oil pressure DODGE RAM 2500 DIESEL 2009 4.G User Guide
[x] Cancel search | Manufacturer: DODGE, Model Year: 2009, Model line: RAM 2500 DIESEL, Model: DODGE RAM 2500 DIESEL 2009 4.GPages: 532, PDF Size: 9.37 MB
Page 438 of 532
include cleaning of the condenser fins and a performance
test. Drive belt tension should also be checked at this
time.
WARNING!
•
Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause
the system to fail, requiring costly repairs. Refer to
Section 3 of the Warranty Information book for
further warranty information.
•
The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced repairman.NOTE:
Use only manufacturer approved A/C System
Sealers, Stop Leak Products, Seal Conditioners, Compres-
sor Oil, or Refrigerants.
Refrigerant Recovery and RecyclingR-134a air conditioning refrigerant is a hydrofluoro-
carbon (HFC) that is endorsed by the Environmental
Protection Agency (EPA) and is an ozone-saving product.
However, the manufacturer recommends that air condi-
tioning service be performed by authorized dealers or
other service facilities using recovery and recycling
equipment.Front Prop Shaft Lubrication — 2500/3500 (4X4)
ModelsLubricate the front driveshaft grease fitting at each oil
change. Refer to the “Maintenance Schedule” in Section 8
for the proper maintenance intervals. Use MOPAR Type
MS-6560 (lithium-based grease), or equivalent.
436 MAINTAINING YOUR VEHICLE
Page 486 of 532
At Each Stop for Fuel•
Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•
Check the windshield washer solvent and add if
required.
Once a Month
•
Check tire pressure and look for unusual wear or
damage.
•
Inspect the battery, clean and tighten the terminals as
required.
•
Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
•
Check all lights and other electrical items for correct
operation.
At Each Oil Change
•
Change the engine oil filter.
•
Inspect the brake hoses and lines.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.Required Maintenance IntervalsRefer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
484 MAINTENANCE SCHEDULES
8M A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S
Page 513 of 532
Bar, Stabilizer/Sway System................ 282
Battery ............................... 434
Emergency Starting ..................... 419
Saving Feature (Protection) ............... 133
Belts, Seat ............................ 35,75
Body Builders Guide ....................... 6
Body Mechanism Lubrication ............... 437
B-Pillar Location ........................ 350
Brake Assist System ...................... 335
Brake Control System, Electronic ............. 333
Brake Fluid ......................... 447,480
Brake System ........................ 330,447
Anti-Lock (ABS) .................... 331,333
Fluid Check .......................... 447
Master Cylinder ....................... 447
Parking ............................. 329
Warning Light ........................ 194
Break-In Recommendations, New Vehicle ........ 73
Bulb Replacement ....................... 465 Bulbs, Light
.......................... 76,464
Cab Top Clearance Lights .................. 473
Calibration, Compass ..................... 151
Camper ............................... 178
Capacities, Fluid ........................ 478
Caps, Filler Oil (Engine) .......................... 432
Power Steering ........................ 328
Radiator (Coolant Pressure) ............... 444
Car Washes ............................ 453
Carbon Monoxide Warning ............74,179,379
Cargo Light ............................ 135
CD (Compact Disc) Player ...............202,216
Cellular Phone .......................... 86
Center High Mounted Stop Light ............ 472
Center Lap Belts ......................... 44
Center Seat Storage Compartment .........167,169
Certification Label ....................... 381
INDEX 511
10
Page 517 of 532
Fluids, Lubricants and Genuine Parts.......... 479
Fog Lights ....................... 135,193,468
Fold Flat Load Floor ..................... 174
Four Wheel Drive ....................... 260
Four-Way Hazard Flasher .................. 406
Freeing A Stuck Vehicle ................... 421
Front Axle (Differential) ................... 448
Fuel ................................. 375
Adding ............................. 379
Filler Cap (Gas Cap) .................... 381
Gauge .............................. 200
Octane Rating ...................... 375,479
Requirements ...................... 375,478
Tank Capacity ........................ 478
Fuses ................................ 458
Garage Door Opener (HomeLink) ........... 153
Gas Cap (Fuel Filler Cap) ...............381,428
Gasoline (Fuel) ......................... 375 Gasoline, Reformulated
................... 375
Gauges ............................... 188
Coolant Temperature ................... 190
Fuel ............................... 200
Oil Pressure .......................... 190
Speedometer ......................... 189
Tachometer .......................... 189
Voltmeter ............................ 188
Gear Ranges ........................... 255
General Information ................. 18,114,374
Glass Cleaning .......................... 456
Grocery Bag Retainer ..................... 172
Gross Axle Weight Rating .................. 384
Gross Vehicle Weight Rating ................ 384
Guide, Body Builders ...................... 6
GVWR ............................... 381
Hands-Free Phone (uconnect) ............... 86
INDEX 515
10
Page 520 of 532
Electronic Stability Program (ESP)
Indicator......................... 197,340
Engine Temperature Warning .............. 200
Exterior .............................. 76
Fog .......................... 135,193,468
Four-Wheel Drive Indicator ............... 264
Hazard Warning Flasher ................. 406
Headlights ........................... 134
High Beam ........................ 137,189
High Beam Indicator .................... 189
High Beam/Low Beam Select ............. 137
Illuminated Entry ....................... 20
Instrument Cluster ..................... 188
Interior .......................... 132,145
Lights On Reminder .................... 135
Malfunction Indicator (Check Engine) ........ 194
Oil Pressure .......................... 201
Passing ............................. 137
Seat Belt Reminder ..................... 189 Security Alarm (Theft Alarm)
.............. 191
Service ........................... 464,465
Service Engine Soon (Malfunction Indicator) . . . 194
Side Marker .......................... 477
Theft Alarm (Security Alarm) .............. 191
Tire Pressure Monitoring (TPMS) ........... 197
Traction Control ....................... 340
Transfer Case ......................... 264
Transmission Warning ................... 199
Turn Signal ................... 76,136,465,469
Voltage ............................. 201
Warning (Instrument Cluster Description) ..... 188
Limited-Slip Differential ................... 304
Loading Vehicle ......................... 381
Tires ............................... 350
Locks ................................. 27
Child Protection ........................ 30
Door ................................ 27
Keys ................................ 12518 INDEX
Page 522 of 532
Oil Change Indicator..................... 193
Oil Change Indicator, Reset ................. 193
Oil, Engine ......................... 431,479
Capacity ............................ 478
Change Interval ....................... 432
Dipstick ............................. 431
Disposal ............................ 433
Filter ............................ 433,479
Filter Disposal ........................ 433
Identification Logo ..................... 432
Materials Added to ..................... 433
Pressure Gauge ....................... 190
Recommendation ................... 432,478
Synthetic ............................ 433
Viscosity ......................... 432,478
Onboard Diagnostic System ..............428,429
Opener, Garage Door (HomeLink) ........... 153
Operating Precautions .................... 428
Operator Manual (Owner’s Manual) ............ 4Outside Rearview Mirrors
.................. 83
Overdrive ............................. 257
Overdrive OFF Switch .................... 257
Overhead Console .................... 145,146
Overhead Travel Information Center .......... 146
Overheating, Engine ...................... 191
Owner’s Manual (Operator Manual) .........4,505
Parking Brake .......................... 329
Passenger Airbag On/Off Switch ............. 54
Passing Light ........................... 137
Pedals, Adjustable ....................... 141
Pets .................................. 73
Pets, Transporting ........................ 73
Phone, Cellular .......................... 86
Phone, Hands-Free (uconnect) ............... 86
Pickup Box ............................ 176
Placard, Tire and Loading Information ......... 350520 INDEX
Page 526 of 532
SteeringPower ........................... 327,328
Wheel Lock ........................... 14
Wheel, Tilt ........................... 140
Steering Wheel Mounted Sound System
Controls .............................. 231
Storage, Behind the Seat ................... 167
Storage Compartment, Center Seat .........167,169
Storage, Vehicle ......................... 463
Storing Your Vehicle ...................... 463
Sun Roof .............................. 159
Supplemental Tire Pressure Information ........ 360
Sway Control, Trailer ..................... 345
Synthetic Engine Oil ...................... 433
System, Navigation (uconnect gps).......... 224
System, Remote Starting .................... 25
Tachometer ............................ 189
Tailgate ............................... 178 Temperature Gauge, Engine Coolant
.......... 190
Tether Anchor, Child Restraint .............64,68
Tilt Steering Column ..................... 140
Tip Start .............................. 252
Tire and Loading Information Placard ......350,360
Tire Identification Number (TIN) ............. 349
Tire Markings .......................... 346
Tire Pressure Monitor System (TPMS) Placard
“HI” (MAX) Load Switch ...............184,185
Tire Safety Information .................... 346
Tires ............................ 76,354,506
Aging (Life of Tires) .................... 359
Air Pressure .......................... 354
Chains .............................. 361
Dual ............................ 365,416
General Information .................... 354
High Speed .......................... 356
Inflation Pressures ..................... 355
Jacking ............................. 409524 INDEX
Page 530 of 532
INTRODUCTION INTRODUCTION HOW TO USE THIS MANUAL WARNINGS AND CAUTIONS VAN CONVERSIONS/CAMPERS VEHICLE IDENTIFICATION NUMBER VEHICLE MODIFICATIONS/ALTERATIONS THINGS TO KNOW BEFORE STARTING YOUR VEHICLE
A WORD ABOUT YOUR KEYS Ignition Key RemovalLocking Doors With A KeySTEERING WHEEL LOCK - IF EQUIPPED To Manually Lock the Steering WheelTo Release the Steering Wheel LockAutomatic Transmission Ignition Interlock SystemSENTRY KEY Replacement
KeysCustomer Key ProgrammingGeneral InformationVEHICLE SECURITY ALARM - IF EQUIPPED Rearming of the SystemTo Set the AlarmTo Disarm the SystemILLUMINATED ENTRY SYSTEM - IF EQUIPPED REMOTE KEYLESS ENTRY (RKE) - IF EQUIPPED To
Unlock the DoorsTo Lock the DoorsUsing the Panic AlarmProgramming Additional RKE TransmittersGeneral InformationRKE Transmitter Battery ServiceREMOTE STARTING SYSTEM - IF EQUIPPED How to Use Remote StartDOOR LOCKS Manual Door LocksPower
Door Locks - If EquippedChild Protection Door LockWINDOWS Power Windows-If Equipped Wind BuffetingOCCUPANT RESTRAINTS Lap/Shoulder BeltsAdjustable Upper Shoulder Belt AnchorageAutomatic Locking Retractors (ALR) Mode - If EquippedCenter Lap Belts
Seat Belt Pretensioners - If EquippedEnhanced Seat Belt Use Reminder System (BeltAlert) Seat Belts and Pregnant WomenSeat Belt ExtenderDriver And Right Front Passenger Supplemental Restraint System (SRS) - Airbags Event Data Recorder (EDR)Child Restraints
ENGINE BREAK-IN RECOMMENDATIONS SAFETY TIPS Transporting PassengersExhaust GasSafety Checks You Should Make Inside the VehiclePeriodic Safety Checks You Should Make Outside the VehicleUNDERSTANDING THE FEATURES OF YOUR VEHICLE
MIRRORS Inside Day/Night MirrorAutomatic Dimming Mirror - If EquippedOutside MirrorsOutside Mirrors Folding FeaturePower Mirrors - If EquippedHeated Mirrors - If EquippedTrailer Towing Mirrors - If Equippeduconnect phone - IF EQUIPPED OperationPhone Call
Featuresuconnect phone FeaturesAdvanced Phone ConnectivityThings You Should Know About Your uconnect phoneGeneral InformationVOICE RECOGNITION (VR) SYSTEM - IF EQUIPPED Voice Recognition (VR) System OperationCommandsVoice TrainingSEATS
Manual Seat Adjuster - If EquippedReclining Seats (Quad Cab Models)Reclining Seats (2500/3500 Models)Adjustable Head RestraintsManual Lumbar Support - If EquippedPower Seats - If EquippedRear Seat FeaturesHeated Seats - If EquippedTO OPEN AND CLOSE
THE HOOD LIGHTS Interior LightsBattery SaverHeadlight DelayHeadlights, Parking Lights and Panel LightsDaytime Running Lights (Canada Only and Fleet Vehicles)Lights-on ReminderFog Lights - If EquippedCargo Light - If EquippedMultifunction LeverWINDSHIELD
WIPERS AND WASHERS Intermittent Wiper SystemWindshield WashersTILT STEERING COLUMN DRIVER ADJUSTABLE PEDALS - IF EQUIPPED AdjustmentELECTRONIC SPEED CONTROL - IF EQUIPPED To ActivateTo Set a Desired SpeedTo DeactivateTo Resume
SpeedTo Vary the Speed SettingTo Accelerate for PassingOVERHEAD CONSOLE - IF EQUIPPED Courtesy/Reading LightsOVERHEAD CONSOLE WITH COMPASS/TEMPERATURE MINI-TRIP COMPUTER - IF EQUIPPED US/M ButtonReset ButtonGlobal ResetStep
ButtonAverage Fuel Economy (AVG ECO)Distance To Empty (DTE)Trip Odometer (ODO)Elapsed Time (ET)C/T ButtonAutomatic Compass CalibrationManual Compass CalibrationRecalibrating The CompassOutside TemperatureGARAGE DOOR OPENER - IF EQUIPPED
Programming HomeLinkGate Operator/Canadian ProgrammingUsing HomeLinkReprogramming A Single HomeLink ButtonSecurityTroubleshooting TipsGeneral InformationPOWER SUNROOF - IF EQUIPPED Open Sunroof - Express ModeClosing Sunroof - ExpressPinch
Protect FeaturePinch Protect OverrideVenting Sunroof - ExpressSunshade OperationWind BuffetingSunroof MaintenanceSunroof Fully ClosedELECTRICAL POWER OUTLETS CIGAR LIGHTER AND ASH RECEIVER CUPHOLDERS Front Instrument Panel Cupholders
(40-20-40 Seats) - Automatic TransmissionFront Instrument Panel Cupholders (Bucket Seats)Rear Cupholder (Quad Cab) - If EquippedSTORAGE Center Storage Compartment (40-20-40 Seat) - If EquippedCenter Storage Compartment (Bucket Seats) - If EquippedStorage
and Seats (Quad Cab Models)Plastic Grocery Bag Retainers - If EquippedREAR WINDOW FEATURES Rear Window Defroster and Heated Outside Mirrors - If EquippedPower Sliding Rear Window - If EquippedSliding Rear Window - If EquippedFOLD FLAT LOAD FLOOR
- IF EQUIPPED PICKUP BOX SLIDE-IN CAMPERS Camper ApplicationsEASY-OFF TAILGATE UNDERSTANDING YOUR INSTRUMENT PANEL INSTRUMENT PANEL FEATURES RAM TRUCK POWER WAGON INSTRUMENT CLUSTER - BASE INSTRUMENT
CLUSTER - PREMIUM INSTRUMENT CLUSTER DESCRIPTION ELECTRONIC DIGITAL CLOCK Clock Setting ProcedureSALES CODE RAQ - AM/FM/CD (6-DISC) RADIO WITH OPTIONAL uconnect studios (SATELLITE RADIO), uconnect phone, AND VIDEO
ENTERTAINMENT SYSTEMS (VES) CAPABILITIES Operating Instructions - Radio ModeOperation Instructions - (CD Mode for CD Audio Play)LOAD/EJECT Button (CD Mode for CD Audio Play)Notes On Playing MP3 FilesOperation Instructions - (CD Mode for MP3 Audio
Play)LOAD/EJECT Button (CD Mode for MP3 Play)SALES CODE REF - AM/FM/CD (SINGLE-DISC) RADIO WITH OPTIONAL uconnect studios (SATELLITE RADIO) AND uconnect phone CAPABILITY Operating Instructions - Radio ModeOperating Instructions - CD Mode
Operating Instructions - Auxiliary ModeOperating Instructions - uconnect phone - If EquippedOperating Instructions - uconnect studios (Satellite Radio) - If EquippedSALES CODE REC - AM/FM/CD (6-DISC) RADIO WITH uconnect gps (NAVIGATION) Operating Instructions
- uconnect studios (Satellite Radio) - If EquippedREC Setting the Clockuconnect studios (SATELLITE RADIO) - IF EQUIPPED System ActivationElectronic Serial Number/Sirius Identification Number (ESN/SID)Selecting uconnect studios (Satellite) Mode in REF, RAQ, And
RAK RadiosSelecting A ChannelStoring And Selecting Preset ChannelsUsing The PTY (Program Type) Button - If EquippedPTY Button SCANPTY Button SEEKSatellite AntennaReception QualityVIDEO ENTERTAINMENT SYSTEM (VES) - IF EQUIPPED REMOTE SOUND
SYSTEM CONTROLS - IF EQUIPPED Radio OperationCD PlayerCD/DVD MAINTENANCE RADIO OPERATION AND CELLULAR PHONES CLIMATE CONTROLS Heater Only - If Equipped Air Conditioning and Heating - If Equipped Air Conditioning with Dual Zone
Temperature Control - If EquippedOperating TipsOperating Tips Chart STARTING AND OPERATING STARTING PROCEDURES Normal StartingAutomatic TransmissionIf Engine Fails To StartAfter StartingENGINE BLOCK HEATER - IF EQUIPPED AUTOMATIC
TRANSMISSION Automatic Transmission with OverdriveFOUR-WHEEL DRIVE OPERATION - IF EQUIPPED Manually Shifted Transfer Case Operating Information/PrecautionsShifting Procedure - Manually Shifted Transfer Case Transfer Case Position Indicator Light
Electronically Shifted Transfer Case Operating Information/Precautions (Five Position Switch) - If EquippedShifting Procedure - Electronically Shifted Transfer CaseElectronically Shifted Transfer Case Operating Information/Precautions (Four Position Switch) - If Equipped
Shifting Procedure - Electronically Shifted Transfer CaseAXLE LOCKER SYSTEM - POWER WAGON ONLY STABILIZER/SWAY BAR SYSTEM - POWER WAGON ONLY SAFE OFF-ROAD DRIVING - POWER WAGON ONLY Off-Road Driving Tips and Vehicle
CharacteristicsDriving In Snow, Mud And SandCrossing Obstacles (Rocks And Other High Points)Hill ClimbingDriving Through WaterAiring Down For Off-Road DrivingVehicle RecoveryAfter Driving Off-RoadLIMITED-SLIP DIFFERENTIAL - IF EQUIPPED DRIVING ON
SLIPPERY SURFACES DRIVING THROUGH WATER Flowing/Rising WaterShallow Standing WaterDRIVING OFF-ROAD - RAM TRUCK ONLY WINCH USAGE - IF EQUIPPED (POWER WAGON ONLY) Things To Know Before Using Your WinchUnderstanding The Features
Of Your Winch Winch AccessoriesOperating Your WinchRigging TechniquesPOWER STEERING Power Steering Fluid CheckPARKING BRAKE BRAKE SYSTEM 3500 Dual Rear Wheel Models OnlyFour-Wheel Anti-Lock Brake SystemELECTRONIC BRAKE CONTROL
SYSTEM - IF EQUIPPED Anti-Lock Brake System (ABS)Traction Control System (TCS)Brake Assist System (BAS)Hill Start Assist (HSA)Electronic Roll Mitigation (ERM)Electronic Stability Program (ESP)TSC (Trailer Sway Control)TIRE SAFETY INFORMATION Tire Markings
Tire Identification Number (TIN)Tire Loading and Tire PressureTIRES - GENERAL INFORMATION Tire PressureTire Inflation PressuresTire Pressures for High Speed OperationRadial Ply TiresTire SpinningTread Wear IndicatorsLife of TireReplacement TiresSUPPLEMENTAL
TIRE PRESSURE
INFORMATION - IF EQUIPPED TIRE CHAINS SNOW TIRES TIRE ROTATION RECOMMENDATIONS Dual Rear Wheels TIRE PRESSURE MONITOR SYSTEM (TPMS) - IF EQUIPPED Tire Pressure Monitor System (TPMS) Tire Light Load Inflation Switch Description
- If EquippedTire Pressure Monitor System ComponentsGeneral InformationFUEL REQUIREMENTS Reformulated GasolineGasoline/Oxygenate BlendsE-85 Usage In Non-Flex Fuel VehiclesMMT In GasolineMaterials Added To FuelFuel System CautionsCarbon Monoxide
WarningsADDING FUEL Loose Fuel Filler Cap (Gas Cap) MessageVEHICLE LOADING Certification LabelTRAILER TOWING Common Towing DefinitionsTrailer Hitch ClassificationTrailer Towing Weights (Maximum Trailer Weight Ratings)Trailer and Tongue WeightTowing
RequirementsTowing TipsSNOWPLOW RECREATIONAL TOWING (BEHIND MOTORHOME, ETC.) Recreational Towing - Two-Wheel Drive ModelsRecreational Towing - Four-Wheel Drive ModelsEQUIPMENT IDENTIFICATION PLATE WHAT TO DO IN EMERGENCIES
HAZARD WARNING FLASHER JACKING INSTRUCTIONS Jack LocationRemoving The Spare TireTire Changing ProcedurePreparationsInstructionsHub Caps/Wheel CoversHOISTING JUMP-STARTING PROCEDURES FREEING A STUCK VEHICLE EMERGENCY TOW
HOOKS - IF EQUIPPED TOWING A DISABLED VEHICLE 4-Wheel Drive Vehicles2-Wheel Drive VehiclesMAINTAINING YOUR VEHICLE ENGINE COMPARTMENT- 5.7L ONBOARD DIAGNOSTIC SYSTEM (OBD II) Loose Fuel Filler Cap MessageEMISSIONS
INSPECTION AND MAINTENANCE PROGRAMS REPLACEMENT PARTS DEALER SERVICE MAINTENANCE PROCEDURES Engine OilEngine Oil FilterEngine Air Cleaner FilterMaintenance-Free BatteryAir Conditioner MaintenanceFront Prop Shaft Lubrication -
2500/3500 (4X4) ModelsBody LubricationWindshield Wiper BladesAdding Washer FluidExhaust SystemCooling SystemBrake SystemRear Axle And 4x4 Front Driving Axle Fluid LevelTransfer CaseAutomatic TransmissionAppearance Care and Protection from Corrosion
FUSES Integrated Power ModuleVEHICLE STORAGE REPLACEMENT LIGHT BULBS BULB REPLACEMENT Headlight (Halogen)/Front Park and Turn LightsFog LightsTail, Stop, Turn and Backup LightsCenter High-Mounted Stoplight (CHMSL) With Cargo LightCab Top
Clearance Lights - If EquippedTailgate ID Lights (Dual Rear Wheels) - If EquippedRear Light Bar ID Marker (Dual Rear Wheel) - If EquippedSide Marker Lights (Dual Rear Wheels) FLUIDS AND CAPACITIES FLUIDS, LUBRICANTS AND GENUINE PARTS EngineChassis
MAINTENANCE SCHEDULES EMISSIONS CONTROL SYSTEM MAINTENANCE MAINTENANCE SCHEDULE Required Maintenance IntervalsIF YOU NEED CONSUMER ASSISTANCE SUGGESTIONS FOR OBTAINING SERVICE FOR YOUR VEHICLE Prepare For
The AppointmentPrepare A ListBe Reasonable With RequestsIF YOU NEED ASSISTANCE Chrysler LLC Customer CenterChrysler Canada Inc. Customer CenterIn Mexico contactCustomer Assistance For The Hearing Or Speech Impaired (TDD/TTY)Service Contract
WARRANTY INFORMATION (U.S. Vehicles Only) MOPAR PARTS REPORTING SAFETY DEFECTS In The 50 United States And Washington, D.CIn CanadaPUBLICATION ORDER FORMS DEPARTMENT OF TRANSPORTATION UNIFORM TIRE QUALITY GRADES
TreadwearTraction GradesTemperature GradesINDEX