maintenance schedule DODGE VIPER 2004 ZB / 2.G User Guide

MAINTENANCE SCHEDULES
CONTENTS
mEmission Control System Maintenance........200
mMaintenance Schedules...................200NSchedule ªBº........................203
NSchedule ªAº........................210
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

EMISSION CONTROL SYSTEM MAINTENANCE
The ªScheduledº maintenance services, listed inbold
typemust be done at the times or mileages specified to
assure the continued proper functioning of the emission
control system. These, and all other maintenance services
included in this manual, should be done to provide best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions such as dusty areas and very short trip
driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the emis-
sion control devices and systems on your vehicle may be
performed by any automotive repair establishment or
individual using any automotive part which has been
certified pursuant to U.S. EPA or, in the State of Califor-
nia, California Air Resources Board regulations.
MAINTENANCE SCHEDULES
There are two maintenance schedules that show the
requiredservice for your vehicle.
First is ScheduleªBº. It is for vehicles that are operated
under the conditions that are listed below and at the
beginning of the schedule.
²Day or night temperatures are below 32É F (0É C).
²Stop and go driving.
²Extensive engine idling.
²Driving in dusty conditions.
²Short trips of less than 10 miles (16 km).
²More than 50% of your driving is at sustained high
speeds during hot weather, above 90É F ( 32É C).
²Trailer towing.L
200 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

²Taxi, police, or delivery service (commercial ser-
vice).L
²Off-road or desert operation.
²If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:Most vehicles are operated under the conditions
listed for Schedule9B9.
Second is ScheduleªAº. It is for vehicles that are not
operated under any of the conditions listed under Sched-
ule9B9.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
²Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
²Check the windshield washer solvent and add if
required.
MAINTENANCE SCHEDULES 201
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Once a Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the battery and clean and tighten the terminals
as required.
²Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
²Check all lights and all other electrical items for correct
operation.At Each Oil Change
²Change the engine oil filter.
²Inspect the exhaust system.
²Inspect the brake hoses.
²Inspect the suspension components.
²Lubricate door hinges and check springs.
²Check the engine coolant level, hoses, and clamps.
²Check power steering fluid level.
²Rotate the tires at each oil change interval shown on
Schedule ªAº 6,000 miles (10 000 km) or every other
interval shown on Schedule ªBº 6,000 miles (10 000
km).
202 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 93,000 96,000 99,000 102,000 105,000
(Kilometers) (149 000) (154 000) (158 000) (163 000) (168 000)
Change engine oil and engine oil filter.XXXXX
Inspect the brake linings. X
Change the rear axle fluid. X
Inspect and replace, if necessary, theengine air
cleaner filter.X
Lubricate the front and rear suspension ball joints. X
Change the transmission fluid.X
Inspect and replace the Auto Tension Drive Belt as
needed. Not required if the belt was previously re-
placed.X
Flush and replace engine coolant. X
* This maintenance is recommended by DaimlerChrysler
Corporation to the owner but is not required to maintain
the warranty on the PCV orifice.
³ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE ªBº 209
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

* This maintenance is recommended by DaimlerChrysler
Corporation to the owner but is not required to maintain
the warranty on the PCV orifice.
³ This maintenance is not required if previously replaced.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
SCHEDULE ªAº 213
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Light Bulbs............................ 186
Lights................................. 60
Airbag.............................41,79
Anti-Lock Warning...................... 75
Back-Up............................. 61
Brake Warning......................... 79
Daytime Running....................... 63
Dimmer Switch, Headlight................ 61
Exterior Check......................... 48
Fog .............................62,64,78
Hazard Warning Flasher...............75,132
Headlight Switch....................... 62
Headlights.........................62,188
High Beam Indicator.................... 77
Instrument Cluster...................... 62
Interior...........................61,186
Lights On Reminder..................... 63
Malfunction Indicator.................... 76
Map Reading.......................... 60Oil Pressure........................... 78
Passing.............................. 65
Reading.............................. 60
Seat Belt Reminder...................... 77
Turn Signal.......................61,64,75
Loading Vehicle
Capacities........................... 130
Tires ............................... 112
Locks
Door................................ 13
Low Tire Indicator....................... 124
Low Tire Pressure System.................. 124
Lower Anchors and Tether for CHildren (LATCH) . 35
Lubricants..........................162,163
Lubrication, Body....................... 162
Maintenance Schedule.................... 200
Light Duty Schedule9B9................. 203
Schedule9A9......................... 210
INDEX 231
10

Pets.................................. 46
Pets, Transporting........................ 46
Placard, Tire and Loading Information......... 112
Power
Accessory Delay......................13,24
Steering..........................107,161
Windows............................. 23
Pregnant Women and Seat Belts.............. 32
Programming Transmitters.................. 18
Radial Ply Tires......................... 120
Radiator Cap........................... 168
Radio................................. 82
Radio Antenna.......................... 90
Radio Operation......................... 90
Rear Axle............................. 176
Rear Wheel Bearings..................... 177
Reclining Front Seats...................... 57
Reformulated Gasoline.................... 127Refrigerant............................ 160
Reminder, Seat Belt.....................30,77
Remote Keyless Entry..................... 15
Replacement Tires....................... 122
Reporting Safety Defects................... 220
Restraints, Child......................... 33
Restraints, Infant......................... 33
Restraints, Occupant...................... 26
Rotation, Tires.......................... 126
Safety Checks Inside Vehicle................. 48
Safety Checks Outside Vehicle............... 48
Safety Defects, Reporting.................. 220
Safety Information, Tire................... 108
Safety Tips............................. 47
Schedule, Maintenance.................... 200
Scheduled Maintenance................... 148
Seat Belt Maintenance.................... 178
Seat Belt Reminder.....................30,77
INDEX 233
10