clutch DODGE VIPER SRT 2016 VX / 3.G User Guide

▫Brake System ....................... .358
▫ Manual Transmission ..................360
▫ Hydraulic Clutch .....................361
▫ Rear Axle .......................... .361
▫ Appearance Care And Protection From
Corrosion .......................... .362
 FUSES ............................. .370
▫ Power Distribution Center ...............371
 VEHICLE STORAGE ....................379
 REPLACEMENT BULBS .................382
 BULB REPLACEMENT ..................383 ▫
Front Headlamp, Front Park/Turn Signal
Lamp ............................. .383
▫ Front/Rear Side Marker Lamp ............383
▫ Taillamp, Tail/Stop Lamp ................383
▫ Rear Turn Signal Lamp .................383
▫ Backup Lamps ....................... .383
 FLUID CAPACITIES ....................384
 FLUIDS, LUBRICANTS, AND GENUINE
PARTS ............................. .385
▫ Engine ............................ .385
▫ Chassis ........................... .387
334 MAINTAINING YOUR VEHICLE

ENGINE COMPARTMENT — 8.4L
1 — Washer Fluid Reservoir6 — Brake/Clutch Fluid Reservoir
2 — Coolant Pressure Cap 7 — Engine Oil Fill
3 — Engine Oil Dipstick 8 — Power Steering Fluid Reservoir
4 — Power Distribution Center 9 — Air Cleaner Filter
5 — Remote Jump Start Positive Battery Post
7
MAINTAINING YOUR VEHICLE 335

CAUTION!
Using a transmission fluid other than the manufac-
turer’s recommended fluid may cause deterioration
in transmission shift quality and/or damage to the
transmission. Refer to “Fluids, Lubricants, And
Genuine Parts” in this section for fluid specifica-
tions.
Change Transmission Fluid
Refer to “Maintenance Schedule” for the proper mainte-
nance intervals. If contaminated with water, change the
fluid immediately. See your authorized dealer for service.
Hydraulic Clutch
Master Cylinder — Clutch Fluid Level Check
The clutch hydraulic system is fed by a segregated
volume of fluid within the brake system master cylinder
reservoir. In the event of leakage or wear, use only themanufacturer’s recommended brake fluid. Refer to “Flu-
ids, Lubricants, And Genuine Parts” in “Maintaining
Your Vehicle” for further information.
Rear Axle
Axle Lubricant Level Check
Check the exterior of the axle for evidence of gear oil
leakage every 12 months or 6,000 miles (10 000 km). This
check should be made with the vehicle level and on the
ground or raised on an axle and wheel type hoist. The
axle lubricant level should be between the bottom of the
filler plug and a point approximately 3/8 inch (9.5 mm)
below the filler plug. If adding axle lubricant, use only
the manufacturer’s recommended axle lubricant. Refer to
“Fluids, Lubricants, And Genuine Parts” in “Maintaining
Your Vehicle” for further information.
7
MAINTAINING YOUR VEHICLE 361

Cavity Relay CartridgeFuseMini-Fuse Description
12 — 25 Amp Clear— ABS/ESP Valve Feed
13 — — 20 Amp Yel- lowHorn
14 —— 10 Amp Red A/C Clutch
15 —— 10 Amp Red Diagnostic, Fuel Door, Stop Switch
16 —— 15 Amp Blue KIN, RF Hub
17 —— 25 Amp cir-
cuit breakerPower Seats
18 —30 Amp Pink — Driver Door Mod
19 —30 Amp Pink — Passenger Door Mod
20 —30 Amp Pink — Rear Window Defroster
21 —20 Amp Blue — Wiper
22 —Jumper Black — B+ Jumper
7
MAINTAINING YOUR VEHICLE 373

Cavity Relay CartridgeFuseMini-Fuse Description
48 — — 10 Amp Red SCCM
49 — — 25 Amp ClearAmplifier
50 HC Micro — — Rad Fan
51 HC Micro — — Rad Fan Relay SER/PAR
52 HC Micro — — Starter Relay
53 HC Micro — — Rear Window Defroster Relay
54 HC Relay — — Rad Fan Relay High
55 HC Micro — — Wiper ON/OFF
56 HC Micro — — Wiper LO/HI
57 G8VA — — Horn Relay
58 G8VA — — A/C Clutch Relay
59 HC Micro — — HVAC Blower
60 HC Micro — — Fuel Pump
7
MAINTAINING YOUR VEHICLE 377

Chassis
ComponentFluid, Lubricant, or Genuine Part
Transmission We recommend you use MOPAR ATF+4 Automatic
Transmission Fluid.
Rear Axle We recommend you use Castrol SAF-XJ/SAE 75W-140
Synthetic Gear and Axle Lubricant.
Brake/Clutch Master Cylinder We recommend you use MOPAR Brake and Clutch
Fluid DOT 4 Motor Vehicle.
Power Steering Reservoir We recommend you use MOPAR Power Steering Fluid +
4, MOPAR or ATF+4 Automatic Transmission Fluid.
7
MAINTAINING YOUR VEHICLE 387

Caps, FillerOil (Engine) .......................... .342
Power Steering ........................ .260
Radiator (Coolant Pressure) ................355
Carbon Monoxide Warning ................87, 306
Car Washes ............................ .362
Chains, Tire ............................ .295
Chart, Tire Sizing ........................ .273
Check Engine Light (Malfunction Indicator Light) . .337
Checking Your Vehicle For Safety ...............86
Checks, Safety ............................86
Child Restraint ............................73
Child Restraints Booster Seats ...........................78
Child Restraints .........................73
Infants And Child Restraints ................76
Installing Child Restraints Using The Vehicle Seat
Belt ..................................79
Older Children And Child Restraints ..........76Using The Top Tether Anchorage
.............82
Clean Air Gasoline ....................... .303
Cleaning Wheels .............................. .363
Windshield Wiper Blades ..................348
Climate Control ......................... .212
Clutch Fluid ............................ .361
Compact Spare Tire ....................... .289
Contract, Service ......................... .401
Coolant Pressure Cap (Radiator Cap) ...........355
Cooling System .......................... .352
Adding Coolant (Antifreeze) ...............354
Coolant Capacity ...................... .384
Coolant Level ..................... .352, 356
Disposal Of Used Coolant .................356
Drain, Flush, And Refill ...................353
Inspection ........................... .356
Points To Remember .....................357
Pressure Cap ......................... .355
410 INDEX

FlashersHazard Warning ....................... .314
Turn Signal ..................... .89, 111, 171
Flash-To-Pass ............................112
Flooded Engine Starting ....................246
Fluid Capacities ......................... .384
Fluid Leaks ..............................89
Fluid Level Checks Brake ........................... .358, 387
Capacities ........................... .384
Clutch Fluid .......................... .361
Cooling System ........................ .352
Engine Oil ........................... .341
Manual Transmission .................360, 387
Power Steering ..................... .260, 387
Fluids, Lubricants And Genuine Parts ...........385
Four-Way Hazard Flasher ...................314
Freeing A Stuck Vehicle .....................331
Fuel .................................. .302Additives
............................ .304
Clean Air ............................ .303
Ethanol ............................. .303
Gasoline ............................. .302
Light ............................... .169
Materials Added ....................... .304
Methanol ............................ .303
Octane Rating ..................... .302, 385
Requirements ...................... .302, 384
Tank Capacity ......................... .384
Fuses ................................. .370
Garage Door Opener (HomeLink) ..........126, 133
Gasoline, Clean Air ....................... .303
Gasoline (Fuel) .......................... .302
Gasoline, Reformulated .....................303
General Information ...................... .212
Glass Cleaning .......................... .366
10
INDEX 413

Ground Clearance........................ .312
Hazard Driving Through Flowing, Rising, Or Shallow Stand-
ing Water ............................ .257
Hazard Warning Flasher ....................314
Headlights Automatic ........................... .109
Delay ............................... .109
High Beam/Low Beam Select Switch .........112
Lights On Reminder .....................110
On With Wipers .....................109, 117
Passing ..............................112
Switch .............................. .108
Time Delay ........................... .109
Head Restraints ......................... .105
High Beam/Low Beam Select (Dimmer) Switch ....112
Holder, Cup ............................ .139
HomeLink (Garage Door Opener) ..............126Hood Release
........................... .105
Hydraulic Clutch Fluid .....................361
Illuminated Entry ..........................20
Immobilizer (Sentry Key) ....................15
Inside Rearview Mirror ......................94
Instrument Cluster ..............149, 156, 160, 171
Instrument Panel And Controls ...............148
Instrument Panel Lens Cleaning ...............367
Interior Appearance Care ....................365
Interior Lights ............................112
Intermittent Wipers (Delay Wipers) .............114
Introduction ..............................4
Jump Starting ........................... .327
KeyFob.................................11 Programming Additional Key Fobs ...........17
Programming Additional Transmitters .........17
414 INDEX