air filter DODGE RAM 2500 DIESEL 2004 3.G User Guide

²AIR CLEANER
þRemoval of the air cleaner.
þRemoval of the air cleaner filter element from the air
cleaner housing.
þRemoval of the air ducting.
²EXHAUST SYSTEM
þRemoval or rendering inoperative exhaust system
components including the muffler or tailpipe.
²ENGINE COOLING SYSTEM
þRemoval or rendering inoperative the fan clutch.
þRemoval of the fan shroud.
Noise Emission Warranty
The manufacturer warrants that this vehicle as manufac-
tured by the manufacturer, was designed, built and
equipped to conform at the time it left the manufacturer's
control with all applicable U.S. EPA Noise Control Regu-
lations.
This warranty covers this vehicle as designed, built and
equipped by the manufacturer, and is not limited to any
particular part, component or system of the vehicle
manufactured by the manufacturer. Defects in design,
assembly or in any part, component or system of the
vehicle as manufactured by the manufacturer, which, at
the time it left the manufacturer's control, caused noise
emissions to exceed Federal standards, are covered by
this warranty for the life of the vehicle.
MAINTAINING YOUR VEHICLE 359
7

²Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and transfer case (if
equipped), add as needed.
²Check Filter MinderŸ. Replace air cleaner filter
element if necessary.
²Check all lights and all other electrical items for correct
operation.
At Each Oil Change
²Change the engine oil filter.
²Inspect the exhaust system.
²Inspect the brake hoses.
²Inspect the CV joints (if equipped) and front suspen-
sion components.
²Check the automatic transmission fluid level.
²Check the manual transmission fluid level.
²Check the coolant level, hoses, and clamps.
386 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 116,250 120,000 123,750 127,500 131,250 135,000
(Kilometers) (186 000) (192 000) (198 000) (204 000) (210 000) (216 000)
Change engine oil and engine oil filter. X X X
Rotate tires. X X X
Lubricate outer tie rod ends 2500/3500 (4X4)
models only.XXX
Clean engine air filter canister.X
Adjust valve lash clearance.X
Inspect drive belts, replace as required. X
Drain and refill transfer case fluid (4X4). X
Inspect fan hub. X
Inspect damper. X
Inspect water pump weep hole for blockage. X X
Replace fuel filter element. Clean the water in
fuel sensor.XX
Inspect front wheel bearings. X
Change rear axle fluid. X X
394 SCHEDULE ªBº
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Air Cleaner, Engine...................331,358
Air Conditioner Maintenance............... 338
Air Conditioning Refrigerant.............338,339
Air Conditioning System................187,338
Air Conditioning System, Zone Control........ 191
Air Filter.............................. 331
Air Pressure, Tires....................252,259
Airbag..............................45,50
Airbag Light.........................70,144
Airbag On/Off Switch..................... 50
Airbag, Side............................ 53
Alarm..............................29,147
Alignment and Balance................... 258
Alterations/Modifications, Vehicle............. 7
Antifreeze (Engine Coolant)................ 345
Capacities........................... 379
Anti-Lock Warning Light...............146,242
Anti-Theft System.....................29,147
Appearance Care........................ 362Ashtray............................... 127
Automatic Transmission................... 353
Adding Fluid......................... 353
Fluid and Filter Changes................. 354
Fluid Level Check...................... 353
Fluid Type........................354,381
Shift Indicator........................ 147
Shifting............................. 218
Special Additives...................... 355
Axle Fluid.......................274,351,381
Axle Lubrication.....................274,351
Ball Joints............................. 340
Battery............................... 336
Blanket..........................213,338
Emergency Starting..................... 310
Bearings.............................. 355
Belts, Drive............................ 331
Belts, Seat.............................. 34
412 INDEX

Used Coolant......................... 346
Door Ajar............................. 145
Door Locks............................. 16
Door Opener, Garage..................... 120
Draining Fuel/Water Separator Filter.......... 334
Drive Belts............................ 331
Dual Rear Wheels.....................263,306
Electric Rear Window Defrost..........78,191,195
Electrical Power Outlets................... 126
Electronic Speed Control................... 109
Emergency Brake........................ 238
Emergency, In Case of
Freeing Vehicle When Stuck............... 313
Hazard Warning Flasher................. 296
Jacking............................. 300
Jump Starting......................... 310
Tow Hooks.......................... 314
Towing............................. 315Emission Control System Maintenance......... 384
Engine............................... 320
Air Cleaner.......................... 331
Block Heater.......................205,212
Break-In Recommendations................ 67
Compartment......................... 320
Coolant..........................345,380
Cooling............................. 343
Data Plate........................... 294
Identification......................... 320
Idling.............................. 214
Jump Starting......................... 310
Oil ..............................325,380
Oil Synthetic......................... 214
Runaway............................ 264
Temperature Gauge..................... 146
Ethylene Glycol Antifreeze................. 345
Exhaust Gas Caution................69,136,342
Exhaust System....................69,342,358
INDEX 415
10

Trailer Towing......................79,279
Modifications/Alterations, Vehicle............. 7
Mopar Parts.........................322,407
Multi-Function Control Lever............... 103
New Vehicle Break-In Period................ 67
Noise Control
Maintenance.......................... 357
Tampering Prohibited................... 358
Noise Emission Warranty...............357,359
Occupant Restraints....................... 33
Odometer..........................148,149
Trip .............................148,149
Off-Pavement Driving.................... 292
Off-Road Driving........................ 292
Oil, Engine............................ 380
Capacity............................ 379
Change Interval....................... 326Dipstick............................. 325
Disposal............................ 331
Filter.........................325,328,380
Pressure Gauge....................... 145
Recommendation...................... 327
Viscosity............................ 327
Oil Filter, Change........................ 328
Onboard Diagnostic System................ 321
Opener, Garage Door..................... 120
Operating Precautions.................... 321
Outside Rearview Mirrors.................. 76
Overdrive............................. 220
Overdrive OFF Switch.................... 220
Overhead Console.................... 112,113
Overhead Travel Information Center.......... 113
Owner's Manual........................ 408
Parking Brake.......................... 238
Passenger Airbag On/Off Switch............. 50
420 INDEX