maintenance schedule DODGE RAM 3500 DIESEL 2008 3.G Owner's Manual

(Miles) (82,500) (90,000) (97,500) (100,000) (105,000)
Kilometers 133 000 145 000 157 000 160 000 169 000
[Months] [66] [72] [78] [84]
Change engine oil and engine oil filter. X X X X
Lubricate Front Drive Shaft Fitting (4X4). X X X X
Rotate tires. X X X X
Lubricate outer tie rod ends. X X X X
Flush and replace engine coolant, if not replaced at
60 mos.***X
Inspect the transfer case fluid (4X4). X
Change front and rear axle fluid (4X4). X X
Inspect drive belt, replace as required.* X X
Replace fuel filter element. X X
Inspect front wheel bearings. X
Inspect brake linings. X X
Inspect and adjust parking brake if necessary. X X
490 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

(Miles) (112,500) (120,000) (127,50) (135,000) (142,500) (150,000)
Kilometers 181 000 193 000 205 0000 217 000 229 000 241 000
[Months] [90] [96] [102] [108] [114] [120]
Change engine oil and engine oil filter. X XXXXX
Lubricate Front Drive Shaft Fitting (4X4). X XXXXX
Rotate tires. X XXXXX
Lubricate outer tie rod ends. X XXXXX
Flush and replace engine coolant at 120 months,
if not replaced at 100,000 miles (161 000 km).***X
Inspect drive belt, replace as required.* X X X
Change transfer case fluid (4X4). X
Check transfer case fluid level (4X4).X
Change front and rear axle fluid (4X4). X X X
Change the automatic transmission fluid & filter. X X
Change manual transmission fluid. X
Replace fuel filter element. X X X
Inspect front wheel bearings. X X
MAINTENANCE SCHEDULES 491
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

(Miles) (112,500) (120,000) (127,50) (135,000) (142,500) (150,000)
Kilometers 181 000 193 000 205 0000 217 000 229 000 241 000
[Months] [90] [96] [102] [108] [114] [120]
Inspect the brake linings, replace if necessary. X X
Inspect and adjust parking brake if necessary. X X
Adjust valve lash clearance.X
Replace Crankcase Ventilation Filter (CCV).X
Clean the EGR Valve.X
Clean the EGR Cooler.X
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
*This maintenance is not required if belt was previously
replaced.**The EGR Valve and EGR Cooler maintenance will be
covered by the manufacturer only at this maintenance
interval, for vehicles registered in California, Maine,
Massachusetts, New York and Vermont.
492 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

CAUTION!
***The manufacturer highly recommends that all
cooling system service, maintenance, and repairs be
performed by your local authorized dealer.
WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which you
have the knowledge and the right equipment. If you
have any doubt about your ability to perform a service
job, take your vehicle to a competent mechanic.
MAINTENANCE SCHEDULES 493
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Power Door........................... 27
Steering Wheel......................... 18
Lower Anchors and Tether for CHildren
(LATCH).............................. 65
Lubrication, Body....................... 433
Lug Nuts............................. 392
Lumbar Support........................ 119
Maintenance........................... 410
Maintenance Procedures................... 412
Maintenance Schedule.................... 484
Manual, Service......................... 501
Manual Transmission..................291,447
Fluid Level Check...................446,447
Lubricant Selection..................... 482
Shift Speeds.......................... 292
Map/Reading Lights..................... 142
Mirrors................................ 84
Automatic Dimming..................... 85Electric Powered....................... 86
Outside.............................. 85
Rearview............................. 84
Trailer Towing......................87,370
Modifications/Alterations, Vehicle............. 8
Monitor, Tire Pressure System............... 338
Mopar Parts.........................409,500
Multi-Function Control Lever............... 133
Navigation Radio........................ 238
Navigation System....................... 238
New Vehicle Break-In Period................ 74
Noise Control
Maintenance.......................... 452
Tampering Prohibited................... 452
Noise Emission Warranty...............451,453
Occupant Restraints....................... 35
Odometer..........................192,199
INDEX 515
10