air condition DODGE SPRINTER 2004 1.G Owner's Manual

MAINTAININ G YOUR VEHICLE 221
7
A utomatic Car WashIf the vehicle is very dirty, prewash it before you drive
into the car wash.
Fold in the exterior mirrors before washing the vehicle
in an automatic car wash and make sure that the
windshield wiper switch is in position 0.
The exterior mirrors and windshield wipers could
otherwise be damaged.
Make sure that mirrors are fully folded out after
leaving the automatic car wash.
Tar StainsQuickly remove tar stains before they dry and become
more difficult to remove. A tar remover is
recommended.Paintwork, Painted Body ComponentsPaint care should be applied when water drops on the
paint surface do not "bead up", normally every 3 to
5 months, depending on climate and washing
detergent used.
Paint cleaner should be applied if paint surface shows
signs of dirt embedding (i.e. loss of gloss).
Do not apply any of these products or wax if your
vehicle is parked in the sun or if the hood is still hot.
Use the appropriate paint stick for quick and
provisional repairs of minor paint damage (i.e., chips
from stones, vehicle doors etc.).Engine Cleaning Prior to cleaning the engine compartment, make sure
to protect electrical components and connectors from
the intrusion of water and cleaning agents.
WARNING!
Smears impair visibility, which is impaired fur-
ther by unfavourable conditions (e.g. fog, dark-
ness, driving snow).
If a wax preservative is sprayed on after washing
the vehicle, wipe off the wax from the windshield
and the wiper blade rubbers. This will prevent
smears forming on the windshield.
Freightliner-all.book Pag e 221 Monday, December 1, 2003 2:54 PM

MAINTENANCE SCHEDULES 251
8M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
SPECIAL MAINTENANCE REQUIREMENTSIf bodies built by manufacturers other than
DaimlerChrysler Corporation are fitted to the vehicle, the
maintenance requirements and lubrication intervals
specified by the body manufacturer must be adhered to,
in addition to all standard maintenance requirements.Brake FluidOnly use brake fluids approved by the manufacturer
(DOT 4 plus). Information about brake fluids is
available from your Sprinter Dealer.CoolantHave the corrosion inhibitor/antifreeze concentration
in the coolant checked before the onset of winter (once
a year in countries with high prevailing temperatures).
Have the coolant renewed every five years or 100,000
miles.Dust Filter for Heating/Ventilation ReplacementThe dust filter and the tailgate interior filter are
renewed during routine maintenance service.
However, if operating conditions are dusty, these
filters should be renewed more frequently.
ENGINE OIL CHA NGE A ND FILTER
REPLACEMENTIn a minimum, change the engine oil and oil filter once
a year - even if the vehicle mileage per year is extremly
low. For standard oil service schedules, please see the
chapter oil service and maintenance service.Once a YearSelect the viscosity of the engine oil (SAE classes)
according to the outside air temperature.
Only use engine oil approved by DaimlerChrysler
Corporation if following the ASSYST system
guidelines.
Information is available from your Sprinter Dealer.
If the fuel used has a sulphur content exceeding 0.05 %
by weight, the service intervals should be split in half.
If the sulphur content of the fuel used is between 0.3%
and 0.8% by weight, the service intervals should be
split in half (i.e. every 5,000 miles instead of every
10,000 miles).
Freightliner-all.book Pag e 251 Monday, December 1, 2003 2:54 PM

MAINTENANCE SCHEDULES 253
8M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
Check fluid levels for the following systems, correct
as necessary.
Should there be a loss of fluid which cannot be
explained by regular use, trace and eliminate
the cause.
Engine cooling system
Check corrosion inhibitor/antifreeze,
refill as necessary.
Hydraulic brake system
Battery
Windscreen washer system
Engine
Fuel filter renewal
Air cleaner with maintenance indicator:
Check degree of contamination.
Air cleaner filter element renewed as
necessary.Chassis and body
Trailer coupling:
Check operation, play and retaining fixtures
Secondary rubber springs:
Visual check
Tire pressures:
Correct as necessary, including spare tyre
Check thickness of brake pads
Brake test
Check condition of brake disks. Brake disks renewal as
necessary
– as a separate order
Check condition of steering mechanism
Heating/ventilation dust filter renewal
Freightliner-all.book Pag e 253 Monday, December 1, 2003 2:54 PM

INDEX
10
A Special Note Concerning Vehicle Alteration . . . . 184
Acceleration Skid Control . . . . . . . . . . . . . . . . . . . . . 155
Deactivating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 159
Indicator Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . 155
Warning Lamp . . . . . . . . . . . . . . . . . . . . . . . . 137, 157
Acceleration Skid Control (ASR). . . . . . . . . . . . 157, 158
Air Bag, Front Seat Passenger . . . . . . . . . . . . . . . . . . . 42
Air Conditioner for the Rear Passenger
Compartment
Air Recirculation . . . . . . . . . . . . . . . . . . . . . . . . . . . 119
Air Strainer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 120
Air Conditioning
Climate Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . 116
Dehumidification . . . . . . . . . . . . . . . . . . . . . . . . . . 117
Rear Passenger Compartment . . . . . . . . . . . . . . . 117Air Conditioning, Regulated . . . . . . . . . . . . . . . . . . . 115
Air Filter Restriction Indicator . . . . . . . . . . . . . . . . . . 209
Air Recirculation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 110
Air Vents
Center . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 113
Side . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 113
Upper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 113
Airbag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Driver’s . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
Malfunction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
Passenger . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
Airbag Malfunction . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
Airbag, Drivers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
Alarm Pushbutton . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22Freightliner-all.book Pag e 261 Monday, December 1, 2003 2:54 PM