steering DODGE VIPER 2016 VX / 3.G Service Manual

MAINTENANCE PROCEDURES
The pages that follow contain therequiredmaintenance
services determined by the engineers who designed your
vehicle.
Besides those maintenance items specified in the fixed
“Maintenance Schedule”, there are other components
which may require servicing or replacement in the future.
CAUTION!
• Failure to properly maintain your vehicle or per-
form repairs and service when necessary could
result in more costly repairs, damage to other
components or negatively impact vehicle perfor-
mance. Immediately have potential malfunctions
examined by an authorized dealer or qualified
repair center.
(Continued)
CAUTION! (Continued)
•Your vehicle has been built with improved fluids
that protect the performance and durability of your
vehicle and also allow extended maintenance inter-
vals. Do not use chemical flushes in these compo-
nents as the chemicals can damage your engine,
transmission, power steering or air conditioning.
Such damage is not covered by the New Vehicle
Limited Warranty. If a flush is needed because of
component malfunction, use only the specified
fluid for the flushing procedure.
Engine Oil
Checking Oil Level
To assure proper engine lubrication, the engine oil must
be maintained at the correct level. Check the oil level at
regular intervals, such as every fuel stop. The best time to
check the oil level is approximately five minutes after a
7
MAINTAINING YOUR VEHICLE 337

of storage time without losing radio and engine control-
ler adaptive memory. Using this feature is an alternative
to disconnecting the battery.
NOTE:This vehicle is designed to sit in storage with a
fully charged battery for up to 30 days. If you plan to
store the vehicle longer than 30 days, we recommend
doing one of the following:
• Disconnect the battery.
• Use the battery charger.
• Put the vehicle into Hibernation mode (3-month
charge).
To Activate Hibernation Mode
1. Cycle the ignition switch to (ACC).
2. Select Hibernation mode within the Driver Informa- tion Display (DID). 3. Push the right arrow button on the steering wheel
controls for one second. Vehicle will countdown from
ten seconds and enter Hibernation Mode.
NOTE: You may push the right arrow button on the
steering wheel controls during the countdown to abort
Hibernation Mode.
To Deactivate Hibernation Mode
1. Push the RKE UNLOCK button to unlock the vehicle.
2. Push the ignition switch to the ON/RUN position.
Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance
test. Drive belt tension should also be checked at this
time.
7
MAINTAINING YOUR VEHICLE 343

system and the clear coat. As with any automotive
coating, storing your vehicle in a covered location will
guarantee a long lasting finish.
The rear wing is molded with unidirectional carbon fiber
and painted in body color. Some patterned or linear
conditions may be visible in the painted carbon fiber
surfaces. This is also a normal result of the carbon fiber
process.
FUSES
WARNING!
•When replacing a blown fuse, always use an ap-
propriate replacement fuse with the same amp
rating as the original fuse. Never replace a fuse
with another fuse of higher amp rating. Never
replace a blown fuse with metal wires or any other
(Continued)
WARNING! (Continued)
material. Failure to use proper fuses may result in
serious personal injury, fire and/or property dam-
age.
• Before replacing a fuse, make sure that the ignition
is off and that all the other services are switched off
and/or disengaged.
• If the replaced fuse blows again, contact an autho-
rized dealer.
• If a general protection fuse for safety systems (air
bag system, braking system), power unit systems
(engine system, gearbox system) or steering system
blows, contact an authorized dealer.
366 MAINTAINING YOUR VEHICLE

Chassis
ComponentFluid, Lubricant, or Genuine Part
Transmission We recommend you use MOPAR ATF+4 Automatic
Transmission Fluid.
Rear Axle We recommend you use Castrol SAF-XJ/SAE 75W-140
Synthetic Gear and Axle Lubricant.
Brake/Clutch Master Cylinder We recommend you use MOPAR Brake and Clutch
Fluid DOT 4 Motor Vehicle.
Power Steering Reservoir We recommend you use MOPAR Power Steering Fluid +
4, MOPAR or ATF+4 Automatic Transmission Fluid.
7
MAINTAINING YOUR VEHICLE 383

Once A Month
•Check tire pressure and look for unusual wear or
damage. Rotate tires at the first sign of irregular wear,
even if it occurs before your next scheduled service.
• Inspect the battery, and clean and tighten the terminals
as required.
• Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering, and transmission, and
add as needed.
• Check all lights and all other electrical items for correct
operation. At Each Oil Change
•
Change the engine oil filter.
• Inspect the exhaust system.
NOTE: Also, inspect the exhaust system if you notice a
change in the sound of the exhaust system, or if the
exhaust fumes can be detected inside the vehicle.
• Inspect the brake hoses.
• Inspect the suspension components.
• Lubricate door hinges and check springs.
• Check the engine coolant level, hoses, and clamps.
• Check power steering fluid level.
8
MAINTENANCE SCHEDULES 387

Automatic Door Locks....................27, 28
Automatic Headlights ..................... .106
Auto Unlock, Doors ........................28
Auto Up Power Windows ....................30
Auxiliary Electrical Outlet (Power Outlet) ........132
Auxiliary Power Outlet .....................132
Battery ............................ .153, 341
Charging System Light ...................153
Emergency Starting ..................... .323
Jump Starting ......................... .323
Keyless Transmitter Replacement (RKE) ........23
Location ............................. .341
Remote Battery Replacement ................23
Saving Feature (Protection) ................342
Storing Vehicle ........................ .342
Transmitter Battery Replacement .............23
Belts, Seat ...............................87
Body Mechanism Lubrication .................345B-Pillar Location
......................... .273
Brake Control System, Electronic ..............259
Brake, Parking .......................... .255
Brake System ........................ .257, 355
Anti-Lock (ABS) .....................257, 259
Fluid Check ....................... .355, 383
Master Cylinder ....................... .355
Warning Light ........................ .150
Break-In Recommendations, New Vehicle ........258
Brightness, Interior Lights ...................110
Bulb Replacement ........................ .379
Bulbs, Light .......................... .88, 377
Camera, Rear ........................... .121
Capacities, Antifreeze (Engine Coolant) ..........380
Capacities, Fluid ......................... .380
Caps, Filler Oil (Engine) .......................... .339
Power Steering ........................ .254
10
INDEX 405

Corrosion Protection...................... .359
Cruise Light ............................ .168
Cupholders ............................ .136
Customer Assistance ...................... .395
Data Recorder, Event .......................71
Daytime Brightness, Interior Lights .............111
Daytime Running Lights ....................107
Dealer Service ........................... .336
Defroster, Rear Window .....................140
Defroster, Windshield .......................87
Delay (Intermittent) Wipers ..................111
Diagnostic System, Onboard .................334
Dimmer Switch, Headlight ...................109
Dipsticks Power Steering ........................ .254
Disposal Antifreeze (Engine Coolant) ................353
Door Ajar .............................. .157Door Ajar Light
......................... .157
Door Locks ..............................25
Key Fob Emergency Key ...................23
Door Locks, Automatic ......................27
Door Opener, Garage ...................... .123
Doors ..................................25
Driving Through Flowing, Rising, Or Shallow Standing
Water ............................... .251
Electrical Outlet, Auxiliary (Power Outlet) ........132
Electric Remote Mirrors ......................96
Electronic Brake Control System ...............259
Traction Control System ...................262
Electronic Speed Control (Cruise Control) ........117
Electronic Stability Control (ESC) ..............262
Electronic Throttle Control Warning Light ........155
Emergency Brake ........................ .255
10
INDEX 407

Turn Signal..................... .88, 108, 167
Flash-To-Pass ........................... .109
Flooded Engine Starting ....................240
Fluid Capacities ......................... .380
Fluid Leaks ..............................88
Fluid Level Checks Brake ........................... .355, 383
Capacities ........................... .380
Clutch Fluid .......................... .358
Cooling System ........................ .349
Engine Oil ........................... .337
Manual Transmission .................357, 383
Power Steering ..................... .254, 383
Fluids, Lubricants And Genuine Parts ...........381
Four-Way Hazard Flasher ...................310
Freeing A Stuck Vehicle .....................327
Fuel .................................. .297
Additives ............................ .299Clean Air
............................ .297
Ethanol ............................. .298
Gasoline ............................. .297
Light ............................... .165
Materials Added ....................... .299
Methanol ............................ .298
Octane Rating ..................... .297, 381
Requirements ...................... .297, 380
Tank Capacity ......................... .380
Fuses ................................. .366
Garage Door Opener (HomeLink) ..........123, 130
Gasoline, Clean Air ....................... .297
Gasoline (Fuel) .......................... .297
Gasoline, Reformulated .....................297
General Information ...................... .206
Glass Cleaning .......................... .362
Ground Clearance ........................ .307
10
INDEX 409

Placard, Tire And Loading Information..........274
Power Brakes .............................. .257
Door Locks ............................26
Mirrors ...............................96
Outlet (Auxiliary Electrical Outlet) ...........132
Steering .......................... .253, 254
Windows ..............................28
Pregnant Women And Seat Belts ...............43
Pretensioners Seat Belts ..............................43
Programming Transmitters (Remote Keyless Entry) . .23
Radial Ply Tires ......................... .281
Radiator Cap (Coolant Pressure Cap) ...........352
Radio Antenna .......................... .206
Radio Operation ......................... .206
Radio (Sound Systems) .....................203
Rear Camera ........................... .121Rear Liftgate
.............................31
Rear Window Defroster .....................140
Rear Window Features .....................140
Reclining Front Seats .......................99
Recorder, Event Data .......................71
Recreational Towing ...................... .306
Reformulated Gasoline .....................297
Refrigerant ............................. .344
Reminder, Lights On ...................... .107
Reminder, Seat Belt .........................35
Remote Keyless Entry (RKE) ..................20
FCC General Information ..................24
Programming Additional Key Fobs ...........16
Programming Additional Transmitters .........16
Remote Battery Replacement ................23
Transmitter Battery Replacement .............23
Remote Sound System (Radio) Controls .........204
Replacement Keys .........................15
Replacement Parts ........................ .336
414 INDEX

Untwisting Procedure.....................41
Seats ...................................98
Adjustment ........................ .98, 100
Reclining ..............................99
Security Alarm ........................ .17, 152
Selection Of Coolant (Antifreeze) ..............381
Selection Of Oil ......................... .338
SENTRY KEY FCC General Information ..................16
Key Programming .......................16
Sentry Key (Immobilizer) ....................14
Sentry Key Replacement .....................15
Service Assistance ........................ .395
Service Contract ......................... .397
Service Manuals ......................... .400
Shift Indicator Light ...................... .244
Shift Speeds ......................... .241, 244
Shoulder Belts ............................36
Signals, Turn ...................... .88, 108, 167Snow Chains (Tire Chains)
...................290
Spare Tire .......................... .284, 285
Spark Plugs ............................ .381
Speed Control (Cruise Control) ................117
Starting ............................... .238
Emergency (Jump Starting) ................323
Engine Fails To Start .....................240
Starting And Operating .....................238
Starting Procedures ....................... .238
Steering Column Controls ...................... .108
Power ........................... .253, 254
Tilt Column ...........................114
Steering Wheel Audio Controls ...............204
Steering Wheel Mounted Sound System Controls . . .204
Storage ............................... .374
Storage, Vehicle .......................... .213
Stuck, Freeing ........................... .327
416 INDEX