air conditioning FIAT 500 2014 2.G User Guide

Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance
test. Drive belt tension should also be checked at this
time.
WARNING!
•Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause the
system to fail, requiring costly repairs. Refer to
Warranty Information Book, located on the DVD,
for further warranty information.
(Continued)
WARNING! (Continued)
•The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced technician.
CAUTION!
Do not use chemical flushes in your air conditioning
system as the chemicals can damage your air condi-
tioning components. Such damage is not covered by
the New Vehicle Limited Warranty.
Refrigerant Recovery And Recycling R134a — If
Equipped
R-134a Air Conditioning Refrigerant is a hydrofluoro-
carbon (HFC) that is endorsed by the Environmental
7
MAINTAINING YOUR VEHICLE 359

Protection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by authorized dealer or other
service facilities using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C system
PAG compressor oil, and refrigerants.
Refrigerant Recovery And Recycling HFO 1234yf
— If Equipped
HFO 1234yf Air Conditioning Refrigerant is a hydro-
fluorocarbon (HFC) that is endorsed by the Environmen-
tal Protection Agency and is an ozone-saving product
with a low GWP (Global Warming Potential). However,
the manufacturer recommends that air conditioning ser-
vice be performed by authorized dealer or other service
facilities using recovery and recycling equipment. NOTE:
Use only manufacturer approved A/C system
PAG compressor oil, and refrigerants.
A/C Air Filter
WARNING!
Do not remove the A/C air filter while the blower is
operating or personal injury may result.
The A/C air filter is located in the fresh air inlet on the
lower right of center console. Perform the following
procedure to replace the filter:
1. Remove the Torx® screw that secures the passenger side console closeout cover.
360 MAINTAINING YOUR VEHICLE

When additional engine coolant (antifreeze) is needed to
maintain the proper level, it should be added to the
coolant bottle. Do not overfill.
Points To Remember
NOTE:When the vehicle is stopped after a few miles/
kilometers of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
• Do not overfill the coolant expansion bottle. •
Check the coolant freeze point in the radiator and in
the coolant expansion bottle. If engine coolant (anti-
freeze) needs to be added, the contents of the coolant
expansion bottle must also be protected against freez-
ing.
• If frequent engine coolant (antifreeze) additions are
required, the cooling system should be pressure tested
for leaks.
• Maintain engine coolant (antifreeze) concentration at a
minimum of 50% OAT coolant (conforming to MS-
12106) and distilled water for proper corrosion protec-
tion of your engine which contains aluminum compo-
nents.
• Make sure that the coolant expansion bottle overflow
hoses are not kinked or obstructed.
• Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean.
374 MAINTAINING YOUR VEHICLE

CavityMaxi Fuse Mini Fuse Description
F11 10 Amp Red Powertrain (Multiair – If Equipped)
F14 5 Amp Tan High Beam (Shutter)
F15 15 Amp Blue Cigar Lighter
F16 7.5 Amp Brown Transmission
F17 25 Amp White Powertrain (Multiair – If Equipped)
F17 15 Amp Blue Powertrain
F18 15 Amp Blue Powertrain
F18 5 Amp Tan Powertrain (Multiair – If Equipped)
F19 7.5 Amp Brown Air Conditioning
F20 15 Amp Blue Heated Seats – If Equipped
F21 15 Amp Blue Fuel Pump
F22 20 Amp Yellow Powertrain
F23 20 Amp Yellow Anti-Lock Brake Valves
F24 7.5 Amp Brown Stability Control System
F30 15 Amp Blue Fog Lamps
7
MAINTAINING YOUR VEHICLE 393

CavityMaxi Fuse Mini Fuse Description
F82 30 Amp Green Sunroof/Convertible Top
F83 20 Amp Yellow Cooling Pump – If Equipped
F84 10 Amp Red Transmission
F85 30 Amp Green (ATO) Rear Defroster
F87 5 Amp Tan Rear Defroster
F90 5 Amp Tan Heated Mirrors – If Equipped
VEHICLE STORAGE
If you are leaving your vehicle dormant for more than 21
days, you may want to take these steps to protect your
battery.
•Disconnect the negative cable from the battery. •
Anytime you store your vehicle, or keep it out of
service (e.g., vacation) for two weeks or more, run the
air conditioning system at idle for about five minutes
in the fresh air and high blower setting. This will
ensure adequate system lubrication to minimize the
possibility of compressor damage when the system is
started again.
394 MAINTAINING YOUR VEHICLE

Adding Engine Coolant (Antifreeze)............371
Adding Fuel ............................ .298
Adding Washer Fluid ..................... .366
Additives, Fuel .......................... .296
Airbag ..................................39
Airbag Deployment ........................52
Airbag Light .............................47
Airbag Maintenance ........................53
Airbag, Side ..............................42
Airbag, Window (Side Curtain) ................43
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .356
Air Conditioner Maintenance .................359
Air Conditioning ......................... .207
Air Conditioning Controls ...................207
Air Conditioning Filter .....................360
Air Conditioning Refrigerant .................359
Air Conditioning System ....................207
Air Pressure, Tires ........................ .270
Alterations/Modifications, Vehicle ...............8Antifreeze (Engine Coolant)
..................370
Capacities ........................... .399
Disposal ............................. .373
Anti-Lock Brake System (ABS) ................249
Anti-Lock Warning Light ....................154
Appearance Care ........................ .380
Automatic Dimming Mirror ...................90
Automatic Oil Change Indicator ...............404
Automatic Temperature Control (ATC) ..........209
Automatic Transaxle ........................11
Automatic Transmission ....................229
Adding Fluid ......................... .379
Fluid and Filter Changes ..................380
Fluid Change ......................... .380
Fluid Level Check ...................... .379
Fluid Type ........................... .401
Gear Ranges .......................... .233
Special Additives ...................... .379
422 INDEX

Exhaust Gas Caution.....................78
Fails to Start .......................... .225
Flooded, Starting ...................... .225
Fuel Requirements ..................... .293
Oil................................. .353
Oil Filler Cap ......................... .355
Oil Selection .......................... .354
Oil Synthetic ......................... .356
Overheating .......................... .305
Starting ............................. .223
Temperature Gauge ..................... .155
Enhanced Accident Response Feature ............50
Euro Twin Clutch Transmission Fluid Type ........................... .378
Event Data Recorder ........................55
Exhaust Gas Caution ........................26
Exhaust System ...........................78
Exterior Lights ............................82 Filler Location Fuel
....................... .157
Filters Air Cleaner .......................... .356
Air Conditioning ...................... .360
Engine Fuel .......................... .400
Engine Oil ........................... .356
Engine Oil Disposal .....................356
Flashers Turn Signal ............................82
Flooded Engine Starting ....................225
Fluid, Brake ............................ .401
Fluid Capacities ......................... .399
Fluid Leaks ..............................82
Fluid Level Checks Automatic Transmission ..................379
Fluids, Lubricants and Genuine Parts ...........400
Fog Lights ..............................115
Freeing A Stuck Vehicle .....................336
Fuel .................................. .293
426 INDEX