lights DODGE VIPER 2005 ZB / 2.G Owner's Manual

High Intensity Discharge Headlights (HID)
The headlights are a type of high voltage discharge tube.
High voltage can remain in the circuit even with the
headlight switch off and the key removed.Because of
this, you should not attempt to service a headlight bulb
yourself. If a headlight bulb fails, take your vehicle to
an authorized dealer for service.
WARNING!
A transient high tension occurs at the bulb sockets of
High Intensity Discharge (HID) headlights when the
headlight switch is turned ON. It may cause serious
electrical shock or electrocution if not serviced prop-
erly. See your authorized dealer for service.
NOTE:If High Intensity Discharge (HID) lights are not
working, recycle the headlight switch 4 times to see if it
will restrike.
Tail, Tail/Stop, and Marker Lamp Bulb
Replacement
1. Open the trunk. Remove two access panel fasteners.
Remove the access panel.
MAINTAINING YOUR VEHICLE 207
7

Headlight Aiming
The headlights on your new Viper were aimed at the
factory. The factory setting was made at a no load setting.
A great increase in weight will change the aiming and it
may be necessary to readjust the headlights if you
typically carry an excessive amount of weight in the
trunk or otherwise suspect misalignment.
Aiming Check
Each headlight assembly can be adjusted up and down
only. No left to right adjustment is necessary. To check,
proceed as follows:
1. Fill the fuel tank and park the vehicle on level ground.
A driveway is not normally level. If in doubt and you
have no way to check levelness, do not attempt to adjust
the headlights.
2.
Mark the position of the headlights on a wall prior to
loading the vehicle. Load the trunk with the items you
normally carry. Have someone sit in the driver’s seat who is
about the same weight as the person who drives the vehicle.
3. Push down on the front and rear of the vehicle several
times to make sure that the suspension has settled.
4. Then readjust the headlights to the original position.
NOTE:If any further adjustments are necessary, contact
your dealership.
FLUIDS AND CAPACITIESU.S. Metric
Fuel (approximate)
8.3 Liter Engine (Premium 91
Octane)18 gal-
lons68 liters
Engine Oil-With Filter
8.3 Liter Engines (0W-40) 10 qts. 9.5 Liters
Cooling System *
8.3 Liter Engines* (Mopar
Antifreeze/Coolant 5 Year/
102,000 Mile Formula)16 qts. 15 Liters
* Includes heater and coolant recovery bottle filled to
MAX level.
212 MAINTAINING YOUR VEHICLE

At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
•Check all lights and all other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the suspension components.
•Lubricate door hinges and check springs.
•Check the engine coolant level, hoses, and clamps.
•Check power steering fluid level.
220 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

About Your Brakes....................... 117
ABS (Anti-Lock Brake) System............... 87
Accessory Delay, Power..................13,26
Adding Engine Coolant (Antifreeze).......... 185
Adding Fuel........................... 145
Adding Washer Fluid..................... 182
Additives, Fuel......................... 144
Adjustable Pedals........................ 79
Aiming Headlights....................... 212
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 171
Air Conditioner Maintenance............... 176
Air Conditioning.....................104,176
Air Conditioning Refrigerant............... 177
Air Pressure, Tires....................... 131
Airbag................................ 41
Airbag Deployment....................... 45
Airbag Light..........................44,91
Airbag Maintenance....................... 49
Airbag On/Off Switch...................35,46Alarm System........................... 20
Alignment and Balance................... 138
Alterations/Modifications, Vehicle............. 7
Antenna.............................. 103
Antifreeze (Engine Coolant)...........184,185,212
Capacities........................... 212
Disposal............................ 186
Anti-Lock Warning Light................... 87
Anti-Theft Security Alarm.................. 20
Appearance Care........................ 194
Auto Down Power Windows................ 26
Automatic Door Locks..................... 15
Automatic Transmission
Adding Fluid......................... 214
Fluid Type........................... 214
Ball Joints............................. 179
Battery.............................90,171
Emergency Starting..................... 150
244 INDEX

Charging System Light..................... 90
Chart, Tire Sizing........................ 123
Check Engine Light (Malfunction Indicator Light) . 162
Checks, Safety........................... 51
Child Restraint........................34,39
Child Restraint Tether Anchors............... 37
Circuit Breakers......................... 197
Clean Air Gasoline....................... 142
Climate Control......................... 104
Clock................................. 93
Compact Disc Maintenance................. 103
Compact Spare Tire...................... 134
Console............................... 66
Console, Floor........................... 66
Contract, Service........................ 236
Converter, Catalytic...................... 168
Convertible............................. 55
Convertible Boot.......................59,64
Convertible Top.......................55,196Convertible Top Maintenance............... 196
Coolant Pressure Cap..................... 185
Cooling System......................... 183
Adding Coolant (Antifreeze).............. 185
Coolant Capacity...................... 212
Coolant Level......................183,187
Disposal of Used Coolant................ 186
Drain, Flush, and Refill.................. 184
Inspection........................... 183
Points to Remember.................... 187
Pressure Cap......................... 185
Radiator Cap......................... 185
Rubber and Plastic Components............ 188
Selection of Coolant...............184,212,213
Crankcase Emission Control System.......... 171
Customer Assistance..................... 235
Daytime Running Lights................... 76
Dealer Service.......................... 163
246 INDEX

Engine Oil Viscosity...................166,212
Engine Oil Viscosity Chart................. 166
Exhaust Gas Caution................51,145,182
Exhaust System......................... 182
Exterior Lights.......................... 205
Fan .................................. 105
Filters
Air Cleaner.......................... 171
Engine Oil........................... 213
Flashers
Hazard Warning.....................87,148
Turn Signal........................... 87
Flash-To-Pass........................... 78
Floor Console........................... 66
Fluid Capacities......................... 212
Fluid Leaks............................. 52
Fluid Level Checks
Brake............................190,214Capacities........................... 212
Cooling System....................... 183
Engine Oil........................... 164
Manual Transmission................... 193
Power Steering.....................178,214
Fluids................................ 213
Fog Lights.........................75,77,90
Four-Way Hazard Flasher.................. 148
Freeing A Stuck Vehicle................... 155
Fuel................................. 142
Adding............................. 145
Additives............................ 144
Clean Air............................ 142
Gasoline............................ 142
Gauge............................... 93
Octane Rating........................ 213
Requirements......................142,212
Tank Capacity........................ 212
Fueling............................... 145
248 INDEX

Fuses................................ 197
GasCap .............................. 145
Gasoline.............................. 142
Gasoline, Clean Air...................... 142
Gasoline, Reformulated................... 142
Gasoline/Oxygenate Blends................ 143
Gauges................................ 92
Coolant Temperature..................90,92
Fuel................................ 93
Oil Pressure........................... 92
Speedometer.......................... 86
Tachometer........................... 92
Voltmeter............................ 93
General Information...................... 18
Glass Cleaning.......................... 195
Ground Clearance....................... 141
Hazard Warning Flasher.................87,148Headlights............................ 207
Aiming............................. 212
High Beam........................... 78
High Beam/Low Beam Select Switch......... 78
Passing.............................. 78
Switch............................... 75
Time Delay........................... 76
Heater............................... 104
High Beam Indicator...................... 89
Hood Latch Maintenance.................. 180
Hood Release........................... 71
Hoses.............................188,189
Hydraulic Clutch Fluid.................... 192
Ignition
Key ................................. 11
Timing.............................. 170
Wiring System........................ 170
Infant Restraint.......................... 34
INDEX 249
10

Inside Rearview Mirror.................... 67
Instrument Cluster........................ 86
Instrument Panel and Controls............... 85
Instrument Panel Lens Cleaning............. 195
Interior and Instrument Lights..........See Lights
Interior Lighting......................... 74
Interior Lights........................... 74
Intermittent Wipers....................... 82
Introduction............................. 4
Jump Starting.......................... 150
Key-In Reminder......................... 12
Keyless Entry System...................... 15
Keys.................................. 11
Knee Bolster............................ 41
Lap/Shoulder Belts....................... 27
LATCH (Lower Anchors and Tether for CHildren) . 36Latches
Hood.............................71,180
Lead Free Gasoline...................... 142
Light Bulbs............................ 205
Lights...............................52,73
Airbag.............................44,91
Anti-Lock Warning...................... 87
Back-Up............................. 74
Brake Warning......................... 91
Bulb Replacement...................... 204
Daytime Running....................... 76
Dimmer Switch, Headlight..............74,78
Engine Temperature Warning.............. 90
Exterior Check......................... 52
Fog .............................75,77,90
Hazard Warning Flasher...............87,148
Headlight Switch....................... 75
Headlights.........................75,207
High Beam........................... 78
250 INDEX

High Beam Indicator.................... 89
Instrument Cluster...................... 75
Interior.............................. 74
License............................. 211
Lights On Reminder..................... 76
Malfunction Indicator.................... 88
Map Reading.......................... 73
Oil Pressure........................... 90
Reading.............................. 73
Seat Belt Reminder...................... 89
Service...........................204,205
Service Engine Soon (Malfunction Indicator).... 88
Turn Signal.......................74,77,87
Loading Vehicle......................... 146
Capacities........................... 146
Tires ............................... 126
Locks
Door................................ 13
Low Tire Indicator....................... 139Low Tire Pressure System.................. 139
Lower Anchors and Tether for CHildren (LATCH) . 36
Lubricants..........................179,180
Lubrication, Body....................... 179
Luggage/Cargo Capacity.................. 146
Maintenance Free Battery.................. 171
Maintenance Schedule.................... 218
Light Duty ScheduleB................. 221
ScheduleA......................... 228
ScheduleB.......................... 221
Malfunction Indicator Light..............88,162
Manual, Service......................... 240
Manual Transmission..................... 114
Shift Speeds.......................... 115
Master Cylinder......................... 191
Message Center.......................... 87
Mirrors................................ 67
Electric Remote........................ 68
INDEX 251
10

Distribution Center..................... 197
Steering..........................121,178
Windows............................. 24
Pregnant Women and Seat Belts.............. 33
Programming Transmitters.................. 18
Radial Ply Tires......................... 134
Radiator Cap (Coolant Pressure Cap).......... 185
Radio Antenna......................... 103
Radio Broadcast Signals.................... 94
Radio Operation........................ 103
Radio (Sound Systems).................... 95
Rear Axle............................. 193
Rear Wheel Bearings..................... 194
Rearview Mirrors........................ 67
Reclining Front Seats...................... 71
Recommended Fluids, Lubricants and Genuine
Parts............................... 213
Reformulated Gasoline.................... 142Refrigerant............................ 177
Reminder, Lights On...................... 76
Reminder, Seat Belt.....................31,89
Remote Keyless Entry..................... 15
Replacement Parts....................... 163
Replacement Tires....................... 137
Reporting Safety Defects................... 239
Restraints, Child......................... 34
Restraints, Infant......................... 34
Restraints, Occupant...................... 26
Rocking Vehicle When Stuck................ 155
Rotation, Tires.......................... 141
Safety Checks Inside Vehicle................. 51
Safety Checks Outside Vehicle............... 52
Safety Defects, Reporting.................. 239
Safety Information, Tire................... 122
Safety Tips............................. 51
Schedule, Maintenance.................... 218
INDEX 253
10