engine overheat DODGE SPRINTER 2004 1.G User Guide

214 MAINTAINING YOUR VEHICLE
 Open the hood.
 At first, only turn the radiator cap to the first detent
to release the pressure from the cooling system.
Only then should the radiator cap be removed
completely.
 To add coolant:
If the engine is cold:
Add coolant until the coolant level reaches the base
area which is visible through the filler opening (area
moistened).
If the engine is already at its regular operating
temperature:
Add coolant until the coolant level is about 0.6 inch
WARNING!
In order to avoid any possibly serious burns:
 If you see flames or smoke coming from the
engine compartment, or if the coolant
temperature gauge indicates that the engine is
overheated, do not open the hood. Move away
from the vehicle and do not open the hood until
the engine has cooled. If necessary, call the fire
department.
 Do not remove pressure cap on coolant reservoir
if engine temperature is above 194 °F (+90 ×C).
Allow engine to cool down before removing cap.
The coolant reservoir contains hot fluid and is
under pressure.
 Using a rag, slowly open cap approximately 1/2
turn to relieve excess pressure. If opened
immediately, scalding hot fluid and steam will
be blown out under pressure.
 Do not spill antifreeze on hot engine parts.
Antifreeze contains ethylene glycol which may
burn if it comes into contact with hot engine
parts.
 Check coolant level only with the engine
switched off and the key in position 0 in the
ignition lock.
Freightliner-all.book Pag e 214 Monday, December 1, 2003 2:54 PM

INDEX 269
10
Overheating (Air Heater) . . . . . . . . . . . . . . . . . . . . . . 131
Overheating (Water Heater) . . . . . . . . . . . . . . . . . . . 131PPassenger Compartment Protection . . . . . . . . . . . . . . 21
Alarm Pushbutton . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Switching off . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Permissible Roof Load . . . . . . . . . . . . . . . . . . . . . . . . 177
Programmed Top Speed . . . . . . . . . . . . . . . . . . . . . . . 173RRear Cargo Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Rear Seat Bench . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Removal and Installation . . . . . . . . . . . . . . . . . . . . . 58
Recommended Fluids and Lubricants . . . . . . . . . . . 245
Refueling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 172
Regular Checks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 208
Relay Assignment, Standard Equipment . . . . . . . . . 230
Remote Keyless Entry . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Locking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Replacing Batteries . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Unlocking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17Removing a Wheel. . . . . . . . . . . . . . . . . . . . . . . . . . . . 195
Replacing Wiper Blades . . . . . . . . . . . . . . . . . . . . . . . 218
Reporting safety Defects . . . . . . . . . . . . . . . . . . . . . . . 259
Reserve Fuel Indicator Lamp . . . . . . . . . . . . . . . . . . . . 94
Residual Engine Heat Utilization . . . . . . . . . . . . . . . 115
Residual Engine Heat Utilization (REST). . . . . . . . . 115
Restraints, Occupant . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
Retrofitting Seat Mounting Cups . . . . . . . . . . . . . . . . 59
Ribbed V-Belt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 211
Roof Load . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 177
RPMs, Constant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 137
SSafety Tips . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Seat Belt Warning Lamp and Airbag Malfunction . . 38
Seat Belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Belt Tensioners . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Fastening and Removing . . . . . . . . . . . . . . . . . . . . . 38
Height Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Seat Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Freightliner-all.book Pag e 269 Monday, December 1, 2003 2:54 PM