possibility of a burst failure.
MAINTAINING YOUR VEHICLE 475
7

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission MoparATF+4, Automatic Transmission Fluid.
Transfer Case MoparATF+4, Automatic Transmission Fluid.
NVG 246 Automatic Transfer Case
OnlyMoparPN 05179014AA, NVG 246 Automatic Transmission Fluid or
equivalent.
Manaul Transmission Fluid (G238) MoparATF+4, Automatic Transmission Fluid.
Manual Transmission Fluid (G-56) MoparATF+4, Automatic Transmission Fluid.
Clutch Linkage Multipurpose Grease, NLGI Grade 2 E.P. or equivalent.
1500 Model Front Axle (4X4) GL-5 SAE 75W-90 (MS-9763) or equivalent.
1500 Model Rear Axle MoparSynthetic Gear Lubricant SAE 75W-140 (MS-8985). Limited-Slip
Rear Axles on 1500 Models Require the addition of 118 ml (4 oz.) Mopar
Limited Slip Additive or equivalent.
2500/3500 Model Front and Rear Axle Synthetic, GL-5 SAE, 75W-90 or equivalent. Limited-Slip 10.5/11.5 inch
Rear AxlesDO NOT REQUIREa limited slip additive.
Brake Master Cylinder MoparDOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir MoparATF+4, Automatic Transmission Fluid.
MAINTAINING YOUR VEHICLE 515
7

At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required. When refilling the washer fluid reservoir,
take some washer fluid and apply it to a cloth or towel
and wipe clean the wiper blades, this will help blade
performance.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant bottle, brake master
cylinder, and transmission and add as needed.
•Check all lights and all other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Lubricate Drivetrain/Steering/Suspension Grease Fit-
tings (if equipped)
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints/U— joints (if equipped) and
front suspension components.
•Check the automatic transmission fluid level.
•Check the manual transmission fluid level.
•Check the coolant level, hoses, and clamps.
•Lubricate Front Drive Shaft Fitting (2500/3500, 4X4).
520 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Ball Joints............................. 464
Battery............................... 461
Emergency Starting..................... 438
Saving Feature (Protection)............... 166
Bearings.............................. 482
Belts, Drive............................ 458
Belts, Seat............................34,73
Body Mechanism Lubrication............... 466
B-Pillar Location........................ 362
Brake Assist System...................... 346
Brake Control System, Electronic............. 344
Brake Fluid.........................476,515
Brake System........................340,475
Anti-Lock (ABS)....................341,344
Disc Brakes.......................... 475
Fluid Check.......................... 476
Hoses.............................. 475
Master Cylinder....................... 476
Parking............................. 338Warning Light........................ 232
Break-In Recommendations, New Vehicle....... 112
Bulb Replacement....................... 499
Bulbs, Light............................ 498
Cab Top Clearance Lights.................. 507
Calibration, Compass..................... 184
Camper............................... 215
Capacities, Fluid........................ 512
Caps, Filler
Oil (Engine).......................... 456
Power Steering........................ 464
Radiator (Coolant Pressure)............... 471
Car Washes............................ 488
Carbon Monoxide Warning...........217,218,383
Cargo Light............................ 168
Cassette Tape and Player Maintenance......... 281
Catalytic Converter...................... 459
CD (Compact Disc) Player............238,246,260
INDEX 551
10

Cruise Control (Speed Control).............. 175
Cup Holder............................ 199
Customer Assistance..................... 542
Data Recorder, Event....................58,97
Daytime Running Lights................... 167
Dealer Service.......................... 453
Defroster, Rear Window................124,209
Defroster, Windshield...............219,285,287
Delay (Intermittent) Wipers................. 171
Differential, Limited-Slip.................. 336
Dipsticks
Automatic Transmission................. 480
Power Steering........................ 464
Disc Brakes............................ 475
Disposal
Antifreeze (Engine Coolant)............... 472
Door Ajar............................. 236
Door Locks............................. 26Door Opener, Garage..................... 186
Drive Belts............................ 458
Drive Shaft Universal Joints................ 465
Dual Rear Wheels.....................379,434
DVD Player (Video Entertainment System)...... 275
E-85 Fuel............................. 386
Electric Rear Window Defrost............124,209
Electrical Power Outlets................... 196
Electronic Brake Control System............. 344
Electronic Speed Control (Cruise Control)...... 175
Electronic Stability Program (ESP).........234,352
Electronically Shifted Transfer Case........321,329
Emergency Brake........................ 338
Emergency, In Case of
Freeing Vehicle When Stuck............... 442
Hazard Warning Flasher................. 420
Jacking............................. 427
Jump Starting......................... 438
INDEX 553
10

Starting............................. 388
Flooded Engine Starting................... 303
Fluid, Brake........................... 515
Fluid Capacities......................... 512
Fluid Level Checks
Automatic Transmission................. 480
Brake............................... 476
Power Steering........................ 464
Fluids, Lubricants and Genuine Parts.......... 514
Fog Lights.......................168,233,502
Fold Flat Load Floor..................... 210
Four Wheel Drive....................... 316
Four-Way Hazard Flasher.................. 420
Freeing A Stuck Vehicle................... 442
Front Axle (Differential)................... 477
Front Wheel Bearings..................... 482
Fuel................................. 380
Adding............................. 384
Filter............................... 459Gauge.............................. 235
Hoses.............................. 474
Octane Rating......................380,514
Requirements......................380,512
System Hoses......................... 474
Tank Capacity........................ 512
Fuel, Flexible.............See Flexible Fuel Vehicles
Fuses................................ 492
Garage Door Opener (HomeLink) ........... 186
Gas Cap (Fuel Filler Cap)...............385,450
Gasoline (Fuel)......................... 380
Gasoline, Reformulated................... 381
Gauges............................... 227
Coolant Temperature.................... 229
Fuel................................ 235
Oil Pressure.......................... 228
Speedometer......................... 228
Tachometer.......................... 227
INDEX 555
10

Courtesy/Reading..................... 179
Cruise.............................. 236
Daytime Running...................... 167
Dual Wheel Assembly Rear............... 509
Electronic Stability Program (ESP) Indicator . 234,353
Fog ..........................168,233,502
Four-Wheel Drive Indicator............... 320
Hazard Warning Flasher................. 420
Headlights........................... 166
High Beam........................170,228
High Beam Indicator.................... 228
High Beam/Low Beam Select............. 170
Illuminated Entry....................... 19
Instrument Cluster..................... 227
Intensity Control....................... 165
Interior..........................165,179
Lights On Reminder.................... 168
Passing............................. 170
Seat Belt Reminder..................... 228Service...........................498,499
Side Marker.......................... 511
Traction Control....................... 353
Transfer Case......................... 320
Transmission Warning................... 235
Turn Signal..................169,227,499,503
Warning (Instrument Cluster Description)..... 227
Limited-Slip Differential................336,478
Loading Vehicle......................... 389
Tires ............................... 362
Locks................................. 26
Child Protection........................ 29
Door................................ 26
Keys................................ 12
Power Door........................... 27
Steering Wheel......................... 15
Lower Anchors and Tether for CHildren
(LATCH)............................64,103
Lubrication, Body....................... 466
558 INDEX

Door Locks........................... 27
Mirrors............................. 123
Outlet (Auxiliary Electrical Outlet).......... 196
Seats............................153,154
Sliding Rear Window................... 209
Steering..........................343,464
Sunroof............................. 193
Windows............................. 31
Power Steering Fluid..................... 515
Pregnant Women and Seat Belts............46,85
Pretensioners
Seat Belts...........................44,83
Programmable Electronic Features.........188,192
Programming Transmitters
(Remote Keyless Entry).................188,192
Radial Ply Tires......................... 369
Radiator Cap (Coolant Pressure Cap).......470,471
Radio Broadcast Signals................... 237Radio, Navigation....................... 274
Radio Operation...................238,246,260
Radio Remote Controls.................... 280
Radio, Satellite.......................... 275
Radio (Sound Systems)..............238,246,260
Rear Axle (Differential).................... 477
Rear Seat, Folding....................157,158
Rear Wheel Bearings..................... 483
Rear Window Features.................... 209
Rear Window, Sliding..................... 210
Reclining Front Seats..................150,151
Reclining Rear Seats...................... 156
Recorder, Event Data....................58,97
Recreational Towing...................... 410
Shifting into Transfer Case Neutral (N).... 411,413
Shifting out of Transfer Case Neutral (N) . . . 412,415
Reformulated Gasoline.................... 381
Refrigerant............................ 464
Reminder, Seat Belt.....................44,84
INDEX 561
10

Selection of Coolant (Antifreeze)..........470,514
Sentry Key (Immobilizer)................... 15
Service Assistance....................... 542
Service Contract......................... 544
Service Manuals........................ 546
Setting the Clock.............236,240,248,262,275
Shift Speeds........................... 315
Shifting............................... 306
Automatic Transmission................. 307
Manual Transmission.................312,314
Transfer Case......................... 319
Transfer Case, Shifting into Transfer
Case Neutral (N).................. 411,413
Transfer Case, Shifting out of Transfer
Case Neutral (N)..................412,415
Shoulder Belt Upper Anchorage............42,81
Shoulder Belts.........................34,73
Side Airbag............................. 95
Signals, Turn........................... 169Sliding Rear Window
Power.............................. 209
Slippery Surfaces, Driving On............... 337
Snow Chains (Tire Chains)................. 375
Snow Plow............................ 406
Snow Tires............................ 377
Spare Tire..........................370,371
Spark Plug Wires (Ignition Cables/Wires)...... 458
Spark Plugs............................ 458
Speed Control (Cruise Control).............. 175
Speedometer........................... 228
Starting............................... 302
Automatic Transmission................. 302
Engine Fails to Start.................... 303
Manual Transmission................... 302
Remote.............................. 24
Starting Procedures (Gas Engines)............ 302
Steering
Linkage............................. 465
INDEX 563
10

Power...........................343,464
Wheel Lock........................... 15
Wheel, Tilt........................... 173
Steering Wheel Mounted Sound System
Controls............................. 280
Storage, Behind the Seat................... 203
Storage Compartment, Center Seat.........203,204
Storage, Vehicle......................... 497
Storing Your Vehicle...................... 497
Sun Roof.............................. 193
Supplemental Tire Pressure Information........ 375
Synthetic Engine Oil...................... 457
System, Navigation...................... 274
System, Remote Starting.................... 24
Tachometer............................ 227
Tailgate............................... 215
Tether Anchor, Child Restraint........64,68,103,107
Tilt Steering Column..................... 173Tip Start.............................. 303
Tire and Loading Information Placard......362,375
Tire Identification Number (TIN)............. 361
Tire Markings.......................... 358
Tire Safety Information.................... 358
Tires ...........................219,366,547
Aging (Life of Tires).................... 373
Air Pressure.......................... 366
Alignment........................... 374
Chains.............................. 375
Compact Spare........................ 370
Dual............................379,434
General Information.................... 366
High Speed.......................... 368
Inflation Pressures..................... 367
Jacking............................. 427
Life of Tires.......................... 373
Load Capacity.....................362,363
Quality Grading....................... 547
564 INDEX