clutch DODGE RAM 2500 DIESEL 2007 3.G Owner's Manual

Brake Hoses
Inspection should be performed whenever the brake
system is serviced or at intervals specified. Inspect hy-
draulic brake hoses for surface cracking, scuffing or worn
spots. If there is any evidence of cracking, scuffing, or
worn spots, the hose should be replaced immediately!
Eventual deterioration of the hose can take place with
possible burst failure.
Clutch Linkage
If the clutch pedal linkage begins to squeak or grunt, the
clutch pedal pivot bushings should be lubricated. Refer
to Fluids, Lubricants and Genuine Parts for the correct
lubricant type. Multipurpose Grease, NLGI Grade 2 E.P.
Clutch Hydraulic System
The clutch hydraulic system is a sealed maintenance-free
system. In the event of leakage or other malfunction, the
system must be replaced.
Rear Axle And 4x4 Front Driving Axle Fluid Level
For Model 9.25 Front Axles and 10.5”/11.5” Rear Axles
refer to Fluids, Lubricants and Genuine Parts for the
correct lubricant type. For normal service, periodic fluid
level checks are not required. When the vehicle is ser-
viced for other reasons, the exterior surfaces of the axle
assembly should be inspected.
When checking the fluid level, the vehicle should be in a
level position. The fluid level should be 1/4” ± 1/4” (6.4
mm ± 6.4 mm) below the fill hole on the 9.25” Front Axle.
The fluid level should be 3/4” ± 1/4” (19 mm ± 6.4 mm)
below the fill hole on all 10.5” and 1/4” ± 1/4” (6.4 mm
± 6.4 mm) on 11.5” Rear Axles.
Drain And Refill
Vehicles operated in normal service do not have regularly
scheduled oil changes. If fluid has become contaminated
MAINTAINING YOUR VEHICLE 411
7

•EXHAUST SYSTEM
Removal or rendering inoperative exhaust system
components including the muffler or tailpipe.
•ENGINE COOLING SYSTEM
Removal or rendering inoperative the fan clutch.
Removal of the fan shroud.
Noise Emission Warranty
The manufacturer warrants that this vehicle as manufac-
tured by the manufacturer, was designed, built and
equipped to conform at the time it left the manufacturer’s
control with all applicable U.S. EPA Noise Control Regu-
lations. This warranty covers this vehicle as designed, built and
equipped by the manufacturer, and is not limited to any
particular part, component or system of the vehicle
manufactured by the manufacturer. Defects in design,
assembly or in any part, component or system of the
vehicle as manufactured by the manufacturer, which, at
the time it left the manufacturer’s control, caused noise
emissions to exceed Federal standards, are covered by
this warranty for the life of the vehicle.
MAINTAINING YOUR VEHICLE 419
7

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission Mopar ATF+4, Automatic Transmission Fluid.
Transfer Case Mopar ATF+4, Automatic Transmission Fluid.
Manual Transmission Fluid G-56 Mopar ATF+4, Automatic Transmission Fluid.
Clutch Linkage Multipurpose Grease, NLGI Grade 2 E.P. or equivalent.
Front and Rear Axle Fluid 2500/3500
Models GL-5 SAE 75W-90 Synthetic or equivalent. 2500/3500 axels do not require
limited slip additive.
Brake Master Cylinder Mopar DOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir Mopar ATF+4, Automatic Transmission Fluid.
MAINTAINING YOUR VEHICLE 447
7

CD (Compact Disc) Player............190,198,211
Cellular Phone .......................... 87
Center High Mounted Stop Light ............ 440
Center Lap Belts ......................... 42
Center Seat Storage Compartment .........159,160
Certification Label ....................... 323
Charge Air Cooler ....................... 408
Chart, Tire Sizing ........................ 297
Check Engine Light (Malfunction Indicator Light) . 183
Child Restraint ........................ 57,58
Child Restraint Tether Anchors .............62,66
Child Seat ............................ 58,65
Cigar Lighter ........................... 154
Cleaning Wheels ............................. 424
Climate Control ......................... 234
Clock ..................... 187,192,200,213,226
Clutch Linkage Maintenance ................ 411
Compact Disc (CD) Maintenance ............. 233 Compact Spare Tire
...................... 308
Compass ........................... 140,141
Compass Calibration ..................... 141
Compass Variance ....................... 142
Computer, Trip/Travel .................... 137
Console, Overhead ....................... 136
Contract, Service ........................ 472
Coolant Pressure Cap (Radiator Cap) .......... 405
Cooling System ......................... 401
Adding Coolant (Antifreeze) .............. 404
Coolant Capacity ...................... 445
Coolant Level ................... 401,402,406
Disposal of Used Coolant ................ 406
Drain, Flush, and Refill .................. 403
Inspection ........................... 406
Points to Remember .................... 406
Pressure Cap ......................... 405
Radiator Cap ......................... 405
Selection of Coolant (Antifreeze) .........403,446
480 INDEX

Passing............................. 128
Switch .............................. 124
Heated Mirrors ....................... 85,164
Heated Seats ........................... 119
Heater ............................... 237
High Beam/Low Beam Select (Dimmer) Switch . . 128
Hitches Trailer Towing ........................ 331
Hoisting .............................. 366
HomeLink (Garage Door Opener) Transmitter . . . 143
Hood Release .......................... 121
Hoses ............................. 408,411
Hub Caps ............................. 362
Hydraulic Clutch Fluid .................... 411
Ignition ............................... 12
Key ................................. 12
Ignition Key Removal ..................... 12
Illuminated Entry ........................ 19 Infant Restraint
........................ 57,58
Inflation Pressure Tires .................... 313
Inside Rearview Mirror .................... 82
Instrument Cluster .................... 178,179
Instrument Panel and Controls .............. 177
Instrument Panel Lens Cleaning ............. 425
Integrated Power Module (Fuses) ............ 426
Interior Appearance Care .................. 424
Interior Lights .......................... 123
Intermittent Wipers (Delay Wipers) ........... 129
Introduction ............................. 4
Jack Location ........................... 355
Jack Operation .......................... 357
Jump Starting .......................... 367
Key, Replacement ........................ 16
Key, Sentry (Immobilizer) ................... 15
Keyless Entry System ...................... 20
484 INDEX

Quality Grading....................... 475
Radial .............................. 307
Replacement .......................... 311
Rotation ............................. 315
Safety ........................... 295,304
Sizes ............................... 297
Snow Tires ........................... 315
Spare Tire ........................... 356
Spinning ............................ 309
Tread Wear Indicators ................... 310
Wheel Mounting ....................... 357
Wheel Nut Torque ..................... 361
Tongue Weight/Trailer Weight .............. 332
Torque Converter Clutch .................. 272
Tow Hooks, Emergency ................... 371
Towing ............................... 327
Disabled Vehicle ....................... 372
Guide .............................. 332
Recreational .......................... 345 Weight
.............................. 332
Traction .............................. 288
Traction Control ......................... 412
Trailer Towing .......................... 327
Cooling System Tips .................... 339
Hitches ............................. 331
Minimum Requirements ................. 333
Mirrors ........................... 85,339
Trailer and Tongue Weight ................ 332
Wiring .............................. 336
Trailer Towing Guide ..................... 332
Trailer Weight .......................... 332
Transaxle Automatic ............................ 12
Manual .............................. 14
Transfer Case Electronically Shifted .................... 280
Fluid ............................... 447
492 INDEX