manual transmission DODGE SPRINTER 2005 1.G Owners Manual

90 UNDERSTANDING YOUR INSTRUMENT PANELLegend For Instruments And Controls
1. Left-hand air vent.
2. Multifunction switch.
3. Speed control .
4. Hood release lever .
5. Instrument cluster, refer to "Instrument Cluster and Indicator Lamps".
6. Hazard warning flasher switch .
7. Steering wheel with horn, front driver airbag .
8. Fuse box .
9. Windshield wiper switch, refer to "Windshield Wiper Switch".
10. Ignition lock/starter switch .
11. Center air vents .
12. Upper air vents .
13. Radio, see individual manual. 14. Temperature control switch
.
15. Airflow control switch .
16. Air distribution switch .
17. Temperature sensor, automatic heating control / air conditioning, regulated .
18. Air conditioning switch .
19. Heater booster switch .
20. Residual engine heat utilization switch .
21. Gear selector lever (automatic transmission)
22. Timer for auxiliary heater .
23. Electrical outlet .
24. Ashtray .
25. Cup holder .
26. Front passenger airbag .
27. Right-hand air vent .
28. Glove compartment .
NOTE: For layout of switches, see previous page.

STARTING AND OPERATING
5
CONTENTS

Power Assistance . . . . . . . . . . . . . . . . . . . . . . . . . . 141


Starting the Engine . . . . . . . . . . . . . . . . . . . . . . . . . 141
Maximum Engine Speed . . . . . . . . . . . . . . . . . . 142
Constant RPMs (Optional) . . . . . . . . . . . . . . . . 143


Stopping the Engine . . . . . . . . . . . . . . . . . . . . . . . . 144


Automatic Transmission . . . . . . . . . . . . . . . . . . . . 145
Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 145
Accelerator Position . . . . . . . . . . . . . . . . . . . . . . 146
Stopping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Maneuvering . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Gear Selector Lever Position . . . . . . . . . . . . . . . 147
Gear Selection for Special Circumstances . . . . 148


Transmission Selector Lever, Manually
Unlocking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 150
Reversing Aid (Optional) . . . . . . . . . . . . . . . . . 150


Loading the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . 153
Loading Guidelines . . . . . . . . . . . . . . . . . . . . . . 154


Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 155
Service Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . 155
Brake Pad Wear Indicator . . . . . . . . . . . . . . . . . 156
Brake Indicator and Electronic Brake Force
Distribution (EBD) Indicator Lamp . . . . . . . . . 157
Parking Brake Indicator Lamp . . . . . . . . . . . . . 158
Parking Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . 159
Driving Safety Systems . . . . . . . . . . . . . . . . . . . 160
Anti-Lock Brake System (ABS) Indicator
Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 161
Anti-Lock Brake System (ABS) . . . . . . . . . . . . . 162
Electronic Brake Force Distribution (EBD) . . . 164
Acceleration Skid Control Indicator Lamp
(ASR) and Brake Assist System (BAS)
1
if equipped . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 164

Acceleration Skid Control (ASR) Warning
Lamp and Electronic Stability Program
(ESP)
1 – if equipped . . . . . . . . . . . . . . . . . . . . . 166

Acceleration Skid Control (ASR) . . . . . . . . . . . 167

STARTING AND OPERATING 147
5
Gear Selector Lever PositionThe current gear selector lever position (1) is indicated
in the gear range indicator display. The automatic gear
shifting process can be adap ted to specific operating
conditions using the gear selector lever.
v
Park Position
The park position is to be used when parking the
vehicle. Engage only with the vehicle stopped.
The park position is not intended to serve as a
brake when the vehicle is parked. Rather, the
driver should always use the parking brake in
addition to placing the gear selector lever in
park position to secure the vehicle.
NOTE: With a malfunction in the vehicle’s electrical
system the gear selector lever could remain locked in
position "P". To unlock the gear selector lever
manually, refer to "Transmission Gear Selector Lever,
Manually Unlocking".
t Reverse Gear
Shift to reverse gear only with the vehicle
stopped.
s Neutral
No power is transmitted from the engine to the
drive axle. When the brakes are released, the
vehicle can be moved freely (pushed or towed).
Do not engage "N" while driving as you may
otherwise lose control of the vehicle.

150 STARTING AND OPERATINGTRANSMISSION SELECTOR LEVER, MANUALLY
UNLOCKINGIn the case of power failure the transmission selector
lever can be manually unlocked (for vehicle towing).
To do so, insert a pin (1) (ball point pen), into the
covered opening below the po sition "D" of the shift
pattern. While pushing the pin down, move selector
lever from position "P".
After removal of the pin from the opening, the cover
will not close fully. Only after moving the selector lever
to positions "D+" and "D–" do es the cover return to its
closed position.
Reversing Aid (Optional)1. Reversing aid sensors
The reversing aid monitors the rear area of the vehicle
by means of four sensors in the rear bumper.
The reversing aid automatically provides you with a
visual and audible indication of the distance between
your vehicle and an obstacle, when the key is in
position 2 in the ignition lock and the reverse gear is
engaged.
1
1
N54.65-2043-20

190 STARTING AND OPERATING
WARNING!
Take into consideration that when towing a trail-
er, the handling characteristics are different and
less stable from those when operating the vehicle
without a trailer.
It is important to avoid sudden maneuvers.
Sudden maneuvers may lead to loss of control
over the vehicle-trailer combination. This could
cause an accident resulting in property damage or
injury to you or others.
CAUTION!
If the transmission hunts between gears on
inclines, manually shift to a lower gear (select
"4",
"3", "2" or
"1"). A lower gear and reduction of
speed reduces the chance of engine overloading
and / or overheating.
When going down a long hill, shift into a lower
gear and use the engine’s braking effect. Avoid
riding the brakes, thus overheating the vehicle
and trailer brakes.
If the engine coolant rises to an extremely high
temperature (coolant temperature needle
approaching the red zone) when the air
conditioner is on, turn off the air conditioner.
Engine coolant heat can be additionally vented by
opening the windows, switching the climate
control fan speed to high and setting the
temperature control to the maximum hot position.

278 INDEXASSYST Maintenance Computer . . . . . . . . . . . . . . . 110
Automatic Lock Feature . . . . . . . . . . . . . . . . . . . . . . . . 19
Automatic Transmission . . . . . . . . . . . . . . . . . . . . . . 145Accelerator Position . . . . . . . . . . . . . . . . . . . . . . . . 146
Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 145
Gear Selector Lever Position . . . . . . . . . . . . . . . . . 147
Maneuvering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Selector Lever Manually Unlocking. . . . . . . . . . . 150
Stopping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Auxiliary Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 172
Auxiliary Heat Exchanger . . . . . . . . . . . . . . . . . . . . . 137
Auxiliary Heater Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 136
Timer Auxiliary Heater (Water and Air Heater) 132
Tips for Coping with Problems . . . . . . . . . . . . . . 138BBatteries. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 227Charging the Battery . . . . . . . . . . . . . . . . . . . . . . . 228
Disconnecting the Battery . . . . . . . . . . . . . . . . . . . 227
Reconnecting the Battery . . . . . . . . . . . . . . . . . . . . 228
Replacing Batteries in Remote Keyless Entry . . . . 22
Battery Charge Indicator Lamp . . . . . . . . . . . . . . . . . 104 Belt Tensioners
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
Belt Tensioners and Airbag . . . . . . . . . . . . . . . . . . . . . 49
Bleeding the Diesel Fuel System . . . . . . . . . . . . . . . . 185
Body Builder Guideline . . . . . . . . . . . . . . . . . . . . . . . 193
Brake Assist System (BAS) . . . . . . . . . . . . . . . . . . . . . 169
Brake fluid. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 223
Brake Fluid Reservoir . . . . . . . . . . . . . . . . . . . . . . . . . 222
Brake Indicator Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 157
Brake Pad Wear Indicator. . . . . . . . . . . . . . . . . . . . . . 156
Brake System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 164 Fluid Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 222
Brake System, Anti-Lock . . . . . . . . . . . . . . . . . . . . . . 162
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 155 Brake Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 223
Service Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 155
Bulbs Bulb Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . 245
Front Lamp Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . 245
CCapacities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 257
Care of Vehicle