ABS DODGE VIPER 2010 ZB II / 2.G User Guide

WARNING!
•Use only manufacturer’s recommended brake
fluid. Refer to “Fluids, Lubricants, and Genuine
Parts” in “Maintaining Your Vehicle” for further
information. Using the wrong type of brake fluid
can severely damage your brake system and/or
impair its performance. The proper type of brake
fluid for your vehicle is also labeled on the origi-
nal factory installed hydraulic master cylinder
reservoir.(Continued)
WARNING! (Continued)
•To avoid contamination from foreign matter or
moisture, use only new brake fluid or fluid that
has been in a tightly closed container. Keep the
master cylinder reservoir cap secured at all times.
Brake fluid in a open container absorbs moisture
from the air resulting in a lower boiling point.
This may cause it to boil unexpectedly during hard
or prolonged braking, resulting in sudden brake
failure. This could result in a accident.
•Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts, causing
the brake fluid to catch fire. Brake fluid can also
damage painted and vinyl surfaces, care should be
taken to avoid its contact with these surfaces.(Continued)
234 MAINTAINING YOUR VEHICLE

WARNING! (Continued)
•Do not allow petroleum based fluid to contami-
nate the brake fluid. Brake seal components could
be damaged, causing partial or complete brake
failure. This could result in an accident.
Change Brake Fluid
Brake fluid will tend to absorb moisture from the atmo-
sphere over time. If the fluid becomes contaminated with
water, brake performance will deteriorate. Therefore, the
brake fluid must be changed at the intervals specified in
the “Maintenance Schedule.” Refer to “Maintenance
Schedule” for further information. See your authorized
dealer for service.
Manual Transmission
Transmission Fluid Level Check
Check the fluid in the transmission when performing
other underhood services.Check the fluid level by removing the fill plug located on
the left side of the transmission. The fluid level should be
at the bottom of the fill hole. Add fluid, if necessary, to
maintain the proper level. Refer to “Fluids, Lubricants,
and Genuine Parts” in “Maintaining Your Vehicle” for
further information.
CAUTION!
Using a transmission fluid other than the manufac-
turer’s recommended fluid may cause deterioration
in transmission shift quality and/or damage to the
transmission. Refer to “Fluids, Lubricants, and
Genuine Parts” in “Maintaining Your Vehicle” for
further information.
Change Transmission Fluid
Refer to “Maintenance Schedule” for the proper mainte-
nance intervals. If contaminated with water, change the
fluid immediately. See your authorized dealer for service.
7
MAINTAINING YOUR VEHICLE 235

Change Clutch Fluid
Clutch fluid will tend to absorb moisture from the
atmosphere over time. If the fluid becomes contaminated
with water, clutch performance will deteriorate. There-
fore, the clutch fluid must be changed at the intervals
specified in “Maintenance Schedule.” Refer to “Mainte-
nance Schedule” for further information. See your autho-
rized dealer for service.
Rear Axle
Axle Lubricant Level Check
Check the exterior of the axle for evidence of gear oil
leakage every 12 months or 6,000 miles (10 000 km). This
check should be made with the vehicle level and sup-
ported by the suspension, with the vehicle on the ground
or raised on an axle and wheel type hoist. The axle
lubricant level should be between the bottom of the filler
plug and a point approximately 3/8 in (9.5 mm) below
the filler plug. If adding axle lubricant, use only themanufacturer’s recommended axle lubricant. Refer to
“Fluids, Lubricants, and Genuine Parts” in “Maintaining
Your Vehicle” for further information.
NOTE:
The Limited Slip Differential requires that a
friction control additive be added when draining and
refilling the axle lubricant.
Change Axle Lubricant
Refer to “Maintenance Schedule” for the proper mainte-
nance intervals. Change the lubricant immediately if
contaminated with water. See your authorized dealer for
service.
Appearance Care and Protection from Corrosion
Protection of Body and Paint from Corrosion
Vehicle body care requirements vary according to geo-
graphic locations and usage. Chemicals that make roads
7
MAINTAINING YOUR VEHICLE 237

if absolutely necessary. Do not use harsh cleaners or
Armor All. Use MOPARTotal Clean or equivalent to
clean vinyl upholstery.
Leather or Vinyl Seat/Trim Care and Cleaning
Leather is best preserved by regular cleaning with a
damp soft cloth. Small particles of dirt can act as an
abrasive and damage the leather surface and should be
removed immediately with a damp cloth. Stubborn soils
can be removed easily with a soft cloth and MOPAR
Total Clean or equivalent. Care should be taken to avoid
soaking the leather with any liquid. Please do not use
polishes, oils, cleaning fluids, solvents, detergents, or
ammonia-based cleaners to clean the leather. Application
of a leather conditioner is not required to maintain the
original condition.
Glass Surfaces
All glass surfaces should be cleaned on a regular basis with
MOPAR Glass Cleaner or any commercial household-type glass cleaner. Never use an abrasive type cleaner. Use
caution when cleaning inside rear windows equipped with
electric defrosters. Do not use scrapers or other sharp
instruments which may scratch the elements.
When cleaning the rearview mirror, spray cleaner on the
towel or rag that you are using. Do not spray cleaner
directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft rag. A mild soap solution may be
used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
rag.
2. Dry with a soft tissue.
240 MAINTAINING YOUR VEHICLE

FUSES
Power Distribution Center
The Power Distribution Center is located in the engine
compartment on the driver’s side of the vehicle. This
center contains fuses and relays.
Cavity Car-tridge
Fuse Mini-
Fuse
Description
1 40 Amp Green — Blower Motor
2 40 Amp Green — Anti-Lock Brakes (ABS)
Pump Feed/Starter
3 30 Amp Pink — Body Control Module
(BCM) – Battery Feed
4 20 Amp Blue — Amplifier
5 30 Amp Pink — Ignition Switch Run/
Accessory Feed – Win-
dows
6 40 Amp Green — Body Control Module
(BCM) – Battery Feed
7 30 Amp Pink — Anti-Lock Brakes (ABS)
Module
Power Distribution Center
244 MAINTAINING YOUR VEHICLE

We appreciate that you have made a major investment
when you purchased the vehicle. An authorized dealer
has also made a major investment in facilities, tools, and
training to assure that you are absolutely delighted with
the ownership experience. You’ll be pleased with their
sincere efforts to resolve any warranty issues or related
concerns.
WARNING!
Engine exhaust, some of its constituents, and certain
vehicle components contain, or emit, chemicals
known to the State of California to cause cancer and
birth defects, or other reproductive harm. In addi-
tion, certain fluids contained in vehicles and certain
products of component wear contain, or emit, chemi-
cals known to the State of California to cause cancer
and birth defects, or other reproductive harm.
WARRANTY INFORMATION
See the Warranty Information Booklet, located on the
DVD, for the terms and provisions of Chrysler Group
LLC warranties applicable to this vehicle and market.
MOPARPARTS
MOPAR fluids, lubricants, parts, and accessories are
available from an authorized dealer. They are recom-
mended for your vehicle in order to help keep the vehicle
operating at its best.
REPORTING SAFETY DEFECTS
In the 50 United States and Washington, D.C.
If you believe that your vehicle has a defect that could
cause a crash or cause injury or death, you should
immediately inform the National Highway Traffic Safety
Administration (NHTSA) in addition to notifying the
manufacturer.
290 IF YOU NEED CONSUMER ASSISTANCE

About Your Brakes....................... 157
ABS (Anti-Lock Brake System) ............ 110,158
Accessory Delay, Power ..................13,28
Adding Engine Coolant (Antifreeze) .......... 229
Adding Fuel ........................... 185
Adding Washer Fluid ..................... 224
Adjustable Pedals ........................ 97
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 216
Air Conditioner Maintenance ............... 221
Air Conditioning .................. 134,137,221
Air Conditioning Controls ................. 134
Air Conditioning, Operating Tips ............ 139
Air Conditioning Refrigerant .............221,222
Air Conditioning System .............134,137,221
Air Pressure, Tires .................... 1 13,172
Airbag ................................ 42
Airbag Deployment ..................... 47,53
Airbag Light ................... 48,49,56,65,112
Airbag Maintenance ....................... 55 Airbag On/Off Switch
..................... 58
Alarm System (Security Alarm) ............... 13
Alterations/Modifications, Vehicle ............. 7
Antenna .............................. 133
Antenna, Satellite Radio ................... 132
Antifreeze (Engine Coolant) ..............228,260
Capacities ........................... 260
Disposal ............................ 231
Anti-Lock Brake System (ABS) .............. 158
Anti-Lock Warning Light ................ 110,161
Anti-Theft Security Alarm (Theft Alarm) ........ 13
Appearance Care ........................ 237
Auto Down Power Windows ................ 29
Automatic Door Locks ..................... 26
Auxiliary Electrical Outlet (Power Outlet) ...... 100
Auxiliary Power Outlet ................... 100
Battery ............................ 1 18,217
Emergency Starting ..................... 202
296 INDEX

Jump Starting......................... 202
Keyless Transmitter Replacement (RKE) ....... 22
Location .......................... 202,217
Saving Feature (Protection) ............... 219
Storing Vehicle ........................ 219
Belts, Seat .......................... 32,34,65
Body Mechanism Lubrication ............... 223
Boot, Convertible Top ................... 75,79
B-Pillar Location ........................ 167
Brake, Parking .......................... 155
Brake System ........................ 157,232
Anti-Lock (ABS) .................... 157,158
Fluid Check ....................... 233,262
Master Cylinder ....................... 233
Warning Light ........................ 112
Break-In Recommendations, New Vehicle .....63,157
Bulb Replacement ....................... 251
Bulbs, Light .......................... 67,250Capacities, Antifreeze (Engine Coolant)
........ 260
Capacities, Fluid ........................ 260
Caps, Filler Fuel ............................... 185
Power Steering ........................ 154
Radiator (Coolant Pressure) ............... 230
Car Washes ............................ 238
Carbon Monoxide Warning ...............64,185
CD (Compact Disc) Changer ................ 125
CD (Compact Disc) Player ............... 119,123
Cellular Phone .......................... 134
Charging System Light .................... 118
Chart, Tire Sizing ........................ 163
Check Engine Light
(Malfunction Indicator Light) ............... 211
Checking Your Vehicle For Safety ............. 64
Checks, Safety ........................... 64
Child Restraint ...................... 56,58,62
Child Restraint Tether Anchors ............... 60
10
INDEX 297