door lock DODGE SPRINTER 2006 1.G Owner's Guide

STARTING AND OPERATING 163
5
Driving Safety Systems
The vehicle can be equipped with the following
Driving Safety Systems:
 Anti-lock brake system (ABS)
 Electronic brake force distribution (EBV)
 Acceleration skid control (ASR)
 Brake assist system (BAS)
1
 Electronic stability program (ESP®)*
NOTE: The maximum effectiveness of ABS, EBV, ASR
and ESP®* is only achieved if you drive with correct
tire pressures and adjust tire pressures to correspond
with the vehicle’s load. In winter operation, the
maximum effectiveness of the ABS and the ESP
®* is
only achieved with winter tires (M+S tires), or snow
chains as required.
*Vehicle type 2500 only
WARNING!
When leaving the vehicle always remove the key
from the ignition lock, and lock your vehicle.
Do not leave children unsupervised in the vehicle,
even if they are secured by a child restraint
system. The children could
 injure themselves on parts of the vehicle
 release the child-proof locks by pressing the
central locking button and could thereby open
the doors and
 cause injury to others as a result
 get out of the vehicle and could either injure
themselves when doing so or they could be
injured by the traffic approaching from the rear
 suffer serious or fatal effects in the event of long
periods of hot weather
 release the parking brake. The vehicle could
then start moving of its own accord.
Unsupervised use of vehicle equipment may cause
severe personal injuries, death and property damage.

212 STARTING AND OPERATING
REFUELING
1. Fuel filler neck
2. Fuel filler cap
The fuel filler neck (1) is located behind the fuel filler flap
next to the driver’s door. The fuel filler flap can be opened
when the driver’s door is open. Turn the fuel filler cap (2)
on the fuel filler neck (1) counterclockwise and take it off.
For cargo/passenger vans, place the fuel filler cap (2) in
the holder on the inside of the fuel filler flap.
When you have finished refueling, install the fuel filler
cap (2).NOTE: Only fill the fuel tank until the fill nozzle cuts
off, do not overfill.
NOTE: Holder on the inside of the fuel filler flap only
for cargo/passenger vans.
WARNING!
Always handle fuel with great care.
Shut off the engine and the auxiliary heater before
refueling.
Fuel is flammable and explosive. Keep open
flames away from the fuel.
Refrain from smoking as well as use of any
electrical equipment (such as cell phones). This
also applies to places where the characteristic
smell of fuel is evident.
If diesel fumes are noticed inside the vehicle, have
the cause traced and rectified immediately by an
authorized Sprinter Dealer.

216 STARTING AND OPERATING
Bleeding the Diesel Fuel System
The diesel fuel system must be bled before starting the
engine.
 Turn the key in the ignition lock position 2 for at
least 30 seconds.
 Return the key to position 0.
 Start the engine three to four times. The engine
control unit indicator lamp± must go out.
NOTE: Too many attempts to start the engine could
drain the battery. If the engine does not start after
several attempts, consult an authorized Sprinter
Dealer.PERMISSIBLE ROOF LOAD
The maximum permissible roof load is:
 Vehicles with low roof 660 lbs (300 kg)
 Vehicles with high roof 330 lbs (150 kg)
 The weight of any load carried on the roof,
including the roof rack, must not exceed the
maximum permissible roof load.
LOADING THE VEHICLE
Two labels on the vehicle show how much weight it
may properly carry.
 The Tire and Loading Information placard can be
found on the driver’s door B-pillar. This placard
tells you important information about the number
of people that can be in the vehicle and the total
weight that can be carried in the vehicle. It also
contains information on the proper size and
recommended tire inflation pressures for the
original equipment tires on the vehicle.
 The Certification Label can be found below the
driver’s seat on an outward facing position of the
mounting pillar. It tells you about the gross weight

320 INDEX
Climate Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
Comfortseat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Comfortseat (Optional) . . . . . . . . . . . . . . . . . . . . . . . . . 61
Compartments in Front Doors. . . . . . . . . . . . . . . . . . . 87
Constant RPMs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Consumer Assistance
Be Reasonable with Request . . . . . . . . . . . . . . . . . 312
If You Need Assistance . . . . . . . . . . . . . . . . . . . . . 312
Prepare a List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 312
Prepare for the Appointment . . . . . . . . . . . . . . . . 312
Coolant Level Indicator Lamp . . . . . . . . . . . . . . . . . . 108
Coolant Temperature Gauge . . . . . . . . . . . . . . . . . . . 103
Coolant, Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 262
Cooling System, Engine . . . . . . . . . . . . . . . . . . . . . . . 261
Corrosion Protection . . . . . . . . . . . . . . . . . . . . . . . . . . 269
Cup Holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
DDe-Fogging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 121
Dehumidification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 126
De-Icing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 121
Diesel Fuels for Use at Very Low Temperatures . . 211Direction of Rotation . . . . . . . . . . . . . . . . . . . . . . . . . . 182
Displaying Engine Oil Level . . . . . . . . . . . . . . . . . . . 115
Doors
Front Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Rear Cargo Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Sliding Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Draining Fuel Filter with Water Separator . . . . . . . 214
Driver’s Airbag. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Driving Safety Systems . . . . . . . . . . . . . . . . . . . . . . . . 163
EElectric Sun Roof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Electrical Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 276
Fuse and Relay Optional Equipment . . . . . . . . . . 281
Fuse, Relay, and Diode Assignments - Optional
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 282
Relay Assignment, Standard Equipment . . . . . . 281
Standard Fuse and Relay Equipment. . . . . . . . . . 277
Electrical Outlet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Electronic Brake Force Distribution . . . . . . . . . . . . . 167
Electronic Brake Force Distribution Lamp . . . . . . . . 160
Electronic Stability Program . . . . . . . . . . . . . . . . . . . 169
Emission Label, Vehicle/Engine . . . . . . . . . . . . . . . . . . 8

INDEX 325
10
Radio Transmitters . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Rear Cargo Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Rear Seat Bench . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
Removal and Installation . . . . . . . . . . . . . . . . . . . . . 64
Recommended Fluids and Lubricants . . . . . . . . . . . 297
Recommended Tire Inflation Pressure . . . . . . . . . . . 186
Refueling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212
Regular Checks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 256
Relay Assignment, Standard Equipment . . . . . . . . . 281
Remote Keyless Entry . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Locking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Replacing Batteries . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Unlocking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Removing a Wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . 242
Replacing Wiper Blades . . . . . . . . . . . . . . . . . . . . . . . 268
Reporting safety Defects . . . . . . . . . . . . . . . . . . . . . . . 315
Reserve Fuel Indicator Lamp . . . . . . . . . . . . . . . . . . . 105
Residual Engine Heat Utilization . . . . . . . . . . . . . . . 124
Residual Engine Heat Utilization (REST) . . . . . . . . 124
Restraints, Occupant . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
Retrofitting Seat Mounting Cups . . . . . . . . . . . . . . . . 65Reversing Aid
Audible Warning . . . . . . . . . . . . . . . . . . . . . . . . . . 102
Ribbed V-Belt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 260
Roof Load . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 216
Rotating Tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 204
RPMs, Constant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
SSafety Tips. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
Seat Belt Warning Lamp and Airbag Malfunction . . 44
Seat Belts
Belt Tensioners . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
Fastening and Removing . . . . . . . . . . . . . . . . . . . . . 45
Height Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Seat Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Seats
Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
Armrest . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
Driver’s and Front Passenger’s Seat . . . . . . . . . . . . 60
Folding Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Head Restraint . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Lumbar Support . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61