steering DODGE RAM 2500 DIESEL 2007 3.G Owner's Guide

Refrigerant Recovery and Recycling
R-134a Air Conditioning Refrigerant is a hydrofluorocar-
bon (HFC) that is endorsed by the Environmental Pro-
tection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by dealers or other service facilities
using recovery and recycling equipment.
Power Steering — Fluid Check
Checking the power steering fluid level at a defined
service interval is not required. The fluid should only be
checked if a leak is suspected, abnormal noises are
apparent, and/or the system is not functioning as antici-
pated. Coordinate inspection efforts through a certified
DaimlerChrysler Dealership. 
WARNING!
Fluid level should be checked on a level surface and
with the engine off to prevent injury from moving
parts and to insure accurate fluid level reading. Do
not overfill. Use only manufacturers recommended
power steering fluid.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to Fluids, Lubricants, and Genuine Parts
for correct fluid type.
Front Suspension Ball Joints
The ball joints originally supplied with the vehicle are
permanently lubricated at the factory and do not require
service. The ball joints and seals should be inspected
whenever the vehicle is serviced for other reasons.
MAINTAINING YOUR VEHICLE 397
7

Steering Linkage — Inspection
Whenever the vehicle is hoisted, all steering linkage
joints should be inspected for evidence of damage. If
seals are damaged, parts should be replaced to prevent
leakage or contamination of the grease.
Front Prop Shaft Lubrication
Lubricate the front driveshaft grease fitting at each oil
change listed in the appropriate Maintenance Schedule
for your vehicle (Schedule “A” and “B”). Use Mopar 
type MS-6560 (lithium based grease), or equivalent.
Front Axle Universal Drive Joints And Pivot
Bearings
The front axle universal joint and pivot bearings are
permanently lubricated and do not require servicing.
Front Driveshaft Grease Fitting
398 MAINTAINING YOUR VEHICLE

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission Mopar ATF+4, Automatic Transmission Fluid.
Transfer Case Mopar ATF+4, Automatic Transmission Fluid.
Manual Transmission Fluid G-56 Mopar ATF+4, Automatic Transmission Fluid.
Clutch Linkage Multipurpose Grease, NLGI Grade 2 E.P. or equivalent.
Front and Rear Axle Fluid 2500/3500
Models GL-5 SAE 75W-90 Synthetic or equivalent. 2500/3500 axels do not require
limited slip additive.
Brake Master Cylinder Mopar DOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir Mopar ATF+4, Automatic Transmission Fluid.
MAINTAINING YOUR VEHICLE 447
7

Axle Fluid.......................... 412,447
Axle Lubrication (Axle Fluid) ............... 412
Ball Joints ............................. 397
Battery ............................... 394
Blanket .......................... 262,396
Emergency Starting ..................... 367
Keyless Transmitter Replacement (RKE) ....... 23
Saving Feature (Protection) ............... 124
Bearings .............................. 415
Belts, Drive ............................ 389
Belts, Seat .............................. 32
Body Mechanism Lubrication ............... 399
B-Pillar Location ........................ 300
Brake Fluid ............................ 447
Brake System ........................ 291,409
Anti-Lock (ABS) ....................... 292
Disc Brakes .......................... 409
Fluid Check .......................... 409 Hoses
.............................. 411
Master Cylinder ....................... 409
Parking ............................. 290
Warning Light ........................ 184
Bulb Replacement ....................... 433
Bulbs, Light ............................ 432
Cab Top Clearance Lights .................. 441
Calibration, Compass ..................... 141
Camper ............................... 170
Capacities, Antifreeze (Engine Coolant) ........ 445
Capacities, Fluid ........................ 445
Caps, Filler Power Steering ........................ 397
Radiator (Coolant Pressure) ............... 405
Car Washes ............................ 422
Carbon Monoxide Warning ...............73,172
Cargo Light ............................ 126
Cassette Tape and Player Maintenance ......... 232
INDEX 479
10

Temperature Gauge..................... 181
Cruise Control (Speed Control) .............. 133
Cup Holder ............................ 155
Customer Assistance ..................... 470
Data Recorder, Event ...................... 56
Daytime Running Lights ................... 125
Dealer Service .......................... 380
Defroster, Rear Window .................85,164
Defroster, Windshield ................74,236,238
Delay (Intermittent) Wipers ................. 129
Diesel Fuel ............................ 318
Diesel Fuel Requirements .................. 318
Differential, Limited-Slip .................. 287
Dipsticks .............................. 383
Power Steering ........................ 397
Disc Brakes ............................ 409
Disposal .............................. 389
Engine Oil ........................... 389 Used Coolant (Antifreeze)
................ 406
Door Ajar ............................. 187
Door Locks ............................. 24
Door Opener, Garage ..................... 143
Draining Fuel/Water Separator Filter .......... 391
Drive Belts ............................ 389
Dual Rear Wheels ..................... 316,364
DVD Player (Video Entertainment System) ...... 226
Electric Rear Window Defrost .............85,164
Electrical Power Outlets ................... 152
Electronic Speed Control (Cruise Control) ...... 133
Electronically Shifted Transfer Case ........... 280
Emergency Brake ........................ 290
Emergency, In Case of Freeing Vehicle When Stuck ............... 370
Hazard Warning Flasher ................. 354
Jacking ............................. 357
Jump Starting ......................... 367
INDEX 481
10

Tow Hooks.......................... 371
Towing ............................. 372
Emission Control System Maintenance ......... 450
Engine ............................... 378
Air Cleaner .......................... 389
Block Heater ....................... 254,261
Break-In Recommendations ................ 71
Compartment ......................... 378
Coolant (Antifreeze) .................... 446
Cooling ............................. 401
Data Plate ........................... 380
Identification ......................... 378
Idling .............................. 263
Jump Starting ......................... 367
Oil .............................. 383,446
Oil Synthetic ......................... 262
Runaway ............................ 317
Temperature Gauge ..................... 181
Event Data Recorder ...................... 56 Exhaust Gas Caution
................73,172,401
Exhaust System ................. 73,400,401,418
Exterior Lighting ........................ 124
Fan .................................. 407
Filters Engine Oil ..................... 383,386,446
Flashers Turn Signal .......................... 127
Flat Tire Stowage ..................... 356,366
Fluid, Brake ........................... 447
Fluid Capacities ......................... 445
Fluid Level Checks Brake ............................... 409
Manual Transmission ................... 412
Power Steering ........................ 397
Transfer Case ......................... 412
Fluids, Lubricants and Genuine Parts .......... 446
Fog Lights ....................... 126,185,436
482 INDEX

Turn Signal.................. 127,179,433,437
Warning (Instrument Cluster Description) ..... 179
Limited-Slip Differential ................287,412
Loading Vehicle ......................... 323
Tires ............................... 300
Locks ................................. 24
Child Protection ........................ 27
Door ................................ 24
Keys ................................ 12
Power Door ........................... 25
Steering Wheel ......................... 15
Lower Anchors and Tether for CHildren (LATCH) . 62
Lubricants ............................. 416
Lubrication, Body ....................... 399
Lug Nuts ............................. 361
Lumbar Support ........................ 112
Maintenance ........................... 380
Maintenance Procedures ................... 383 Maintenance Schedule
.................... 450
Schedule “A” ......................... 463
Manual, Service ......................... 474
Manual Transmission .................. 274,412
Fluid Level Check ...................... 412
Lubricant Selection ..................... 447
Mirrors ................................ 82
Automatic Dimming ..................... 83
Electric Powered ....................... 84
Outside .............................. 83
Rearview ............................. 82
Trailer Towing ...................... 85,339
Modifications/Alterations, Vehicle ............. 8
Mopar Parts ......................... 379,473
Multi-Function Control Lever ............... 127
Navigation Radio ........................ 225
Navigation System ....................... 225
New Vehicle Break-In Period ................ 71
486 INDEX

Phone, Cellular.......................... 87
Phone, Hands-Free (UConnect™) ............. 87
Pickup Box ............................ 169
Placard, Tire and Loading Information ......... 300
Power Distribution Center (Fuses) ............... 426
Door Locks ........................... 25
Mirrors .............................. 84
Outlet (Auxiliary Electrical Outlet) .......... 152
Seats ............................... 113
Sliding Rear Window ................. 30,165
Steering .......................... 294,397
Sunroof ............................. 149
Windows ............................. 29
Power Steering Fluid ..................... 447
Pregnant Women and Seat Belts .............. 44
Pretensioners Seat Belts ............................. 42
Programmable Electronic Features .........145,148 Programming Transmitters
(Remote Keyless Entry)
.................145,148
Radial Ply Tires ......................... 307
Radiator Cap (Coolant Pressure Cap) .......... 405
Radio Broadcast Signals ................... 188
Radio, Navigation ....................... 225
Radio Operation ................... 190,198,211
Radio Remote Controls .................... 231
Radio, Satellite .......................... 226
Radio (Sound Systems) ..............190,198,211
Rear Axle (Differential) ................. 41 1,412
Rear Seat, Folding ..................... 1 15,116
Rear Wheel Bearings ..................... 416
Rear Window Features .................... 164
Rear Window, Sliding ................... 31,165
Reclining Front Seats ..................... 111
Reclining Rear Seats ...................... 114
Recorder, Event Data ...................... 56
488 INDEX

Steering Linkage ............................. 398
Power ........................... 294,397
Wheel Lock ........................... 15
Wheel, Tilt ........................... 130
Steering Wheel Mounted Sound System Controls ............................. 231
Storage, Behind the Seat ................... 159
Storage Compartment, Center Seat .........159,160
Storage, Vehicle ......................... 431
Storing Your Vehicle ...................... 431
Sun Roof .............................. 149
Supplemental Tire Pressure Information ........ 313
Synthetic Engine Oil ...................... 262
System, Navigation ...................... 225
Tachometer ............................ 179
Tailgate ............................... 171
Tether Anchor, Child Restraint .............62,66 Tilt Steering Column
..................... 130
Tire and Loading Information Placard ......300,313
Tire Identification Number (TIN) ............. 299
Tire Markings .......................... 295
Tire Safety Information .................... 295
Tires ............................ 74,304,475
Aging (Life of Tires) .................... 311
Air Pressure .......................... 304
Alignment ........................... 312
Chains .............................. 313
Changing ............................ 356
Compact Spare ........................ 308
Dual ............................ 316,364
General Information .................... 304
High Speed .......................... 306
Inflation Pressures ..................... 305
Jacking ............................. 357
Life of Tires .......................... 311
Load Capacity ..................... 300,301
INDEX 491
10