jump start DODGE VIPER 2004 ZB / 2.G Owners Manual
[x] Cancel search | Manufacturer: DODGE, Model Year: 2004, Model line: VIPER, Model: DODGE VIPER 2004 ZB / 2.GPages: 236, PDF Size: 4.18 MB
Page 99 of 236
WARNING!
Do not attempt to push or tow your vehicle to get it
started. Unburned fuel could enter the catalytic
converter and once the engine has started, ignite and
damage the converter and vehicle. If the vehicle has
a discharged battery, booster cables may be used to
obtain a start from a booster battery or the battery in
another vehicle. This type of start can be dangerous
if done improperly, so follow this procedure care-
fully. See section 6 of this manual for jump starting
instructions.
If the engine fails to start after you have followed the
ªNORMAL STARTINGº procedure, it may be flooded.
Push the accelerator pedal all the way to the floor and
hold it there while cranking the engine. This should clear
any excess fuel in case the engine is flooded.NOTE:To prevent damage to the starter, do not crank
the engine for more than 15 seconds at a time. Wait 10 to
15 seconds before trying again.
If the engine has been flooded, it may start to run, but not
have enough power to continue running when the start
button is released. If this occurs, continue cranking with
the accelerator pedal pushed all the way to the floor.
Release the accelerator pedal and the start button once
the engine is running smoothly.
If the engine shows no sign of starting after two 15
second periods of cranking with the accelerator pedal
held to the floor, the ªNORMAL STARTINGº procedure
should be repeated.
STARTING AND OPERATING 99
5
Page 131 of 236
WHAT TO DO IN EMERGENCIES
CONTENTS
mHazard Warning Flasher..................132
mIf Your Engine Overheats.................132
mJump-Starting Procedures.................134
mDriving On Slippery Surfaces..............137NTraction............................137
mFreeing A Stuck Vehicle..................138
mTowing A Disabled Vehicle................139
6
Page 134 of 236
JUMP-STARTING PROCEDURES
WARNING!
²Do not attempt to push or tow your vehicle to get
it started. Unburned fuel could enter the catalytic
converter and once the engine has started, ignite
and damage the converter and vehicle. If the
vehicle has a discharged battery, booster cables
may be used to obtain a start from a booster
battery or the battery in another vehicle. This type
of start can be dangerous if done improperly, so
follow this procedure carefully.
²Take care to avoid the radiator cooling fan and
accessory drive whenever the hood is raised. You
can be hurt by the moving components.
WARNING!
²Battery fluid is a corrosive acid solution; do not
allow battery fluid to contact eyes, skin or cloth-
ing. Don't lean over battery when attaching
clamps or allow the clamps to touch each other. If
acid splashes in eyes or on skin, flush contami-
nated area immediately with large quantities of
water.
²A battery generates hydrogen gas that is flam-
mable and explosive. Keep flame or spark away
from the top of the battery. Do not use a booster
battery or any other booster source with an output
that exceeds 12 volts.
134 WHAT TO DO IN EMERGENCIES
Page 135 of 236
The battery is located under the battery access panel
inside the trunk on the left side. Remote battery terminals
are located in the engine compartment for jump starting.1. Wear eye protection and remove any metal jewelry
such as watch bands or bracelets that might make an
inadvertent electrical contact.
2. When boost is provided by a battery in another
vehicle, park that vehicle within booster cable reach but
WHAT TO DO IN EMERGENCIES 135
6
Page 136 of 236
without letting the vehicles touch. Set the parking brake,
place the transmission in neutral and turn the ignition
OFF for both vehicles.
3. Turn off the heater, radio and all unnecessary electrical
loads.
4. If you are jump starting your Viper, connect one end of
a jumper cable to the positive terminal of the booster
battery. Connect the other end of the same cable to the
remote battery positive terminal after removing the plas-
tic cover.
5. If you are jump starting another vehicle, connect one
end of a jumper cable to the remote battery positive
terminal post on the Power Distribution Center. Connect
the other end of the same cable to the positive terminal of
the discharged battery after removing the plastic cover.6. Connect the other cable, first to the negative terminal
of the booster battery and then to the ground (on the ear
of the Thermostat Housing) of your Viper as shown.
Make sure you have a good contact.
7. If you are jump starting another vehicle, connect one
end of a jumper cable to the ground (on the ear of the
Thermostat Housing shown in illustration) of your Viper
136 WHAT TO DO IN EMERGENCIES
Page 228 of 236
Convertible Top......................... 178
Convertible Top Maintenance............... 178
Cooling System......................... 166
Adding Coolant (Antifreeze).............. 168
Coolant Capacity...................... 195
Coolant Level......................... 169
Disposal of Used Coolant................ 167
Drain, Flush, and Refill.................. 166
Inspection........................... 166
Points to Remember.................... 170
Pressure Cap......................... 168
Rubber and Plastic Components............ 170
Selection of Coolant.................... 167
Crankcase Emission Control System.......... 155
Customer Assistance..................... 216
Dealer Service.......................... 147
Defroster, Windshield...................... 48
Dimmer Switch, Headlight.................. 65Door Locks............................. 13
Door Locks, Automatic.................... 15
Doors................................. 13
Drive Belts............................ 152
Driving
On Slippery Surfaces.................... 137
Electric Remote Mirrors.................... 55
Emergency, In Case of
Hazard Warning Flasher................. 132
Jump Starting......................... 134
Overheating.......................... 132
Towing............................. 139
Emission Control System Maintenance......146,200
Engine
Break-In Recommendations................ 46
Cooling.............................. 78
Oil ..............................148,195
Oil Disposal.......................... 151
228 INDEX
Page 230 of 236
Hazard Warning Flasher.................75,132
Headlights............................ 188
Aiming............................. 193
High Beam........................... 65
High Beam/Low Beam Select Switch......... 65
Switch............................... 62
Time Delay........................... 63
Heater................................ 90
High Beam Indicator...................... 77
Hood Latch Maintenance.................. 163
Hood Release........................... 58
Hoses.............................170,171
Hydraulic Clutch Fluid.................... 175
Ignition
Key ................................. 11
Timing.............................. 154
Wiring System........................ 154
Infant Restraint.......................... 33Instrument Cluster........................ 74
Instrument Panel and Controls............... 73
Instrument Panel Lens Cleaning............. 178
Interior and Instrument Lights..........See Lights
Interior Lights........................... 61
Intermittent Wipers....................... 69
Introduction............................. 4
Jump Starting.......................... 134
Key-In Reminder......................... 12
Keyless Entry System...................... 15
Keys.................................. 11
Knee Bolster............................ 38
Lap/Shoulder Belts....................... 27
LATCH (Lower Anchors and Tether for CHildren) . 35
Latches
Hood............................... 163
230 INDEX
Page 234 of 236
Seat Belts.............................. 26
And Pregnant Women................... 32
Extender............................. 32
Inspection............................ 48
Operating Instructions................... 28
Reminder............................ 77
Seats................................. 57
Adjustment........................... 57
Reclining............................. 57
Selection of Oil......................... 150
Service Assistance....................... 216
Service Contract......................... 218
Service Manuals........................ 220
Setting the Clock......................... 81
Shift Indicator Light....................76,101
Shift Speeds.........................100,101
Side View Mirror Adjustment................ 56
Signals, Turn............................ 75
Six Point Belt System...................... 31Slippery Surfaces, Driving On............... 137
Snow Tires............................ 125
Spark Plugs............................ 152
Specifications........................... 196
Speedometer............................ 74
Starting............................... 97
Emergency (Jump Starting)............... 134
Engine Fails to Start..................... 98
Steering
Linkage............................. 163
Power...........................107,161
Tilt Column........................... 65
Storage............................... 183
Stuck, Freeing.......................... 138
Sulfur in Gasoline....................... 129
Supplemental Restraint System - Airbag........ 38
Tachometer............................. 80
Temperature Gauge, Engine Coolant........... 80
234 INDEX