steering DODGE VIPER 2009 ZB II / 2.G Owner's Manual

HAZARD WARNING FLASHER
The Hazard Warning flasher switch is on the top of the
steering column, just behind the steering wheel.
Press the Hazard Warning flasher switch and all front
and rear directional signals will flash. Press the switch a
second time to turn the flashers off.Do not use this emergency warning system when the
vehicle is in motion. Use it when your vehicle is disabled
and is creating a safety hazard for other motorists.
If it is necessary to leave the vehicle to go for service, the
Hazard Warning flasher will continue to operate with the
ignition key removed.
NOTE:With extended use, the Hazard Warning flasher
may run down your battery.
IF YOUR ENGINE OVERHEATS
In any of the following situations, you can reduce the
potential for overheating by taking the appropriate ac-
tion.
•On the highways —Slow down and use the highest
gear possible.
•In city traffic —While stopped, put the transmission
in NEUTRAL, but do not increase engine idle speed.
Hazard Warning Switch
180 WHAT TO DO IN EMERGENCIES

D. After Injecting TIREFIT Sealant
1. Allow the air pump to inflate the tire to the pressure
indicated on the tire pressure label on the driver-side
latch pillar. Check the pressure in the tire by looking at
the Pressure Gauge 2.
•If the tire inflates to at least 26 psi (1.8 bar) within
15 minutes, proceed to Step 2 of this procedure.
•If tire fails to inflate to 26 psi (1.8 bar) within
15 minutes, perform the procedure steps described
under “G. Distributing TIREFIT Sealant to Better
Enable Tire Inflation.”
2. Press the AIR PUMP POWER button 3 to
turn OFF the TIREFIT kit.3. Remove the Speed Limit sticker from the top of the
Sealant Bottle 1 and place the sticker on the steering
wheel.
4. Disconnect the Clear Sealant Hose 7 from the valve
stem, reinstall the Yellow Cap on the fitting at the end of
the hose, and place the TIREFIT kit in the vehicle.
CAUTION!
Failure to reinstall the Yellow Cap on the fitting at
the end of the Clear Sealant Hose 7 can result in
sealant contacting your skin, clothing, and the ve-
hicle interior. It can also result in sealant contacting
internal TIREFIT kit components causing permanent
damage to the kit.
E. Securing TIREFIT Sealant in the Tire
Drive the vehicle for approximately 5 mi (8 km) to ensure
distribution of the TIREFIT Sealant within the tire.
188 WHAT TO DO IN EMERGENCIES

NOTE:The Vehicle Security Alarm System will prevent
the engine from starting.
12. Start the engine in the vehicle with the discharged
battery. If engine does not start in 15 seconds, stop
cranking engine and allow starter to cool down before
cranking again.
13. When removing the booster cables, reverse the above
sequence exactly. Be careful of the moving belts and fans.
WARNING!
Any procedure other than above could result in:
•Personal injury caused by electrolyte squirting out
the battery vent;
•Personal injury or property damage due to battery
explosion;
•Damage to charging system of booster vehicle or
of immobilized vehicle.
FREEING A STUCK VEHICLE
If your vehicle becomes stuck in mud, sand, or snow, it
can often be moved by a rocking motion. Turn your
steering wheel right and left to clear the area around the
front wheels. Then shift back and forth between RE-
VERSE and First gear. Usually the least accelerator pedal
pressure to maintain the rocking motion without spin-
ning the wheels is most effective.
CAUTION!
Racing the engine or spinning the wheels too fast
may lead to transmission/axle overheating and fail-
ure. It can also damage the tires. Do not spin the
wheels above 30 mph (48 km/h).
WHAT TO DO IN EMERGENCIES 195
6

ENGINE COMPARTMENT — 8.4L
1 — Coolant Pressure Cap 6 — Clutch Fluid Reservoir
2 — Engine Oil Dipstick 7 — Power Steering Fluid Reservoir
3 — Power Distribution Center 8 — Engine Oil Fill
4 — Remote Jump Start Positive Battery Post 9 — Air Cleaner Filter
5 — Brake Fluid Reservoir 10 — Washer Fluid ReservoirMAINTAINING YOUR VEHICLE 1997

Chassis
Component Fluid, Lubricant, or Genuine Part
Transmission MOPARATF+4 Automatic Transmission Fluid
Rear Axle MOPARSynthetic Gear and Axle Lubricant SAE 75W-140 or equivalent,
with Limited Slip Additive Friction Modifier
Brake Master Cylinder MOPARBrake and Clutch Fluid DOT 4 Motor Vehicle or equivalent
Power Steering Reservoir MOPARPower Steering Fluid + 4, MOPARATF+4 Automatic Transmission
Fluid
248 MAINTAINING YOUR VEHICLE

At Each Stop for Fuel
•Check the engine oil level about five minutes after a
fully warmed engine is shut off. Checking the oil level
while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when
the level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery, and clean and tighten the terminals
as required.
•Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering, and transmission,
and add as needed.
•Check all lights and all other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
NOTE:Also, inspect the exhaust system if you notice a
change in the sound of the exhaust system, or if the
exhaust fumes can be detected inside the vehicle.
•Inspect the brake hoses.
•Inspect the suspension components.
•Lubricate door hinges and check springs.
•Check the engine coolant level, hoses, and clamps.
•Check power steering fluid level.
252 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Location..........................192,207
Saving Feature (Protection)............... 210
Storing Vehicle........................ 210
Belts, Seat............................33,34
Body Mechanism Lubrication............... 212
Boot, Convertible Top...................69,74
B-Pillar Location........................ 156
Brake, Parking.......................... 145
Brake System........................147,222
Anti-Lock (ABS)....................147,148
Fluid Check.......................222,248
Master Cylinder....................... 222
Warning Light........................ 104
Break-In Recommendations, New Vehicle.....59,147
Bulb Replacement....................... 237
Bulbs, Light............................ 236
Capacities, Antifreeze (Engine Coolant)........ 246
Capacities, Fluid........................ 246Caps, Filler
Fuel................................ 175
Oil (Engine).......................... 205
Power Steering........................ 144
Radiator (Coolant Pressure)............... 219
Car Washes............................ 227
Carbon Monoxide Warning...............60,174
CD (Compact Disc) Changer................ 116
CD (Compact Disc) Player............... 111,115
Cellular Phone.......................... 125
Chains, Tire............................ 167
Charging System Light.................... 109
Chart, Tire Sizing........................ 153
Check Engine Light
(Malfunction Indicator Light)............... 201
Checks, Safety........................... 60
Child Restraint....................53,54,55,58
Child Restraint Tether Anchors............... 56
Circuit Breakers......................... 230
INDEX 281
10

Clean Air Gasoline....................... 171
Climate Control......................... 125
Clock................................ 110
Clutch Fluid........................... 224
Compact Disc (CD) Maintenance............. 124
Console............................... 94
Console, Floor........................... 94
Contract, Service........................ 273
Convertible............................. 65
Convertible Boot.......................69,74
Convertible Top.......................65,228
Convertible Top Maintenance............... 228
Coolant Pressure Cap (Radiator Cap).......... 219
Cooling System......................... 216
Adding Coolant (Antifreeze).............. 218
Coolant Capacity...................... 246
Coolant Level......................217,220
Disposal of Used Coolant................ 220
Drain, Flush, and Refill.................. 217Inspection........................... 220
Points to Remember.................... 221
Pressure Cap......................... 219
Radiator Cap......................... 219
Selection of Coolant (Antifreeze)......217,246,247
Customer Assistance..................... 271
Daytime Running Lights................... 84
Dealer Service.......................... 203
Defroster, Rear Window.................... 95
Defroster, Windshield...................61,128
Delay (Intermittent) Wipers................. 90
Diagnostic System, Onboard................ 200
Dimmer Control......................... 88
Dimmer Switch, Headlight.................. 86
Dipsticks
Power Steering........................ 144
Disposal
Antifreeze (Engine Coolant)............... 220
282 INDEX

Engine Oil Viscosity Chart................. 205
Ethanol............................... 171
Exhaust Gas Caution..............31,60,174,214
Exhaust System.......................60,214
Exterior Finish Care...................... 227
Filters
Air Cleaner.......................... 206
Engine Oil........................206,247
Engine Oil Disposal.................... 206
Finish Care............................ 227
Flashers
Hazard Warning....................103,180
Turn Signal........................85,103
Flash-To-Pass........................... 86
Flooded Engine Starting................... 136
Floor Console........................... 94
Fluid Capacities......................... 246
Fluid Leaks............................. 62Fluid Level Checks
Brake............................222,248
Capacities........................... 246
Clutch Fluid.......................... 224
Cooling System....................... 217
Engine Oil........................... 203
Manual Transmission.................224,248
Power Steering.....................144,248
Fluids................................ 247
Fluids, Lubricants and Genuine Parts.......... 247
Fog Lights.........................83,84,101
Four-Way Hazard Flasher.................. 180
Freeing A Stuck Vehicle................... 195
Fuel................................. 170
Adding............................. 175
Clean Air............................ 171
Ethanol............................. 171
Filler Cap (Gas Cap).................... 175
Gasoline............................ 170
284 INDEX

Checking............................ 203
Dipstick............................. 203
Disposal............................ 206
Filter............................206,247
Filter Disposal........................ 206
Materials Added to..................... 206
Pressure Gauge....................... 108
Recommendation...................205,246
Viscosity..........................205,246
Oil Filter, Selection....................... 206
Onboard Diagnostic System..............200,201
Operator Manual (Owner’s Manual)............ 4
Outside Rearview Mirrors.................. 77
Overheating, Engine...................... 180
Owner’s Manual (Operator Manual).........4,275
Paint Care............................. 226
Paint Damage.......................... 226
Panic Alarm............................ 21Parking Brake.......................... 145
Parking On Hill......................... 145
Passing Light........................... 86
Pedals, Adjustable........................ 92
Pets.................................. 59
Pets, Transporting........................ 59
Placard, Tire and Loading Information......... 156
Polishing and Waxing..................... 227
Power
Accessory Delay......................13,28
Brakes.............................. 147
Distribution Center (Fuses)............... 230
Door Locks........................... 26
Mirrors.............................. 78
Steering............................. 144
Windows............................. 28
Pregnant Women and Seat Belts.............. 41
Programming Transmitters
(Remote Keyless Entry).................... 22
INDEX 289
10