battery DODGE SPRINTER 2004 1.G Owner's Manual
[x] Cancel search | Manufacturer: DODGE, Model Year: 2004, Model line: SPRINTER, Model: DODGE SPRINTER 2004 1.GPages: 272, PDF Size: 22.71 MB
Page 216 of 272
216 MAINTAINING YOUR VEHICLEBA TTERIESThe standard battery is located in the engine
compartment.The auxiliary battery is located underneath the front
passenger seat (optional equipment).
The battery will not achieve its maximum service life
unless it is kept adequately charged at all times. If the
vehicle is used primarily for short distances, or left
parked for lengthy periods, have the battery charge
checked more frequently.
Disconnecting the Battery
WARNING!
Failure to follow these instructions can result in
severe personal injuries and death.
Never lean over batteries while connecting, you
might get injured, if the battery explodes.
Battery fluid contains sulfuric acid. Do not allow
this fluid to come in contact with eyes, skin or
clothing. In case it does, immediately flush
affected area with water and seek medical help if
necessary.
A battery will also produce hydrogen gas, which
is flammable and explosive. Keep flames or
sparks away from battery, avoid improper
connection of jumper cables, smoking etc.
Use only impact-resistant batteries with a central
gas release cover to prevent corrosion damage and
to prevent occupants from caustic burns in the
event of an accident.
CAUTION!
Do not loosen or remove the battery terminal
clamps while the engine is running or the key is in
the ignition lock as this could damage electrical or
electronic equipment beyond repair. All electrical
consumers must be switched off.
Do not place any metal objects on the battery.
Doing so may cause a short-circuit.
Loosen and remove the negative terminal clamp
first, then the positive terminal.
Afterwards disconnect vent tube from the fitting.
Freightliner-all.book Pag e 216 Monday, December 1, 2003 2:54 PM
Page 217 of 272
MAINTAININ G YOUR VEHICLE 217
7
Reconnecting the Battery1. Vent tube
2. Fitting
All electrical consumers must be switched off. First
connect and tighten the positive terminal clamp, then
the negative terminal. Make sure that the terminal
clamps are not switched.
NOTE: If batteries have to be replaced, only use
batteries with a central vent cap as this will prevent
corrosion damage.
Connect the battery vent tube (1) to the fitting (2).
Charging the BatteryDisconnect the battery before charging it with a battery
charger.
Comply with the operating instructions for the battery
charger.
To ensure that the battery is disposed of in an
environmentally responsible manner, it should only be
replaced by an authorized Sprinter Dealer.
Batteries contain material that can harm the
environment with improper disposal.
Large 12 volt storage batteries contain lead.
Recycling of batteries is the preferred method of
disposal.
Many states require sellers of batteries to accept old
batteries for recycling.
Freightliner-all.book Pag e 217 Monday, December 1, 2003 2:54 PM
Page 250 of 272
250 MAINTENANCE SCHEDULES
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S8
MA INTENA NCE - WITH A SSYST MA INTENA NCE
COMPUTERASSYST provides you with information on the best
possible timing for maintenance work.
NOTE: The engine manufacturer strongly
recommends the use of synthetic engine oils, such as
Mobil 1 SAE 0W-40.
When the next maintenance service is due, this will be
indicated in the multi-function display with the
symbol
9 Oil service
9 Maintenance service - displayed in km/miles
or days.
9
If the display shows the number of days, the symbol
È will also appear in the multi-function display.
You should have the maintenance performed within
the stated period/distance.
The service indicator will be reset by your Sprinter
Dealer after an oil service and/or maintenance service
has been performed.
REGULA R CHECK-UPSTo maintain the safe operation of your vehicle, it is
recommended that you perform the following tasks on
a regular basis (i.e., weekly or whenever the vehicle is
refueled). Check:
Engine oil level
Brake system, clutch mechanism – fluid level
Battery – acid level
Windshield washer system and headlamp cleaning
system – fluid level
Mechanical assemblies (e. g. ,engine, transmission,
etc.) – check for leaks
Condition of tires and tire pressures
All exterior lights
Freightliner-all.book Pag e 250 Monday, December 1, 2003 2:54 PM
Page 253 of 272
MAINTENANCE SCHEDULES 253
8M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
Check fluid levels for the following systems, correct
as necessary.
Should there be a loss of fluid which cannot be
explained by regular use, trace and eliminate
the cause.
Engine cooling system
Check corrosion inhibitor/antifreeze,
refill as necessary.
Hydraulic brake system
Battery
Windscreen washer system
Engine
Fuel filter renewal
Air cleaner with maintenance indicator:
Check degree of contamination.
Air cleaner filter element renewed as
necessary.Chassis and body
Trailer coupling:
Check operation, play and retaining fixtures
Secondary rubber springs:
Visual check
Tire pressures:
Correct as necessary, including spare tyre
Check thickness of brake pads
Brake test
Check condition of brake disks. Brake disks renewal as
necessary
– as a separate order
Check condition of steering mechanism
Heating/ventilation dust filter renewal
Freightliner-all.book Pag e 253 Monday, December 1, 2003 2:54 PM
Page 262 of 272
262 INDEXAnti-Lock Brake System (ABS) Indicator Lamp . . . 152
Appearance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 219
Armrest . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
Ashtray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76
ASSYST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 249
ASSYST Maintenance Computer . . . . . . . . . . . . . . . 103
Automatic Lock Feature . . . . . . . . . . . . . . . . . . . . . . . . 15
Automatic Transmission . . . . . . . . . . . . . . . . . . . . . . 139
Accelerator Position . . . . . . . . . . . . . . . . . . . . . . . . 140
Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 139
Maneuvering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
Selector Lever Manually Unlocking. . . . . . . . . . . 144
Selector Lever Position . . . . . . . . . . . . . . . . . . . . . . 141
Stopping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
Auxiliary Heat Exchanger . . . . . . . . . . . . . . . . . . . . . 129
Auxiliary Heater
Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 129
Timer Auxiliary Heater (Water and
Air Heater) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Tips for Coping with Problems . . . . . . . . . . . . . . 130Batteries . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 216
Charging the Battery . . . . . . . . . . . . . . . . . . . . . . . 217
Disconnecting the Battery . . . . . . . . . . . . . . . . . . . 216
Reconnecting the Battery . . . . . . . . . . . . . . . . . . . . 217
Replacing Batteries in Remote Keyless Entry . . . . 18
Battery Charge Indicator Lamp . . . . . . . . . . . . . . . . . . 95
Belt Tensioners . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Bleeding the Diesel Fuel System . . . . . . . . . . . . . . . . 176
Body Builder Guideline . . . . . . . . . . . . . . . . . . . . . . . 183
Brake Assist System (BAS) . . . . . . . . . . . . . . . . . . . . . 160
Brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212
Brake Fluid Reservoir . . . . . . . . . . . . . . . . . . . . . . . . . 211
Brake Indicator Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 148
Brake Pad Wear Indicator. . . . . . . . . . . . . . . . . . . . . . 147
Brake System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 155
Fluid Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 211
Brake System, Anti-Lock . . . . . . . . . . . . . . . . . . . . . . 153
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Brake Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212Freightliner-all.book Pag e 262 Monday, December 1, 2003 2:54 PM
Page 263 of 272
INDEX 263
10
Service Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Bulbs
Bulb Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . 233
Front Lamp Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . 233
CCapacities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 244
Care of Vehicle
Engine Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Headlamps, Taillamps, Turn Signal Lenses . . . . 222
Vehicle Washing . . . . . . . . . . . . . . . . . . . . . . . . . . . 222
Care of vehicle
Paintwork, painted body components . . . . . . . . 221
Power washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 220
Tar stains . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Catalytic Converter . . . . . . . . . . . . . . . . . . . . . . . . . . . 183
Central Locking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Locking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Central Locking Switch. . . . . . . . . . . . . . . . . . . . . . . . . 13
Locking and Unlocking . . . . . . . . . . . . . . . . . . . . . . 15
Locking Status Display . . . . . . . . . . . . . . . . . . . . . . 14To Program the Automatic Lock Feature . . . . . . . 15
Chains, Snow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 170
Changing a Bulb
Additional Brake Lamp . . . . . . . . . . . . . . . . . . . . . 240
Exit Lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 243
Front Lamp Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . 233
Interior Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . 242
Interior Lighting with Interior Sensor
Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 243
License Plate Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 240
Reading Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 242
Side-Marker Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 241
Side-Mounted Turn Signal . . . . . . . . . . . . . . . . . . 241
Taillamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 238
Changing the Tire . . . . . . . . . . . . . . . . . . . . . . . . . . . . 187
Charging the Battery . . . . . . . . . . . . . . . . . . . . . . . . . . 217
Checking Coolant Level . . . . . . . . . . . . . . . . . . . . . . . 213
Checking Weights of Vehicle and Trailer. . . . . . . . . 179
Cigar Lighter. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76Freightliner-all.book Pag e 263 Monday, December 1, 2003 2:54 PM
Page 266 of 272
266 INDEX
Fuel Tank Capacity . . . . . . . . . . . . . . . . . . . . . . . . . 173
Refueling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 172
Fuse and Relay Optional Equipment . . . . . . . . . . . . 230
Fuse, Relay, and Diode Assignments - Optional
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 230
Fuses, Electrical . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 225
GGlove Compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
Lockable Glove Compartment . . . . . . . . . . . . . . . . 79HHazard Warning Flasher Switch . . . . . . . . . . . . . . . . 186
Head Restraint . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
Headlamp Range Control. . . . . . . . . . . . . . . . . . . . . . . 62
Headlamps, taillamps, turn signal lenses . . . . . . . . 222
Heated Rear Window . . . . . . . . . . . . . . . . . . . . . . . . . 114
Heater, Seat. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 109, 111
Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
How to Use this Manual . . . . . . . . . . . . . . . . . . . . . . . . . 4
Hydroplaning. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 165Ignition
Lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Starter Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Immobilizer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Indicator Lamp Symbols . . . . . . . . . . . . . . . . . . . . . . . . 99
Inhalation of Exhaust Gas. . . . . . . . . . . . . . . . . . . . . . . 48
Installing a Wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 196
Instrument and Display Lighting . . . . . . . . . . . . . . . . 90
Instrument Cluster
Battery Charge Indicator Lamp . . . . . . . . . . . . . . . 95
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Coolant Level Indicator Lamp . . . . . . . . . . . . . . . . 98
Coolant Temperature Gauge . . . . . . . . . . . . . . . . . . 93
Engine Control Unit Indicator Lamp . . . . . . . . . . . 99
Engine Oil Level Indicator Lamp . . . . . . . . . . . . . . 97
Tachometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
Trip Meter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90
Water in Fuel Indicator Lamp . . . . . . . . . . . . . . . . . 96
Instrument Cluster and Indicator Lamps. . . . . . . . . . 85
Instruments and Controls . . . . . . . . . . . . . . . . . . . . . . . 83Freightliner-all.book Pag e 266 Monday, December 1, 2003 2:54 PM
Page 267 of 272
INDEX 267
10
Interior Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Cargo Area . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Driver and Rear-Seat Passenger/Cargo Area . . . 63
Interior Sensor Protection . . . . . . . . . . . . . . . . . . . . 63
Reading Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
Intervals, Maintenance . . . . . . . . . . . . . . . . . . . . . . . . 249
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Intrument Cluster
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94JJack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 192
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Jump Starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 198LLamps
Acceleration Skid Control . . . . . . . . . . . . . . . . . . . 155
Acceleration Skid Control Warning Lamp . 137, 157
Additional Brake Lamp . . . . . . . . . . . . . . . . . . . . . 240
Anti-Lock Brake System (ABS) Indicator Lamp. 152
Battery Charge Indicator Lamp . . . . . . . . . . . . . . . 95
Brake Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 148Brake System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 155
Coolant Level Indicator Lamp . . . . . . . . . . . . . . . . 98
Electronic Brake Force Distribution . . . . . . . . . . . 148
Engine Control Unit Indicator Lamp . . . . . . . . . . . 99
Engine Oil Level . . . . . . . . . . . . . . . . . . . . . . . . . . . 108
Engine Oil Level Indicator Lamp . . . . . . . . . . . . . . 97
Exit Lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 243
Indicator Lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
License Plate Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 240
Reading Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 242
Reserve Fuel Indicator Lamp . . . . . . . . . . . . . . . . . 94
Seat Belt Warning Lamp . . . . . . . . . . . . . . . . . . . . . 38
Side-Marker Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 241
SRS Malfunction Indicator Lamp . . . . . . . . . . . . . . 40
Taillamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 238
Water in Fuel Indicator Lamp . . . . . . . . . . . . . . . . . 96
Lifting Points . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Lighter, Cigar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76
Lighting, Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Loading . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 144Freightliner-all.book Pag e 267 Monday, December 1, 2003 2:54 PM