belt FIAT 500 2014 2.G Workshop Manual

STARTING PROCEDURES
Before starting your vehicle, adjust your seat, adjust both
inside and outside mirrors, and fasten your seat belts.
WARNING!
•Never leave children alone in a vehicle, or with
access to an unlocked vehicle.
• Allowing children to be in a vehicle unattended is
dangerous for a number of reasons. A child or
others could be seriously or fatally injured. Chil-
dren should be warned not to touch the parking
brake, brake pedal or the shift lever.
• Do not leave the Key Fob in or near the vehicle (or
in a location accessible to children). A child could
operate power windows, other controls, or move
the vehicle.
Manual Transmission — If Equipped
Apply the parking brake, place the shift lever in NEU-
TRAL, and press the clutch pedal before starting the
vehicle. This vehicle is equipped with a clutch interlock-
ing ignition system. It will not start unless the clutch
pedal is pressed to the floor.
Automatic Transmission — If Equipped
The shift lever must be in the PARK or NEUTRAL
position before you can start the engine. Depress the
brake pedal before shifting to any driving gear.
NOTE: You must press the brake pedal before shifting
out of PARK.
Normal Starting
NOTE: Normal starting of either a cold or a warm
engine is obtained without pumping or pressing the
accelerator pedal.
5
STARTING AND OPERATING 223

Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance
test. Drive belt tension should also be checked at this
time.
WARNING!
•Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause the
system to fail, requiring costly repairs. Refer to
Warranty Information Book, located on the DVD,
for further warranty information.
(Continued)
WARNING! (Continued)
•The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced technician.
CAUTION!
Do not use chemical flushes in your air conditioning
system as the chemicals can damage your air condi-
tioning components. Such damage is not covered by
the New Vehicle Limited Warranty.
Refrigerant Recovery And Recycling R134a — If
Equipped
R-134a Air Conditioning Refrigerant is a hydrofluoro-
carbon (HFC) that is endorsed by the Environmental
7
MAINTAINING YOUR VEHICLE 359

Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the car to
wash them. Dry with a soft cloth.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
WARNING!
A frayed or torn belt could rip apart in a collision and
leave you with no protection. Inspect the belt system
periodically, checking for cuts, frays, or loose parts.
Damaged parts must be replaced immediately. Do
not disassemble or modify the system. Seat belt
assemblies must be replaced after a collision if they
have been damaged (i.e., bent retractor, torn web-
bing, etc.).
Convertible Top Care – If Equipped
NOTE:Lubricate the top rails with Berulub FR 43 every
2000 cycles or if scratching noises due to dust are present.
386 MAINTAINING YOUR VEHICLE

Mileage or time passed
(whichever comes first)
20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000
110,000
120,000
130,000
140,000
150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:
32,000
48,000
64,000
80,000
96,000
112,000
128,000
144,000
160,000
176,000
192,000
208,000
224,000
240,000
Flush and replace the engine
coolant at 10 years or 150,000
miles (240,000 km) whichever
comes first. XX
Inspect and replace PCV valve if
necessary. X
Replace the timing belt. X
** The spark plug change interval is mileage based only,
yearly intervals do not apply.
408 MAINTENANCE SCHEDULES

Autostick.............................. .238
Battery ................................ .357
Jump Starting ......................... .332
Keyless Transmitter Replacement (RKE) ........18
Belts, Seat ...............................79
Body Mechanism Lubrication .................363
B-Pillar Location ......................... .264
Brake Assist System ...................... .250
Brake Fluid ............................ .401
Brake, Parking .......................... .244
Brakes ................................ .375
Brake System ........................... .248
Anti-Lock (ABS) ....................... .249
Master Cylinder ....................... .375
Parking ............................. .244
Warning Light ........................ .153
Brake/Transmission Interlock .................231
Bulb Replacement ........................ .395Bulbs, Light
..............................82
Capacities, Antifreeze (Engine Coolant) ..........399
Capacities, Fluid ......................... .399
Caps, Filler Fuel ................................ .298
Oil (Engine) .......................... .355
Carbon Monoxide Warning ...................78
Cargo Area Features ...................... .138
Car Washes ............................ .381
CD (Compact Disc) Player ...................177
Cellular Phone .......................... .206
Chains, Tire ............................ .281
Change Oil Indicator ...................... .404
Changing A Flat Tire ...................... .319
Chart, Tire Sizing ........................ .259
Check Engine Light (Malfunction Indicator Light) . .151
Checking Your Vehicle For Safety ...............78
Checks, Safety ............................78
10
INDEX 423

Child Restraint............................56
Child Restraints Child Seat Installation .....................73
Install A LATCH-compatible Child Restraint .....68
Installing Child Restraints Using The Vehicle Seat
Belt ..................................71
Lower Anchors And Tethers For Children .......64
Clean Air Gasoline ....................... .294
Cleaning Wheels .............................. .382
Windshield Wiper Blades ..................363
Climate Control ......................... .206
Clutch ................................ .375
Clutch Fluid ............................ .375
Compact Disc (CD) Maintenance ..............205
Compact Spare Tire ....................... .275
Connector UCI................................ .203
Universal Consumer Interface (UCI) ..........203Contract, Service
......................... .414
Convertible Top Maintenance .................386
Coolant (Antifreeze) ...................... .399
Cooling System .......................... .369
Adding Coolant (Antifreeze) ...............371
Coolant Level ......................... .369
Disposal of Used Coolant .................373
Drain, Flush, and Refill ...................369
Inspection ........................... .373
Points to Remember .....................372
Pressure Cap ......................... .372
Selection of Coolant (Antifreeze) .............370
Corrosion Protection ...................... .380
Cruise Light ............................ .148
Cupholders ............................ .136
Customer Assistance ...................... .412
Data Recorder, Event .......................55
Daytime Running Lights ....................112
424 INDEX

Passing..............................112
Switch ...............................112
Heated Mirrors ............................93
Heated Seats ............................ .105
Heater ................................ .207
Hill Start Assist .......................... .251
Holder, Cup ............................ .136
Hood Release ........................... .109
Ignition .................................11
Key..................................11
Ignition Key Removal .......................11
Immobilizer (Sentry Key) ....................13
Infant Restraint ...........................56
Information Center, Vehicle ..................158
Instrument Cluster ....................... .146
Instrument Panel and Controls ................143
Instrument Panel Cover .....................385
Instrument Panel Lens Cleaning ...............385Interior Appearance Care
....................383
Interior Lighting ..........................114
Introduction ..............................4
Jacking Instructions ....................... .324
Jack Location ........................... .320
Jack Operation .......................... .319
Jump Starting ........................... .332
Key-In Reminder ..........................13
Key, Replacement ..........................14
Keys ...................................11
Key, Sentry (Immobilizer) ....................13
Lane Change and Turn Signals ................147
Lane Change Assist ........................113
Lap/Shoulder Belts .........................29
Latches .................................82
Hood ............................... .109
428 INDEX

Lead Free Gasoline....................... .293
Leaks, Fluid ..............................82
Life of Tires ............................ .278
Liftgate (Sedan) ...........................25
Light Bulbs ..............................82
Lights ..................................82
Airbag ................................47
Anti-Lock ............................ .154
Brake Assist Warning ....................256
Brake Warning ........................ .153
Bulb Replacement ...................... .396
Engine Temperature Warning ...............152
Exterior ...............................82
Fog ................................ .147
High Beam ............................112
High Beam Indicator .....................147
Low Fuel ............................ .147
Malfunction Indicator (Check Engine) .........151
Oil Pressure .......................... .151Park
.................................112
Passing ..............................112
Seat Belt Reminder ..................... .148
Service .............................. .396
Service Engine Soon (Malfunction Indicator) . . . .151
Tire Pressure Monitoring (TPMS) ............149
Traction Control ....................... .256
Turn Signal ............................82
Voltage ............................. .148
Wait to Start .......................... .146
Warning (Instrument Cluster Description) ......146
Loading Vehicle Tires ............................... .264
Locks Automatic Door .........................23
Door .................................20
Power Door ............................22
Lubrication, Body ........................ .363
10
INDEX 429

Filter Disposal........................ .356
Identification Logo ..................... .354
Materials Added to ..................... .356
Recommendation ...................... .354
Synthetic ............................ .356
Viscosity ............................ .355
Oil Filter, Selection ....................... .356
Onboard Diagnostic System ..................349
Operating Precautions ..................... .349
Operator Manual (Owner’s Manual) .............5
Overheating, Engine ...................... .155
Owner’s Manual (Operator Manual) .............5
Paint Care ............................. .380
Parking Brake ........................... .244
Passing Light ............................112
Pets ....................................77
Placard, Tire and Loading Information ..........265Power
Door Locks ............................22
Mirrors ...............................91
Outlet (Auxiliary Electrical Outlet) ...........133
Steering ............................. .243
Sunroof ............................. .130
Windows ..............................23
Power Steering Fluid ...................... .401
Pregnant Women and Seat Belts ................39
Preparation for Jacking .....................323
Pretensioners Seat Belts ..............................37
Radial Ply Tires ......................... .272
Radio Operation ......................... .177
Radio Reception ......................... .177
Radio (Sound Systems) .....................177
Rear Liftgate (Sedan) .......................25
Rear Window Features .....................139
10
INDEX 431

Recorder, Event Data.......................55
Recreational Towing ...................... .300
Reformulated Gasoline .....................294
Refrigerant ............................. .359
Release, Hood ........................... .109
Reminder, Seat Belt .........................37
Remote Keyless Entry (RKE) FCC General Information ..................20
Power Convertible Top Function .............16
Remote Sound System (Radio) Controls .........204
Replacement Bulbs ....................... .395
Replacement Keys .........................14
Replacement Parts ........................ .351
Replacement Tires ........................ .279
Reporting Safety Defects ....................415
Restraints, Child ...........................56
Rotation, Tires .......................... .282
Safety Checks Inside Vehicle ..................79Safety Checks Outside Vehicle
.................82
Safety Defects, Reporting ....................415
Safety, Exhaust Gas .........................78
Safety Information, Tire .....................257
Safety Tips ...............................78
Schedule, Maintenance .....................404
Seat Belt Maintenance ..................... .386
Seat Belt Reminder .........................37
Seat Belts ................................79
And Pregnant Women .....................39
Child Restraint ..........................56
Extender ..............................38
Front Seat .............................29
Inspection .............................79
Pretensioners ...........................37
Rear Seat ..............................29
Untwisting Procedure .....................34
Seat Belts (Sedan) ..........................26
Seats ................................. .101
432 INDEX