check engine light DODGE RAM 2500 DIESEL 2008 3.G User Guide
[x] Cancel search | Manufacturer: DODGE, Model Year: 2008, Model line: RAM 2500 DIESEL, Model: DODGE RAM 2500 DIESEL 2008 3.GPages: 527, PDF Size: 8.88 MB
Page 272 of 527

CAUTION!
If WATER IN FUEL indicator light remains on DO
NOT START engine before you drain water from the
fuel filter to avoid engine damage. Refer to ªDrain-
ing Fuel/Water Separator Filter (6.7L Diesel Engine)º
under ªMaintenance Proceduresº in Section 7.
4. Turn the ignition key to START and crank the engine.
Do not press the accelerator during starting.
CAUTION!
Do not crank engine for more than 15 seconds at a
time as starter motor damage may result. Turn key to
OFF and wait at least two minutes before trying
again.5. When the engine starts, release the key.
6. Check to see that there is oil pressure.
7. Release the parking brake.
Starting Procedure ± Engine Manifold Air
Temperature Below 66ÉF (19ÉC)
NOTE:The temperature displayed on the overhead
console (if equipped) does not necessarily reflect the
engine manifold air temperature. When certain engine
temperatures fall below 66ÉF (19ÉC) the lights will remain
on indicating the intake manifold heater system is active.
270 STARTING AND OPERATING
Page 273 of 527

Follow the steps in the Normal Starting Procedure ex-
cept:
CAUTION!
Do not crank engine for more than 15 seconds at a
time or starter motor damage may result. Turn key to
OFF and wait at least two minutes for starter to cool
before repeating start procedure.
²The WAIT TO START light will remain on for a period
of time (length of time depends on engine tempera-
ture).
²After the WAIT TO START light goes off, turn the
ignition key to START. Do not press the accelerator
during starting.
²After engine start-up, check to see that there is oil
pressure.
²Allow the engine to idle about three minutes until
the manifold heaters have completed the post-heat
cycle.
²Release the parking brake and drive.
NOTE:Engine idle speed will automatically increase to
1000 RPM at low coolant temperatures to improve engine
warm-up.
NOTE:If the engine stalls or if the ignition switch is left
ON for more than two minutes after the WAIT TO START
light goes out, reset the grid heaters by turning the
ignition switch to OFF for at least five seconds and then
back ON. Repeat steps 3 through 7 of the normal starting
procedure.
STARTING AND OPERATING 271
5
Page 276 of 527

Starting Fluids
WARNING!
STARTING FLUIDS or flammable liquids are
NEVER TO BE USED in the CumminstDiesel (see
Warning label). Never pour diesel fuel, flammable
liquid, starting fluids (ether) into the air cleaner
canister, air intake piping, or turbocharger inlet in an
attempt to start the vehicle. This could result in a
flash fire and explosion causing serious personal
injury and engine damage.
The engine is equipped with an automatic electric air
preheating system. If the instructions in this manual are
followed, the engine should start in all conditions.
WARNING!
Do not leave children or animals inside parked
vehicles in hot weather. Interior heat build up may
cause serious injury or death.
NORMAL OPERATION (DIESEL ENGINE)
Observe the following when the engine is operating.
²All message center lights are off.
²Check Engine Lamp is off.
²Engine Oil Pressure is above 10 psi (69 kPa) at idle.
²Low Oil Pressure light is off.
274 STARTING AND OPERATING
Page 371 of 527

The automatic transmission fluid and filter should be
changed if you REGULARLY tow a trailer for more than
45 minutes of continuous operation. See Maintenance
Schedule in section 8 of this manual for transmission
fluid change intervals.
NOTE:Check the automatic transmission fluid level
before towing.
Towing Tips Ð Tow/Haul (If Equipped)
To reduce potential for automatic transmission overheat-
ing, turn the ªTOW HAULº feature ON when driving in
hilly areas or downshift the transmission (using the
Auto-6 [ERS] switch).
Towing Tips Ð Electronic Speed Control (If
Equipped)
þ
Don't use in hilly terrain or with heavy loads.
þWhen using the speed control, if you experience speed
drops greater than 10 mph (16 km/h), disengage until
you can get back to cruising speed.
þUse speed control in flat terrain and with light loads to
maximize fuel efficiency.
Towing Tips Ð Cooling System
To reduce potential for engine and transmission over-
heating, take the following actions:
þCity Driving
When stopped for short periods of time, put transmission
in neutral and increase engine idle speed.
þHighway Driving
Reduce speed.
þAir Conditioning
Turn off temporarily.
STARTING AND OPERATING 369
5
Page 419 of 527

CAUTION!
Fill the oil filter element with clean oil before instal-
lation. Use the same type oil that will be used in the
engine. When filling the oil filter, prevent foreign
material from falling into the filter. Severe engine
damage may occur.
Apply a light film of lubricating oil to the sealing surface
of the filter gasket before installing the filter.
CAUTION!
Overtightening may distort the threads or damage
the filter element seal.Install the filter as specified by the filter manufacturer.
Turn the filter 3/4 to one full turn after making contact
with the gasket.
Check the condition of the threads and sealing surface on
the oil pan and drain plug.
Install the drain plug and sealing washer and tighten to
37 ft-lbs. (50 N´m).
Use only high-quality multi-grade lubricating oil in your
CumminstDiesel Engine. Choose the correct oil for your
operating conditions as outlined in the Selection of
Engine Oil.
CumminstTurbo Diesel
Fill the engine with the correct grade of new oil. The
engine capacity is 11 quarts (10.4 liters) in the crankcase
and 1 quart (.95 liter) in the lubricating oil filter.
MAINTAINING YOUR VEHICLE 417
7
Page 436 of 527

Windshield Washers
The fluid reservoir is located under the hood and should
be checked for fluid level at regular intervals. Fill the
reservoir with windshield washer solvent only (not ra-
diator antifreeze). When refilling the washer fluid reser-
voir, take some washer fluid and apply it to a cloth or
towel and wipe the wiper blades clean. This will help
blade performance.
To prevent freeze-up of your windshield washer system
in cold weather, select a solution or mixture that meets or
exceeds the temperature range of your climate. This
rating information can be found on most washer fluid
containers.
The washer fluid reservoir will hold a full gallon of fluid
when the Low Washer Fluid Light illuminates.WARNING!
Commercially available windshield washer solvents
are flammable. They could ignite and burn you. Care
must be exercised when filling or working around
the washer solution.
After the engine has warmed, operate the defroster for a
few minutes to reduce the possibility of smearing or
freezing the fluid on the cold windshield. MopartAll
Weather Windshield Washer Solution, used with water as
directed on the container, aids cleaning action, reduces
the freezing point to avoid line clogging, and is not
harmful to paint or trim.
434 MAINTAINING YOUR VEHICLE
Page 487 of 527

take some washer fluid and apply it to a cloth or towel
and wipe clean the wiper blades, this will help blade
performance.
Once a Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the batteries and clean and tighten the termi-
nals as required.
²Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and transfer case (if
equipped), add as needed.
²Check all lights and all other electrical items for correct
operation.
²Drain water from the fuel filter.
²Check Filter MinderŸ (If Equipped). Replace air
cleaner filter element if necessary.At Each Oil Change
²Change the engine oil filter.
²Inspect the exhaust system.
²Inspect the brake hoses.
²Inspect the U-Joints (if equipped) and front suspension
components.
²Check the automatic transmission fluid level.
²Check the manual transmission fluid level.
²Check the coolant level, hoses, and clamps.
²Lubricate outer tie rod ends (4X4) models only.
²Lubricate Front Drive Shaft Fitting (4X4).
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
MAINTENANCE SCHEDULES 485
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
Page 508 of 527

Adding Fuel........................... 349
Adjustable Pedals....................... 138
Air Cleaner, Engine (Engine Air Cleaner
Filter).............................419,452
Air Conditioner Maintenance............... 430
Air Conditioning Refrigerant.............430,431
Air Conditioning System................252,430
Air Conditioning System, Zone Control........ 255
Air Filter.............................. 419
Air Pressure, Tires....................325,333
Airbag............................35,48,55
Airbag Light.......................58,77,190
Airbag On/Off Switch..................... 55
Alarm, Panic............................ 24
Alarm (Security Alarm).................19,192
Alarm System (Security Alarm)............... 19
Alignment and Balance................... 332
Alterations/Modifications, Vehicle............. 8
Antenna, Satellite Radio................... 245Antifreeze (Engine Coolant)..............438,439
Capacities........................... 479
Anti-Lock Warning Light...............195,314
Anti-Theft Security Alarm (Theft Alarm)........ 19
Anti-Theft System.....................19,192
Appearance Care........................ 455
Ashtray............................... 162
Assistance Towing....................... 102
Auto Unlock, Doors...................... 146
Automatic Dimming Mirror................. 85
Automatic Door Locks.................... 146
Automatic Transaxle...................... 12
Interlock System........................ 19
Automatic Transmission................... 447
Adding Fluid......................448,449
Fluid and Filter Changes................. 450
Fluid Level Check...................... 448
Fluid Type........................447,482
Shift Indicator........................ 192
506 INDEX
Page 509 of 527

Shifting............................. 285
Special Additives...................... 450
Autostick............................. 192
Axle Fluid..........................446,482
Axle Lubrication (Axle Fluid)............... 446
Ball Joints............................. 431
Battery............................... 428
Blanket..........................277,430
Emergency Starting..................... 397
Keyless Transmitter Replacement (RKE)....... 25
Saving Feature (Protection)............... 130
Bearings.............................. 450
Belts, Drive............................ 418
Belts, Seat.............................. 36
Body Builders Guide....................... 7
Body Mechanism Lubrication............... 433
B-Pillar Location........................ 320
Brake Fluid............................ 482Brake System........................312,443
Anti-Lock (ABS)....................... 313
Disc Brakes.......................... 443
Fluid Check.......................... 444
Hoses.............................. 445
Master Cylinder....................... 444
Parking............................. 310
Warning Light........................ 194
Bulb Replacement....................... 466
Bulbs, Light............................ 465
Cab Top Clearance Lights.................. 474
Calibration, Compass..................... 150
Camper............................... 179
Capacities, Antifreeze (Engine Coolant)........ 479
Capacities, Fluid........................ 479
Caps, Filler
Oil (Engine).......................... 415
Power Steering........................ 431
INDEX 507
10
Page 510 of 527

Radiator (Coolant Pressure)............... 439
Car Washes............................ 455
Carbon Monoxide Warning...............76,181
Cargo Light............................ 133
Cassette Tape and Player Maintenance......... 247
Catalyst Full Message..................... 425
CD (Compact Disc) Player............202,210,224
Cellular Phone.......................... 89
Center High Mounted Stop Light............ 473
Center Lap Belts......................... 45
Center Seat Storage Compartment.........167,168
Certification Label....................... 352
Charge Air Cooler....................... 442
Chart, Tire Sizing........................ 317
Check Engine Light (Malfunction Indicator
Light)................................ 194
Child Restraint........................61,62
Child Restraint Tether Anchors.............65,69
Child Seat............................62,68Cigar Lighter........................... 162
Cleaning
Wheels............................. 457
Climate Control......................... 249
Clock.....................200,204,212,225,239
Closed Crankcase Ventilation (CCV) Filter...... 426
Clutch Linkage Maintenance................ 445
Compact Disc (CD) Maintenance............. 248
Compact Spare Tire...................... 328
Compass Calibration..................... 150
Compass Variance....................... 150
Console, Overhead....................... 142
Contract, Service........................ 499
Coolant Pressure Cap (Radiator Cap).......... 439
Cooling System......................... 436
Adding Coolant (Antifreeze).............. 439
Coolant Capacity...................... 479
Coolant Level...................436,437,440
Disposal of Used Coolant................ 440
508 INDEX