brake fluid DODGE VIPER SRT 2016 VX / 3.G User Guide

With disc brakes, fluid level can be expected to fall as the
brake pads wear. However, low fluid level may be caused
by a leak and a checkup may be needed.
Use only the manufacturer’s recommended brake fluid.
Refer to “Fluids, Lubricants, And Genuine Parts” in
“Maintaining Your Vehicle” for further information. Use
of a brake fluid that may have a lower initial boiling
point or unidentified as to specification, may result in
sudden brake failure during hard prolonged braking.
WARNING!
•Use only manufacturer ’s recommended brake
fluid. Refer to “Fluids, Lubricants, And Genuine
Parts” in “Maintaining Your Vehicle” for further
information. Using the wrong type of brake fluid
can severely damage your brake system and/or
impair its performance. The proper type of brake
(Continued)
WARNING! (Continued)
fluid for your vehicle is also identified on the
original factory installed hydraulic master cylinder
reservoir.
• To avoid contamination from foreign matter or
moisture, use only new brake fluid or fluid that has
been in a tightly closed container. Keep the master
cylinder reservoir cap secured at all times. Brake
fluid in a open container absorbs moisture from the
air resulting in a lower boiling point. This may
cause it to boil unexpectedly during hard or pro-
longed braking, resulting in sudden brake failure.
This could result in a accident.
• Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts, causing
the brake fluid to catch fire. Brake fluid can also
(Continued)
7
MAINTAINING YOUR VEHICLE 359

WARNING!(Continued)
damage painted and vinyl surfaces, care should be
taken to avoid its contact with these surfaces.
• Do not allow petroleum based fluid to contaminate
the brake fluid. Brake seal components could be
damaged, causing partial or complete brake failure.
This could result in an accident.
Change Brake Fluid
Brake fluid will tend to absorb moisture from the atmo-
sphere over time. If the fluid becomes contaminated with
water, brake performance will deteriorate. Therefore, the
brake fluid must be changed at the intervals specified in
the “Maintenance Schedule.” Refer to “Maintenance
Schedule” for further information. See your authorized
dealer for service.
Manual Transmission
Transmission Fluid Level Check
Check the fluid in the transmission when performing
other underbody services.
Check the fluid level by removing the fill plug located on
the left side of the transmission. The fluid level should be
approximately 1/4 in (6.4 mm) below the bottom of the
fill hole. Add fluid, if necessary, to maintain the proper
level. Refer to “Fluids, Lubricants, And Genuine Parts” in
“Maintaining Your Vehicle” for further information.
NOTE: DO NOT overfill transmission, damage can
occur.
360 MAINTAINING YOUR VEHICLE

CAUTION!
Using a transmission fluid other than the manufac-
turer’s recommended fluid may cause deterioration
in transmission shift quality and/or damage to the
transmission. Refer to “Fluids, Lubricants, And
Genuine Parts” in this section for fluid specifica-
tions.
Change Transmission Fluid
Refer to “Maintenance Schedule” for the proper mainte-
nance intervals. If contaminated with water, change the
fluid immediately. See your authorized dealer for service.
Hydraulic Clutch
Master Cylinder — Clutch Fluid Level Check
The clutch hydraulic system is fed by a segregated
volume of fluid within the brake system master cylinder
reservoir. In the event of leakage or wear, use only themanufacturer’s recommended brake fluid. Refer to “Flu-
ids, Lubricants, And Genuine Parts” in “Maintaining
Your Vehicle” for further information.
Rear Axle
Axle Lubricant Level Check
Check the exterior of the axle for evidence of gear oil
leakage every 12 months or 6,000 miles (10 000 km). This
check should be made with the vehicle level and on the
ground or raised on an axle and wheel type hoist. The
axle lubricant level should be between the bottom of the
filler plug and a point approximately 3/8 inch (9.5 mm)
below the filler plug. If adding axle lubricant, use only
the manufacturer’s recommended axle lubricant. Refer to
“Fluids, Lubricants, And Genuine Parts” in “Maintaining
Your Vehicle” for further information.
7
MAINTAINING YOUR VEHICLE 361

Chassis
ComponentFluid, Lubricant, or Genuine Part
Transmission We recommend you use MOPAR ATF+4 Automatic
Transmission Fluid.
Rear Axle We recommend you use Castrol SAF-XJ/SAE 75W-140
Synthetic Gear and Axle Lubricant.
Brake/Clutch Master Cylinder We recommend you use MOPAR Brake and Clutch
Fluid DOT 4 Motor Vehicle.
Power Steering Reservoir We recommend you use MOPAR Power Steering Fluid +
4, MOPAR or ATF+4 Automatic Transmission Fluid.
7
MAINTAINING YOUR VEHICLE 387

•Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering, and transmission, and
add as needed.
• Check all lights and all other electrical items for correct
operation.
At Each Oil Change
• Change the engine oil filter.
• Inspect the exhaust system.
NOTE: Also, inspect the exhaust system if you notice a
change in the sound of the exhaust system, or if the
exhaust fumes can be detected inside the vehicle. •
Inspect the brake hoses.
• Inspect the suspension components.
• Lubricate door hinges and check springs.
• Check the engine coolant level, hoses, and clamps.
• Check power steering fluid level.
8
MAINTENANCE SCHEDULES 391

MAINTENANCE CHART
Miles:6,000
12,000
18,000
24,000
30,000
36,000
42,000
48,000
54,000
60,000
66,000
72,000
78,000
84,000
90,000
96,000
102,000
108,000 114,000
120,000
126,000
132,000
138,000
144,000
150,000
Or Months: 6 12 18 24 30 36 42 48 54 60 66 72 78 84 90 96 102 108 114 120 126 132 138 144 150
Or Kilometers:
10,000
20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000 110,000
120,000
130,000
140,000
150,000
160,000
170,000
180,000
190,000
200,000
210,000
220,000
230,000
240,000
250,000
Change the engine oil and
engine oil filter. XXXXXXXXXXXXXXXXXXXXXXXXX
Rotate the tires, rotate at the
first sign of irregular wear, even
if it occurs before scheduled
maintenance. XXXXXXXXXXXXXXXXXXXXXXXXX
Inspect the brake linings; re-
place if necessary. XXXXXXXXXXXX
Inspect the exhaust system. XXXXXXXXXXXX
Change Brake Fluid XXXXXX
Adjust the parking brake on
vehicles equipped with four
wheel disc brakes. XXXXX
392 MAINTENANCE SCHEDULES

About Your Brakes....................... .263
ABS (Anti-Lock Brake System) ................265
Adding Engine Coolant (Antifreeze) ............354
Adding Fuel ............................ .307
Adding Washer Fluid ..................... .349
Additives, Fuel .......................... .304
Adjust Forward ............................. .103
Rearward ............................ .103
Adjustable Pedals .........................118
AirBag.............................. .47, 48
Advance Front Air Bag .................48, 49
Air Bag Operation .......................51
Air Bag Warning Light ....................69
Enhanced Accident Response ................68
Event Data Recorder (EDR) .................72
FrontAirBag ........................47, 48
If A Deployment Occurs ...................67
Knee Impact Bolsters .....................64 Maintaining Your Air Bag System
............71
Transporting Pets ........................84
Air Bag Deployment ........................47
Air Bag Light ...................... .69, 88, 153
Air Bag Maintenance .......................71
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .343
Air Conditioner Maintenance .................346
Air Conditioning, Operating Tips ..............220
Air Conditioning Refrigerant ..............346, 347
Air Conditioning System ....................346
Air Pressure, Tires ........................ .284
Alarm (Security Alarm) .....................156
Alarm System (Security Alarm) ................18
Alterations/Modifications, Vehicle ...............7
Antenna ............................... .212
Antifreeze (Engine Coolant) ...............353, 384
Capacities ........................... .384
Disposal ............................. .356
Anti-Lock Brake System (ABS) ................265
408 INDEX

Anti-Lock Warning Light....................267
Appearance Care ........................ .362
Auto Down Power Windows ..................30
Automatic Door Locks ....................28, 29
Automatic Headlights ..................... .109
Auto Unlock, Doors ........................29
Auto Up Power Windows ....................31
Auxiliary Electrical Outlet (Power Outlet) ........135
Auxiliary Power Outlet .....................135
Battery ............................ .157, 344
Charging System Light ...................157
Emergency Starting ..................... .327
Jump Starting ......................... .327
Keyless Transmitter Replacement (RKE) ........24
Location ............................. .344
Remote Battery Replacement ................24
Saving Feature (Protection) ................345
Storing Vehicle ........................ .345Transmitter Battery Replacement
.............24
Belts, Seat ...............................88
Body Mechanism Lubrication .................348
B-Pillar Location ......................... .278
Brake Control System, Electronic ..............264
Brake, Parking .......................... .261
Brake System ........................ .263, 358
Anti-Lock (ABS) .....................263, 265
Fluid Check ....................... .358, 387
Master Cylinder ....................... .358
Warning Light ........................ .154
Break-In Recommendations, New Vehicle ........263
Brightness, Interior Lights ...................113
Bulb Replacement ........................ .383
Bulbs, Light .......................... .89, 382
Camera, Rear ........................... .124
Capacities, Antifreeze (Engine Coolant) ..........384
Capacities, Fluid ......................... .384
10
INDEX 409

FlashersHazard Warning ....................... .314
Turn Signal ..................... .89, 111, 171
Flash-To-Pass ............................112
Flooded Engine Starting ....................246
Fluid Capacities ......................... .384
Fluid Leaks ..............................89
Fluid Level Checks Brake ........................... .358, 387
Capacities ........................... .384
Clutch Fluid .......................... .361
Cooling System ........................ .352
Engine Oil ........................... .341
Manual Transmission .................360, 387
Power Steering ..................... .260, 387
Fluids, Lubricants And Genuine Parts ...........385
Four-Way Hazard Flasher ...................314
Freeing A Stuck Vehicle .....................331
Fuel .................................. .302Additives
............................ .304
Clean Air ............................ .303
Ethanol ............................. .303
Gasoline ............................. .302
Light ............................... .169
Materials Added ....................... .304
Methanol ............................ .303
Octane Rating ..................... .302, 385
Requirements ...................... .302, 384
Tank Capacity ......................... .384
Fuses ................................. .370
Garage Door Opener (HomeLink) ..........126, 133
Gasoline, Clean Air ....................... .303
Gasoline (Fuel) .......................... .302
Gasoline, Reformulated .....................303
General Information ...................... .212
Glass Cleaning .......................... .366
10
INDEX 413

Remote Battery Replacement................24
Key-In Reminder ..........................13
Keyless Entry System .....................11,21
Keyless Go ...............................11
Key, Replacement ..........................16
Key, Sentry (Immobilizer) ....................15
Lane Change And Turn Signals ................111
Lap/Shoulder Belts .........................37
Latches .................................89
Hood ............................... .105
Lead Free Gasoline ....................... .302
Leaks, Fluid ..............................89
Life Of Tires ............................ .292
Liftgate .................................32
Light Bulbs ..............................89
Lights .............................. .89, 108
AirBag .........................69, 88, 153
Anti-Lock ............................ .267Automatic Headlights
....................109
Brake Warning ........................ .154
Bulb Replacement ....................382, 383
Cruise .............................. .172
Daytime Running .......................110
Dimmer Switch, Headlight .............111,112
Engine Temperature Warning ...............156
Exterior ...............................89
Hazard Warning Flasher ..................314
Headlights ........................... .108
Headlights On Reminder ..................110
Headlights On With Wipers .............109, 117
Headlight Switch ...................... .108
High Beam ............................112
High Beam/Low Beam Select ...............112
Illuminated Entry ........................20
Instrument Cluster ..................... .108
Intensity Control ........................113
Interior ..............................112
10
INDEX 415