power steering DODGE RAM 5500 CHASSIS CAB 2009 4.G User Guide

Chassis
ComponentFluid, Lubricant, or Genuine Part
Automatic Transmission (5-Speed
545RFE) MOPAR
ATF+4 Automatic Transmission Fluid
Transfer Case MOPARATF+4 Automatic Transmission Fluid
Front and Rear Axle Fluid (4500/
5500) GL-5 SAE 75W-90 Synthetic (MS-9763) or equivalent.
Brake Master Cylinder MOPARDOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir MOPARATF+4 Automatic Transmission Fluid
MAINTAINING YOUR VEHICLE 379
7

•Change your engine oil more often if you drive your
vehicle off-road for an extended period of time.
•Under no circumstances should oil change intervals
exceed 6,000 miles (10,000 km) or 6 months, whichever
comes first.
Your dealer will reset the oil change indicator message
after completing the scheduled oil change. If this sched-
uled oil change is performed by someone other than your
dealer the message can be reset by referring to the steps
described under “Odometer/Trip Odometer” under “In-
strument Cluster Description” in Section 4 of this.
At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
•Check all lights and other electrical items for correct
operation.
MAINTENANCE SCHEDULES 383
8
M A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S

96,000 Miles (160,000 km) or 96 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the
engine air cleaner filter, replace if necessary.
❏ Inspect the brake linings, replace if necessary.
❏ Lubricate outer tie rod ends.
❏ Inspect the front suspension, tie rod ends, and boot seals, replace if necessary.
❏ Lube front drive shaft fitting (4x4 only).
❏ Inspect the CV Joints.
❏ Inspect exhaust system.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
102,000 Miles (170,000 km) or
102 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏ Rotate tires.
❏ Lube front drive shaft fitting (4x4 only).
❏ Lubricate outer tie rod ends.
❏ Flush and replace the engine coolant if
not done at 60 months.
❏ Flush and replace power steering fluid.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
MAINTENANCE SCHEDULES 393
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S

Emergency Starting..................... 326
Saving Feature (Protection) ............... 124
Belts, Seat .............................. 36
Body Builders Guide ....................... 6
Body Mechanism Lubrication ............... 343
B-Pillar Location ........................ 262
Brake Fluid ............................ 379
Brake System ........................ 255,353
Anti-Lock (ABS) ....................... 256
Fluid Check .......................... 353
Master Cylinder ....................... 353
Parking ............................. 254
Warning Light ........................ 168
Bulb Replacement ....................... 370
Bulbs, Light ............................ 370
Cab Top Clearance Lights .................. 375
Calibration, Compass ..................... 141
Capacities, Antifreeze (Engine Coolant) ........ 377Capacities, Fluid
........................ 377
Caps, Filler Oil (Engine) .......................... 339
Power Steering ........................ 253
Radiator (Coolant Pressure) ............... 351
Car Washes ............................ 360
Carbon Monoxide Warning ................. 284
CD (Compact Disc) Player ...............173,187
Cellular Phone .......................... 86
Center Lap Belts ......................... 45
Center Seat Storage Compartment .........148,150
Certification Label ....................... 287
Chart, Tire Sizing ........................ 259
Check Engine Light
(Malfunction Indicator Light) ............... 168
Child Restraint .......................... 60
Child Restraint Tether Anchors .............64,67
Child Seat ............................ 60,66
Cigar Lighter ........................... 145
INDEX 411
10

CleaningWheels ............................. 361
Climate Control ......................... 204
Clock ........................ 172,175,189,195
Compact Disc (CD) Maintenance ............. 203
Compass ........................... 140,141
Compass Calibration ..................... 141
Compass Variance ....................... 143
Computer, Trip/Travel .................... 136
Contract, Service ........................ 403
Coolant Pressure Cap (Radiator Cap) .......... 351
Cooling System ......................... 348
Adding Coolant (Antifreeze) .............. 350
Coolant Capacity ...................... 377
Coolant Level ...................... 348,352
Disposal of Used Coolant ................ 352
Drain, Flush, and Refill .................. 349
Inspection ........................... 352
Points to Remember .................... 352 Pressure Cap
......................... 351
Radiator Cap ......................... 351
Selection of Coolant (Antifreeze) .........349,378
Cruise Control (Speed Control) .............. 133
Cupholders ............................ 146
Customer Assistance ..................... 401
Data Recorder, Event ...................... 57
Daytime Running Lights ................... 126
Dealer Service .......................... 337
Defroster, Rear Window ................... 153
Defroster, Windshield ................74,205,208
Delay (Intermittent) Wipers ................. 129
Differential, Limited-Slip .................. 249
Dipsticks .............................. 338
Power Steering ........................ 253
Disposal .............................. 340
Antifreeze (Engine Coolant) ............... 352
Engine Oil ........................... 340
412 INDEX

Fabric Care............................ 361
Filters Air Cleaner .......................... 340
Engine Fuel .......................... 378
Engine Oil ..................... 338,340,378
Flashers Turn Signal .......................... 127
Flat Tire Stowage ........................ 326
Flooded Engine Starting ................... 222
Fluid, Brake ........................... 379
Fluid Capacities ......................... 377
Fluid Level Checks Brake .............................. 353
Manual Transmission ................... 356
Power Steering ........................ 253
Transfer Case ......................... 356
Fluids, Lubricants and Genuine Parts .......... 378
Fog Lights ....................... 126,167,374
Fold Flat Load Floor ..................... 154 Four Wheel Drive
....................... 230
Four-Way Hazard Flasher .................. 314
Freeing A Stuck Vehicle ................... 330
Front Axle (Differential) ................... 355
Fuel ................................. 281
Adding ............................. 285
Diesel .............................. 378
Filler Cap (Gas Cap) .................... 286
Filter ............................... 378
Gauge .............................. 171
Light ............................... 172
Octane Rating ........................ 281
Requirements ......................... 281
Tank Capacity ........................ 377
Fuses ................................ 364
Gas Cap (Fuel Filler Cap) ...............286,336
Gasoline (Fuel) ......................... 281
Gasoline, Reformulated ................... 281
414 INDEX

Power Door........................... 28
Steering Wheel ......................... 14
Lower Anchors and Tether for CHildren
(LATCH) .............................. 64
Lubrication, Body ....................... 343
Lug Nuts ........................... 320,322
Lumbar Support ........................ 118
Maintenance ........................... 337
Maintenance Free Battery .................. 341
Maintenance Procedures ................... 338
Maintenance Schedule .................382,384
Maintenance Schedules .................... 382
Manual, Service ......................... 405
Manual Transmission Fluid Level Check ..................... 356
Lubricant Selection ..................... 379
Mirrors ................................ 81
Automatic Dimming ..................... 82 Electric Powered
....................... 83
Outside .............................. 82
Rearview ............................. 81
Trailer Towing ......................... 84
Modifications/Alterations, Vehicle ............. 7
Mopar Parts ......................... 337,404
Multi-Function Control Lever ............... 126
Navigation Radio ........................ 194
Navigation System ....................... 194
New Vehicle Break-In Period ................ 72
Occupant Restraints ....................... 35
Octane Rating, Gasoline (Fuel) .............. 281
Odometer .......................... 166,171
Trip ............................. 166,171
Oil Change Indicator ..................... 167
Oil, Engine ............................ 378
Capacity ............................ 377
418 INDEX

Change Interval....................... 339
Dipstick ............................. 338
Disposal ............................ 340
Filter ......................... 338,340,378
Identification Logo ..................... 339
Materials Added to ..................... 340
Pressure Gauge ....................... 164
Recommendation ...................... 339
Synthetic ............................ 340
Viscosity ............................ 339
Onboard Diagnostic System ................ 336
Operating Precautions .................... 336
Operator Manual (Owner’s Manual) ............ 4
Outside Rearview Mirrors .................. 82
Overdrive ............................. 227
Overdrive OFF Switch .................... 227
Overhead Console ....................... 136
Overhead Travel Information Center .......... 136
Overheating, Engine ...................... 165 Owner’s Manual (Operator Manual)
.........4,405
Parking Brake .......................... 254
Passenger Airbag On/Off Switch ............. 53
Passing Light ........................... 128
Pedals, Adjustable ....................... 131
Pets .................................. 72
Pets, Transporting ........................ 72
Phone, Cellular .......................... 86
Phone, Hands-Free (UConnect) .............. 86
Placard, Tire and Loading Information ......... 262
Power Door Locks ........................... 28
Mirrors .............................. 83
Outlet (Auxiliary Electrical Outlet) .......... 144
Seats ............................... 118
Sliding Rear Window ................. 34,154
Steering .......................... 252,253
Windows ............................. 32
INDEX 419
10

Power Steering Fluid..................... 379
Pregnant Women and Seat Belts .............. 47
Programming Transmitters
(Remote Keyless Entry) .................... 24
Radial Ply Tires ......................... 272
Radiator Cap (Coolant Pressure Cap) .......348,351
Radio, Navigation ....................... 194
Radio Operation ...................... 173,187
Radio Remote Controls .................... 201
Radio, Satellite ....................... 195,197
Radio (Sound Systems) .................173,187
Rear Axle (Differential) .................355,356
Rear Window Features .................... 153
Rear Window, Sliding ................... 34,154
Reclining Front Seats ..................... 116
Recorder, Event Data ...................... 57
Recreational Towing ...................... 304
Shifting into Transfer Case Neutral (N) ....305,307 Shifting out of Transfer Case
Neutral (N)
....................... 306,309
Reformulated Gasoline .................... 281
Refrigerant ............................ 343
Reminder, Seat Belt ....................... 46
Remote Keyless Entry (RKE) ................. 21
Remote Sound System (Radio) Controls ........ 201
Remote Starting System .................... 26
Replacement Keys ........................ 16
Replacement Parts ....................... 337
Replacement Tires ....................... 274
Reporting Safety Defects ................... 404
Resetting Oil Change Indicator .............. 167
Restraint, Head ......................... 117
Restraints, Child ....................... 60,66
Restraints, Occupant ...................... 35
Rotation, Tires .......................... 279
Safety Checks Inside Vehicle ................. 74
420 INDEX

Transfer Case, Shifting into Transfer
Case Neutral (N).................... 305,307
Transfer Case, Shifting out of Transfer
Case Neutral (N) .................... 306,309
Shoulder Belt Upper Anchorage .............. 44
Shoulder Belts ........................... 36
Signals, Turn ........................... 127
Sliding Rear Window Power ............................ 34,154
Snow Chains (Tire Chains) ................. 276
Snow Plow ............................ 300
Snow Tires ............................ 278
Spark Plugs ............................ 378
Speed Control (Cruise Control) .............. 133
Speedometer ........................... 163
Starting ............................... 221
Automatic Transmission ................. 221
Engine Fails to Start .................... 222
Remote .............................. 26 Starting Procedures (Gas Engines)
............ 221
Steel Carcass Ply Tires .................... 269
Steering Power ........................... 252,253
Wheel Lock ........................... 14
Wheel, Tilt ........................... 130
Steering Wheel Mounted Sound
System Controls ......................... 201
Storage, Behind the Seat ................... 148
Storage Compartment, Center Seat .........148,150
Storage, Vehicle ......................... 369
Storing Your Vehicle ...................... 369
Supplemental Tire Pressure Information ........ 276
Synthetic Engine Oil ...................... 340
System, Navigation ...................... 194
System, Remote Starting .................... 26
Tachometer ............................ 163
Temperature Gauge, Engine Coolant .......... 164
422 INDEX