radiator DODGE STRATUS 2005 2.G User Guide

Disposal Of Used Engine Coolant
Used ethylene glycol based engine coolant is a regulated
substance requiring proper disposal. Check with your
local authorities to determine the disposal rules for your
community. Do not store ethylene glycol based engine
coolant in open containers or allow it to remain in
puddles on the ground. Prevent ingestion by animals or
children. If ingested by a child, contact a physician
immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine off and cold, the coolant level should be between
the“MIN”and“MAX”marks on the side of the coolant
bottle. Some darkening of the coolant bottle will occur
over time. This is normal. If the coolant level is hard to
see, jostling the coolant bottle will make it easier to see.
There is no need to remove the radiator cap unless
checking for coolant freeze point, adding, or replacing
coolant. Advise your service attendant of this. As long as
the engine operating temperature is satisfactory, thecoolant bottle need only be checked once a month. Heater
performance may also be adversely affected by low
coolant levels.
When additional coolant is needed to maintain the
proper level, it should be added to the coolant bottle. Do
not overfill. Special procedures are required when filling
the engine cooling system of the 2.7L Engine. See your
authorized dealer for details.
Points to Remember
NOTE:
When the vehicle is stopped after a few miles of
operation, you may observe vapor coming from the front
of the engine compartment. This is normally a result of
moisture from rain, snow, or high humidity accumulat-
ing on the radiator and being vaporized when the
thermostat opens, allowing hot water to enter the radia-
tor.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant bottle.
224 MAINTAINING YOUR VEHICLE

•Check coolant freeze point in the system.
•If frequent coolant additions are required, or if the
level in the bottle does not drop when the engine cools,
the cooling system should be pressure tested for leaks.
•Maintain coolant concentration at 50% HOAT ethylene
glycol engine coolant (minimum) and distilled water
for proper corrosion protection of your engine which
contains aluminum components.
•Make sure that the radiator and coolant bottle hoses
are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle has
air conditioning, keep the front of the condenser clean,
also.
•Do not change the thermostat for summer or winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory cooling performance, poor gas
mileage, and increased emissions.
Hoses and Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, checking, tears, cuts, abrasions,
and excessive swelling indicate deterioration of the rub-
ber.
Pay particular attention to those hoses nearest to high
heat sources such as the exhaust manifold. Inspect hose
routing to be sure hoses do not touch any heat source or
moving component that may cause heat damage or
mechanical wear.
Insure nylon tubing in these areas has not melted or
collapsed. Inspect all hose connections such as clamps
and couplings to make sure they are secure and no leaks
are present. Components should be replaced immedi-
ately if there is any evidence of degradation that could
cause failure.
Brakes
In order to assure brake system performance, all brake
system components should be inspected periodically.
Suggested service intervals can be found in section 8.
MAINTAINING YOUR VEHICLE 225
7

Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
NOTE:Under no circumstances should oil change
intervals exceed 6 months or 6,000 miles, whichever
comes first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
•
Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•
Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, and transaxle and add as needed.
•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
250 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Special Additives..................... 230
Autostick............................. 172
Auxiliary Power Outlet................... 81
Ball Joints............................ 216
Battery............................... 213
Emergency Starting.................... 193
Gas Caution......................195,214
Heater............................. 145
Jump Starting........................ 193
Keyless Transmitter Replacement.......... 22
Location.........................193,213
Belts, Drive........................... 210
Belts, Engine.......................... 212
Body Mechanism Lubrication.............. 216
B-Pillar Location....................... 159
Brake, Parking......................... 150
Brake System.......................151,225
Anti-Lock........................... 152
Fluid Check......................... 227
Hoses.............................. 226
Master Cylinder...................... 227
Warning Light........................ 93Brake/Transmission Interlock...........145,148
Break-In Recommendations, New Vehicle...... 48
Bulb Replacement...................... 238
Bulbs, Light........................... 238
Capacities, Antifreeze (Engine Coolant)...... 244
Capacities, Fluid....................... 244
Caps, Filler
Fuel............................... 176
Oil (Engine)......................... 209
Radiator (Coolant Pressure).............. 223
Car Washes........................... 231
Carbon Monoxide Warning............... 176
Carpeting............................. 232
Cassette Tape and Player Maintenance....... 123
Cassette Tape Player...............100,108,111
Catalytic Converter..................... 211
CD Changer..................107,112,117,119
CD Player....................105,113,115,123
Center High Mounted Stop Light........... 242
Central Locking......................... 17
Chains, Tire........................... 170
Changing A Flat Tire.................... 188
INDEX 281
10

Charging System Light................... 90
Chart, Tire Sizing....................... 156
Check Engine Light
(Malfunction Indicator Light).............. 204
Checking Your Vehicle For Safety............ 49
Child Restraint...................41,43,45,46
Child Restraint Tether Anchors............. 45
Child Safety Locks....................... 18
Cigar Lighter........................... 98
Circuit Breakers........................ 235
Clean Air Gasoline...................... 174
Cleaning
Glass.............................. 233
Headlights.......................... 233
Instrument Panel..................... 234
WoodTrim .......................... 234
Climate Control........................ 125
Clock................................. 98
Coin Holder........................... 54
Compact Disc Changer................... 119
Compact Disc Maintenance............... 124
Compact Disc Player.................100,105
Compact Spare Tire..................... 166Compass.............................. 95
Compass Calibration..................... 96
Contract, Service....................... 272
Coolant Pressure Cap.................... 223
Cooling System........................ 220
Adding Coolant (Antifreeze)............. 223
Coolant Capacity..................... 244
Coolant Level.....................221,224
Disposal of Used Coolant............... 224
Drain, Flush, and Refill................. 221
Inspection........................220,221
Points to Remember................... 224
Pressure Cap........................ 223
Radiator Cap........................ 223
Rubber and Plastic Components.......... 225
Selection of Coolant.............222,244,245
Corrosion Protection.................... 230
Crankcase Emission Control System......... 213
Cruise Control (Speed Control)............. 71
Cruise Light........................... 89
Customer Assistance.................... 270
Daytime Brightness, Interior Lights.......... 64
282 INDEX

Partial Zero Emissions Vehicle for 2.4 Liter.... 248
Passing Light........................... 67
Pets.................................. 48
Placard, Tire and Loading Information....... 159
Power
Brakes............................. 151
Door Locks.......................... 16
Outlet.............................. 81
Seats............................... 60
Steering............................ 153
Steering, Checking.................... 215
Sunroof............................. 79
Windows.........................25,153
Power Steering Fluid.................... 246
Pregnant Women and Seat Belts............. 33
Preparation for Jacking................... 188
Pretensioners
Seat Belts............................ 31
Programmable Electronic Features.........74,78
Programming Transmitters............21,74,78
Radial Ply Tires........................ 166
Radiator Cap (Coolant Pressure Cap)........ 223Radio Broadcast Signals................... 99
Radio Operation...............108,113,122,125
Radio Remote Controls.................. 122
Radio (Sound Systems).............100,108,113
Rear Seat, Folding....................... 61
Rear Window Defroster.................. 135
Rearview Mirrors........................ 56
Recommended Fluids, Lubricants and Genuine
Parts............................... 245
Reformulated Gasoline................... 174
Refrigerant............................ 215
Reminder, Lights On..................... 67
Reminder, Seat Belt...................... 32
Remote Keyless Entry.................... 19
Remote Sound System Controls............ 122
Remote Trunk Release.................... 24
Replacement Tires...................... 169
Reporting Safety Defects................. 274
Restraint, Head......................... 61
Restraints, Occupant..................... 26
Rocking Vehicle When Stuck.............. 197
Rotation, Tires......................... 171
INDEX 289
10