belt FIAT 500 2012 2.G Service Manual

Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance
test. Drive belt tension should also be checked at this
time.
CAUTION!
Do not use chemical flushes in your air conditioning
system as the chemicals can damage your air condi-
tioning components. Such damage is not covered by
the New Vehicle Limited Warranty.
WARNING!
•Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause
the system to fail, requiring costly repairs. Refer to
Warranty Information Book, located on the DVD,
for further warranty information.
•The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced repairman.
Refrigerant Recovery And Recycling
R-134a air conditioning refrigerant is a hydrofluoro-
carbon (HFC) that is endorsed by the Environmental
7
MAINTAINING YOUR VEHICLE 315

Seat Belt Maintenance
Do not bleach, dye or clean the seat belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the seat belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the seat belts from the
car to wash them. Dry with a soft cloth.
Replace the seat belts if they appear frayed or worn or if
the buckles do not work properly.
Convertible Top Care – If Equipped
NOTE:Lubricate the top rails with Berulub FR 43 every
2000 cycles or if scratching noises due to dust are present.
CAUTION!
Failure to follow these cautions may cause interior
water damage, stains or mildew on the top material:
(Continued)
CAUTION! (Continued)
•Avoid high-pressure car washes, as they can dam-
age the top material. Also, increased water pres-
sure may force past the weather strips.
•Remove any standing water from the top and dry
the surface before opening it. Operating the top,
opening a door or lowering a window while the
top is wet may allow water to drip into the
vehicles interior.
•Use care when washing the vehicle, water pressure
directed at the weather strip seals may cause water
to leak into the vehicles interior.
Immediate removal of any contaminant is recommended.
Regular washing of the top will enhance its life and
appearance, and make successive cleanings easier. Do not
subject the top to excessive heat. Frequently vacuum the
top and storage compartment.
336 MAINTAINING YOUR VEHICLE

152,000 Miles (247,000 km) or
114 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏ Rotate the tires, rotate at the first sign of
irregular wear, even if it occurs before
152,000 miles (247 000 km).
❏ Flush and replace engine coolant.
❏ Replace the timing belt.
Odometer Reading Date
Repair Order #Dealer Code
Signature, Authorized Service Center
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S364 MAINTENANCE SCHEDULES

B-Pillar Location........................ 242
Battery ............................... 313
Jump Starting ....................... 293
Keyless Transmitter Replacement (RKE) ..... 20
Belts, Seat .............................. 69
Body Mechanism Lubrication ............... 316
Brake Assist System ...................... 230
Brake Fluid ............................ 349
Brake System ........................ 228,326
Anti-Lock (ABS) .................. 228,230
Master Cylinder ..................... 327
Parking ........................... 224
Warning Light ....................... 140
Brake, Parking .......................... 224
Brake/Transmission Interlock ............... 212
Brakes ............................... 326
Break-In Recommendations, New Vehicle ........ 67
Bulbs, Light ............................ 72 Capacities, Antifreeze (Engine Coolant)
........ 347
Capacities, Fluid ........................ 347
Caps, Filler Fuel .............................. 266
Oil (Engine) ........................ 311
Car Washes ............................ 331
Carbon Monoxide Warning ...............68,265
Cargo Area Features ...................... 126
CD (Compact Disc) Player ................. 161
Cellular Phone .......................... 189
Chains, Tire ............................ 253
Changing A Flat Tire ..................... 282
Chart, Tire Sizing ........................ 238
Check Engine Light
(Malfunction Indicator Light) .............138,306
Checking Your Vehicle For Safety ............. 68
Checks, Safety ........................... 68
Child Restraint ........................ 57,58
Child Restraint Tether Anchors ............... 61
10
INDEX 379

Infant Restraint.......................... 57
Information Center, Vehicle ................. 144
Instrument Cluster ....................... 133
Instrument Panel and Controls .............. 131
Instrument Panel Cover ................... 335
Instrument Panel Lens Cleaning ............. 335
Interior Appearance Care .................. 333
Interior Lighting ........................ 103
Introduction ............................. 4
Jack Location ........................... 283
Jack Operation ....................... 282,287
Jacking Instructions ...................... 287
Jump Starting .......................... 293
Key-In Reminder ......................... 14
Key, Replacement ........................ 15
Key, Sentry (Immobilizer) ................... 14
Keys .................................. 11 Lane Change and Turn Signals
.............. 134
Lane Change Assist ...................... 102
Lap/Shoulder Belts ....................... 31
Latches ................................ 72
Hood .............................. 98
Lead Free Gasoline ...................... 261
Leaks, Fluid ............................ 72
Life of Tires ............................ 252
Liftgate (Sedan) .......................... 26
Light Bulbs ............................. 72
Lights .............................. 72,100
Airbag ...................... 48,55,70,135
Anti-Lock .......................... 141
Brake Assist Warning .................. 235
Brake Warning ...................... 140
Engine Temperature Warning ............ 139
Exterior ............................ 72
Fog .............................. 134
High Beam ......................... 101
384 INDEX

High Beam Indicator.................. 134
Low Fuel .......................... 134
Malfunction Indicator (Check Engine) ...... 138
Oil Pressure ........................ 138
Park .............................. 101
Seat Belt Reminder ................... 135
Service Engine Soon (Malfunction Indicator) . 138
Tire Pressure Monitoring (TPMS) ......... 136
Traction Control ..................... 235
Turn Signal .................... 72,102,134
Voltage ............................ 135
Wait to Start ........................ 133
Warning (Instrument Cluster Description) . . . 133
Loading Vehicle Tires .............................. 242
Locks Automatic Door ...................... 24
Door .............................. 22
Power Door ......................... 23 Lubrication, Body
....................... 316
Maintenance Free Battery .................. 313
Maintenance Procedures ................... 309
Maintenance Schedule .................... 352
Maintenance, General ..................... 309
Malfunction Indicator Light (Check Engine) . . 138,307
Manual Transmission .................. 209,329
Fluid Level Check .................... 329
Frequency of Fluid Change ............. 329
Lubricant Selection ................... 329
Manual, Service ......................... 373
Master Cylinder (Brakes) .................. 327
Mirrors ................................ 80
Automatic Dimming ................... 81
Electric Powered ...................... 82
Modifications/Alterations, Vehicle ............. 7
Monitor, Tire Pressure System ............... 256
Multi-Function Control Lever ............... 100
10
INDEX 385

New Vehicle Break-In Period................ 67
Occupant Restraints ..................... 46,52
Occupant Restraints (Sedan) ...........27,44,46,50
Octane Rating, Gasoline (Fuel) .............. 261
Odometer ............................. 143
Trip .............................. 143
Oil Change Indicator ..................... 149
Oil Change Indicator, Reset ................. 149
Oil, Engine ......................... 310,347
Capacity ........................... 347
Change Interval ..................... 310
Checking .......................... 310
Disposal ........................... 312
Filter ............................. 312
Identification Logo ................... 311
Materials Added to ................... 312
Recommendation .................. 31 1,347
Synthetic .......................... 312 Viscosity
........................... 311
Onboard Diagnostic System ................ 306
Operator Manual (Owner’s Manual) ............ 4
Overheating, Engine ................... 142,271
Owner’s Manual (Operator Manual) .........4,373
Paint Care ............................. 330
Parking Brake .......................... 224
Pets .................................. 67
Placard, Tire and Loading Information ......... 242
Power Door Locks ......................... 23
Mirrors ............................ 82
Outlet (Auxiliary Electrical Outlet) ........ 121
Steering ........................... 223
Sunroof ........................... 118
Windows ........................... 24
Power Steering Fluid ..................... 349
Pregnant Women and Seat Belts .............. 40
386 INDEX

Preparation for Jacking.................... 287
Pretensioners Seat Belts ........................... 38
Radial Ply Tires ......................... 249
Radio (Sound Systems) .................... 161
Radio Operation ...................... 161,189
Radio Reception ........................ 161
Rear Liftgate (Sedan) ...................... 26
Recorder, Event Data ...................... 56
Recreational Towing ...................... 268
Refrigerant ............................ 315
Release, Hood ........................... 98
Reminder, Seat Belt ....................... 39
Remote Sound System (Radio) Controls ........ 187
Replacement Keys ........................ 15
Replacement Parts ....................... 308
Replacement Tires ....................... 252
Reporting Safety Defects ................... 372 Restraints, Child
....................... 57,62
Rotation, Tires .......................... 255
Safety Checks Inside Vehicle ................. 69
Safety Checks Outside Vehicle ............... 71
Safety Defects, Reporting .................. 372
Safety Information, Tire ................... 236
Safety Tips ............................. 68
Safety, Exhaust Gas ....................... 68
Schedule, Maintenance .................... 352
Seat Belt Maintenance .................... 336
Seat Belt Reminder ....................... 39
Seat Belts .............................. 69
And Pregnant Women .................. 40
Child Restraint ....................... 57
Front Seat .......................... 31
Inspection .......................... 69
Pretensioners ........................ 38
Rear Seat ........................... 31
10
INDEX 387

Seat Belts (Sedan)........................ 27
Seats ................................. 91
Adjustment ......................... 91
Heated ............................. 95
Selection of Oil ......................... 311
Sentry Key (Immobilizer) ................... 14
Service Assistance ....................... 369
Service Contract ......................... 371
Service Engine Soon Light
(Malfunction Indicator) .................... 138
Service Manuals ........................ 373
Shift Lever Override ...................... 298
Shift Speeds, Manual Transmission ........... 210
Shoulder Belts ........................... 31
Side Airbag ............................. 49
Signals, Turn ......................... 72,102
Slippery Surfaces, Driving On ............... 220
Snow Chains (Tire Chains) ................. 253
Spare Tire ............................. 249 Specifications
Oil ............................... 311
Speed Control (Cruise Control) ...........109,135
Speedometer ........................... 144
Sport Mode ............................ 226
Starting ............................... 207
Automatic Transmission ................ 207
Cold Weather ....................... 208
Engine Fails to Start .................. 208
Manual Transmission .................. 207
Steering Power ............................ 223
Tilt Column ........................ 108
Wheel, Tilt ......................... 108
Steering Wheel Audio Controls.............. 187
Steering Wheel Mounted Sound System Controls. . 187
Storage ............................... 342
Storage, Vehicle ...................... 201,342
Storing Your Vehicle ...................... 342
388 INDEX