ECU DODGE VIPER 2009 ZB II / 2.G Owner's Manual

Normal Starting
CAUTION!
The engine in your vehicle is designed for operation
down to 0°F (-18°C). Starting the engine below 0°F
(-18°C) creates a potential for scuffing or seizing of
internal components in this very high performance
engine. To prevent engine damage, do not start the
engine at temperatures below 0°F (-18°C).
NOTE:
•You must disarm the security system in order to start
the engine. For details, refer to “Security Alarm Sys-
tem” in Section 2 of this manual
•Normal Starting of either a cold or a warm engine does
not require pumping or depressing the accelerator
pedal. However, if the engine has not started within
three seconds, slightly depress the accelerator pedalwhile continuing to crank. If the engine fails to start
within 15 seconds, turn the key to the OFF/LOCK
position, wait five seconds, then repeat the normal
starting procedure.
To start the engine:
1. Fully apply the parking brake.
2. Press the clutch pedal to the floor.
NOTE:The engine will not start unless the clutch pedal
is pressed to the floor.
3. Place the gear selector in NEUTRAL
4. Insert the ignition key fully into the ignition switch
5. Turn the key to the ON/RUN position.
STARTING AND OPERATING 135
5

WARNING!
•Never have any smoking materials lit in or near
the vehicle when the gas cap is removed or the
tank filled.
•Never add fuel to the vehicle when the engine is
running.
•A fire may result if gasoline is pumped into a
portable container that is inside of a vehicle. You
could be burned. Always place gas containers on
the ground while filling.
NOTE:
•Tighten the gas cap until you hear a “clicking” sound.
This is an indication that the gas cap is tightened
properly. The Malfunction Indicator Light in the in-
strument cluster may turn on if the gas cap is not
secured properly. Make sure that the gas cap is tight-
ened each time the vehicle is refueled.
•If the gas cap is lost or damaged, be sure the replace-
ment cap is for use with this vehicle.
TRAILER TOWING
Trailer towing with this vehicle is not recommended.
RECREATIONAL TOWING (BEHIND
MOTORHOME, ETC.)
Towing This Vehicle Behind Another Vehicle (Flat
towing with all four wheels on the ground)
Recreational towing for this vehicle is not recommended.
NOTE:If the vehicle requires towing, make sure all four
wheels are off the ground.
176 STARTING AND OPERATING

D. After Injecting TIREFIT Sealant
1. Allow the air pump to inflate the tire to the pressure
indicated on the tire pressure label on the driver-side
latch pillar. Check the pressure in the tire by looking at
the Pressure Gauge 2.
•If the tire inflates to at least 26 psi (1.8 bar) within
15 minutes, proceed to Step 2 of this procedure.
•If tire fails to inflate to 26 psi (1.8 bar) within
15 minutes, perform the procedure steps described
under “G. Distributing TIREFIT Sealant to Better
Enable Tire Inflation.”
2. Press the AIR PUMP POWER button 3 to
turn OFF the TIREFIT kit.3. Remove the Speed Limit sticker from the top of the
Sealant Bottle 1 and place the sticker on the steering
wheel.
4. Disconnect the Clear Sealant Hose 7 from the valve
stem, reinstall the Yellow Cap on the fitting at the end of
the hose, and place the TIREFIT kit in the vehicle.
CAUTION!
Failure to reinstall the Yellow Cap on the fitting at
the end of the Clear Sealant Hose 7 can result in
sealant contacting your skin, clothing, and the ve-
hicle interior. It can also result in sealant contacting
internal TIREFIT kit components causing permanent
damage to the kit.
E. Securing TIREFIT Sealant in the Tire
Drive the vehicle for approximately 5 mi (8 km) to ensure
distribution of the TIREFIT Sealant within the tire.
188 WHAT TO DO IN EMERGENCIES

WARNING!
TIREFIT is not a permanent flat tire repair. Have the
tire inspected and repaired or replaced after using
TIREFIT. Do not exceed 55 mph (90 km/h) until
having the tire repaired or replaced. Failure to follow
this warning can result in injuries that are serious or
fatal to you, your passengers, and others around you.
F. After Securing TIREFIT Sealant in the Tire
1. Turn the Mode Select knob 4 to the Air
Mode position.
2. Uncoil the Black Air Pump Hose 6 and connect it to the
valve stem.
3. Check the pressure in the tire by reading the Pressure
Gauge 2.
•If the pressure is less than 19 psi (1.3 bar), the tire is
too badly damaged. Do not attempt to drive the
vehicle further. Call for assistance.
•If the pressure is equal to or greater than 19 psi
(1.3 bar), but less than the level indicated on the tire
pressure label, proceed to Step 4 of this procedure.
•If the pressure is at the level indicated on the tire
pressure label on the driver-side latch pillar, proceed
to Step 5 of this procedure.
4. Inflate the tire to the pressure indicated on the tire
pressure label on the driver-side latch pillar.
5. Disconnect the TIREFIT kit from the valve stem and
then reinstall the cap on the valve stem.
6. Place the TIREFIT kit in its proper storage area in the
vehicle.
WHAT TO DO IN EMERGENCIES 189
6

7.If you are jump-starting another vehicle,connect one
end of a jumper cable to the remote jump-start positive
post(+). Connect the other end of the same cable to the
positive(+)terminal of the discharged battery.
8.If you are jump-starting your vehicle,connect the
other cable to the negativeterminal on the booster
battery. Connect the other end of the same cable to the ear
of the thermostat housing on the engine in your vehicle.
Make sure you have a good contact.
9.If you are jump-starting another vehicle,connect the
other cable to the ear of the thermostat housing on the
engine in your vehicle. Connect the other end of the same
cable to a good ground on the engine in the other vehicle.
Make sure that you have a good contact.WARNING!
•You should not try to start your vehicle by pushing
or towing.
•Do not connect the cable to the negative post of the
discharge battery. The resulting electrical spark
could cause the battery to explode.
•During cold weather when temperatures are be-
low freezing point, electrolyte in a discharged
battery may freeze. Do not attempt jump-starting
because the battery could rupture or explode. The
battery temperature must be brought up above
freezing point before attempting jump-start.
10. Start the engine in the vehicle that has the booster
battery. Let the engine idle a few minutes.
11. Turn off the Vehicle Security Alarm System.
194 WHAT TO DO IN EMERGENCIES

NOTE:The Vehicle Security Alarm System will prevent
the engine from starting.
12. Start the engine in the vehicle with the discharged
battery. If engine does not start in 15 seconds, stop
cranking engine and allow starter to cool down before
cranking again.
13. When removing the booster cables, reverse the above
sequence exactly. Be careful of the moving belts and fans.
WARNING!
Any procedure other than above could result in:
•Personal injury caused by electrolyte squirting out
the battery vent;
•Personal injury or property damage due to battery
explosion;
•Damage to charging system of booster vehicle or
of immobilized vehicle.
FREEING A STUCK VEHICLE
If your vehicle becomes stuck in mud, sand, or snow, it
can often be moved by a rocking motion. Turn your
steering wheel right and left to clear the area around the
front wheels. Then shift back and forth between RE-
VERSE and First gear. Usually the least accelerator pedal
pressure to maintain the rocking motion without spin-
ning the wheels is most effective.
CAUTION!
Racing the engine or spinning the wheels too fast
may lead to transmission/axle overheating and fail-
ure. It can also damage the tires. Do not spin the
wheels above 30 mph (48 km/h).
WHAT TO DO IN EMERGENCIES 195
6

•The Vehicle Security Alarm is disabled when the
Battery Save Feature is enabled. Therefore, the vehicle
is not protected when the Battery Save Feature is
enabled.
•The exterior and interior lighting functions will not
work when the Battery Save Feature is enabled.
To Deactivate the Battery Save Feature
1. Press the exterior driver’s door handle once to wake
up the vehicle. Then, press the handle again to open the
door.
NOTE:If the door does not open (vehicle is armed),
press the RKE UNLOCK button to unlock the vehicle.
2. Insert the key into the ignition switch.
3. Turn the ignition switch to the ON/RUN position. The
Battery Save Feature will turn off.NOTE:If the ignition switch is NOT turned to ON/
RUN position, the Battery Save Feature will be enabled
45 seconds after the driver’s door is closed.
Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance
test. Drive belt tension should also be checked at this
time.
NOTE:If A/C performance seems less then normal,
check the front of the A/C condenser (located in front of
the radiator) for dirt and insect accumulation. Clean with
a gentle water spray as required. Front end fascia protec-
tors may reduce air flow to the condenser and radiator,
reducing A/C and engine cooling performance.
MAINTAINING YOUR VEHICLE 211
7

About Your Brakes....................... 147
ABS (Anti-Lock Brake System)............101,148
Accessory Delay, Power..................13,28
Adding Engine Coolant (Antifreeze).......... 218
Adding Fuel........................... 175
Adding Washer Fluid..................... 213
Adjustable Pedals........................ 92
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 206
Air Conditioner Maintenance............... 211
Air Conditioning................125,126,128,211
Air Conditioning Controls................. 126
Air Conditioning, Operating Tips............ 130
Air Conditioning Refrigerant............. 211,212
Air Conditioning System.............126,128,211
Air Pressure, Tires....................105,161
Airbag................................ 42
Airbag Deployment.....................46,51
Airbag Light...................46,47,53,61,103
Airbag Maintenance....................... 52Airbag On/Off Switch..................... 54
Alarm System (Security Alarm)............... 13
Alterations/Modifications, Vehicle............. 7
Antenna.............................. 124
Antenna, Satellite Radio................... 124
Antifreeze (Engine Coolant)...........217,218,246
Capacities........................... 246
Disposal............................ 220
Anti-Lock Brake System (ABS).............. 148
Anti-Lock Warning Light...............101,151
Anti-Theft Security Alarm (Theft Alarm)........ 13
Appearance Care........................ 226
Auto Down Power Windows................ 30
Automatic Door Locks..................... 27
Battery............................109,207
Emergency Starting..................... 192
Jump Starting......................... 192
Keyless Transmitter Replacement (RKE)....... 23
280 INDEX

Seat Belt Reminder.....................39,107
Seat Belts............................33,34
And Pregnant Women................... 41
Child Restraint...................53,54,55,58
Extender............................. 41
Inspection............................ 61
Maintenance.......................... 229
Operating Instructions................... 35
Reminder............................ 107
Untwisting Procedure.................... 39
Seats................................. 79
Adjustment........................... 79
Reclining............................. 80
Security Alarm (Theft Alarm)................ 13
Selection of Coolant (Antifreeze)..........217,247
Selection of Oil......................... 205
Service Assistance....................... 271
Service Contract......................... 273Service Engine Soon Light
(Malfunction Indicator).................... 102
Service Manuals........................ 275
Setting the Clock........................ 110
Shift Indicator Light...................107,139
Shift Speeds.........................137,139
Shift Speeds, Manual Transaxle.............. 139
Shoulder Belts........................... 34
Signals, Turn.........................85,103
Slippery Surfaces, Driving On............... 141
Snow Chains (Tire Chains)................. 167
Snow Tires............................ 167
Speedometer........................... 100
Starting............................... 134
Emergency (Jump Starting)............... 192
Engine Fails to Start.................... 136
Starting and Operating.................... 134
Starting Procedures...................... 134
INDEX 291
10

Steering
Power.............................. 144
Tilt Column........................... 91
Storage............................... 234
Storage, Vehicle......................... 129
Stuck, Freeing.......................... 195
Supplemental Restraint System - Airbag........ 42
Synthetic Engine Oil...................... 206
Tachometer............................ 107
Temperature Gauge, Engine Coolant.......... 108
Theft Alarm (Security Alarm)................ 13
Theft System (Security Alarm)............... 13
Tilt Steering Column...................... 91
Tire and Loading Information Placard......... 156
Tire Identification Number (TIN)............. 155
Tire Markings.......................... 151
Tire Safety Information.................... 151
TIREFIT.............................. 181Tires ............................62,160,276
Aging (Life of Tires).................... 165
Air Pressure.......................... 160
Chains.............................. 167
General Information.................... 160
High Speed.......................... 162
Inflation Pressures..................... 161
Life of Tires.......................... 165
Load Capacity........................ 156
Pressure Monitor System (TPMS)........... 169
Quality Grading....................... 276
Radial.............................. 163
Replacement......................... 166
Rotation............................. 167
Safety..........................62,151,160
Sizes............................... 153
Snow Tires........................... 167
Spinning............................ 164
Storage............................. 167
292 INDEX