maintenance schedule FIAT 500 ABARTH 2015 2.G User Guide

MAINTENANCE SCHEDULES
CONTENTS
!MAINTENANCE SCHEDULE.............392▫Maintenance Chart.....................394
8

MAINTENANCE SCHEDULE
Your vehicle is equipped with an automatic oil change
indicator system. The oil change indicator system will
remind you that it is time to take your vehicle in for
scheduled maintenance.
Based on engine operation conditions, the oil change
indicator message will illuminate. This means that ser-
vice is required for your vehicle. Operating conditions
such as frequent short-trips, trailer tow, extremely hot or
cold ambient temperatures, and E85 fuel usage will
influence when the “Change Oil” message is displayed.
Severe operating conditions can cause the change oil
message to illuminate as early as 3,500 miles (5,600 km)
since last reset. Have your vehicle serviced as soon as
possible, within the next 500 miles (805 km).
Your authorized dealer will reset the oil change indicator
message after completing the scheduled oil change. If a
scheduled oil change is performed by someone other
than your authorized dealer, the message can be reset by
referring to the steps described under “Electronic Vehicle
Information Center (EVIC)” in “Understanding Your
Instrument Panel” for further information.
NOTE:Under no circumstances should oil change inter-
vals exceed 10,000 miles (16,000 km) or twelve months,
whichever comes first.
Severe Duty All Models
Change Engine Oil at 4000 miles (6,500 km) if the vehicle
is operated in a dusty and off road environment. This
type of vehicle use is considered Severe Duty.
392 MAINTENANCE SCHEDULES

Once A Month Or Before A Long Trip:
Check engine oil level
Check windshield washer fluid level
Check the tire inflation pressures and look for unusual
wear or damage
Check the fluid levels of the coolant reservoir and brake
master cylinder as needed
Check function of all interior and exterior lights
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for required maintenance.
At Every Oil Change Interval As Indicated By Oil
Change Indicator System:
Change oil and filter.
Rotate the tires.Rotate at the first sign of irregular
wear, even if it occurs before the oil indicator sys-
tem turns on.
Inspect battery and clean and tighten terminals as
required.
Inspect brake pads, shoes, rotors, drums, hoses and
park brake.
Inspect engine cooling system protection and hoses.
Inspect exhaust system.
Inspect engine air cleaner if using in dusty or off-road
conditions.
8
MAINTENANCE SCHEDULES 393

Maintenance Chart
Mileage or time passed (whichever comes first)20,00030,00040,00050,00060,00070,00080,00090,000100,000110,000120,000130,000140,000150,000
Or Years:2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:32,00048,00064,00080,00096,000112,000128,000144,000160,000176,000192,000208,000224,000240,000
Additional Inspections
Inspect the CV joints.XXXXX
Inspect front suspension, tie rod ends, boot seals,and replace if necessary.XXX X X X X
Inspect brake linings, replace if needed.XXX X X X X
Inspect parking brake function, adjust as necessary.XXX X X X X
Additional Maintenance
Replace cabin/air conditioning filter.XXX X X X X
Clean and lube sun roof tracks.XX XXX X X X X X X X X X
394 MAINTENANCE SCHEDULES

Mileage or time passed (whichever comes first)20,00030,00040,00050,00060,00070,00080,00090,000100,000110,000120,000130,000140,000150,000
Or Years:2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:32,00048,00064,00080,00096,000112,000128,000144,000160,000176,000192,000208,000224,000240,000
Replace engine air filter.XXXXX
Replace the spark plugs. **XXXXX
Flush and replace the engine coolant at 10 yearsor 150,000 miles (240,000 km) whichever comesfirst.XX
Inspect and replace PCV valve if necessary.X
Replace the timing belt.X
** The spark plug change interval is mileage based only,
yearly intervals do not apply.
8
MAINTENANCE SCHEDULES 395

WARNING!
•You can be badly injured working on or around a
motor vehicle. Do only service work for which you
have the knowledge and the right equipment. If
you have any doubt about your ability to perform
a service job, take your vehicle to a competent
mechanic.
•Failure to properly inspect and maintain your vehicle
could result in a component malfunction and effect
vehicle handling and performance. This could cause
an accident.
396 MAINTENANCE SCHEDULES

Maintenance Free Battery....................347
Maintenance, General......................343
Maintenance Procedures....................343
Maintenance Schedule......................392
Malfunction Indicator Light (Check Engine).......341
Manual, Service..........................402
Manual Transmission......................230
Fluid Level Check.......................367
Frequency of Fluid Change................367
Lubricant Selection......................367
Master Cylinder (Brakes)....................364
Media Hub..............................99
Mirrors.................................89
Automatic Dimming......................90
Electric Powered.........................91
Heated...............................93
Modifications/Alterations, Vehicle...............8
Monitor, Tire Pressure System................286
Multi-Function Control Lever.................109
New Vehicle Break-In Period..................76
Occupant Restraints........................26
Octane Rating, Gasoline (Fuel)................295
Odometer...............................148
Tr i p . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..148
Oil Change Indicator.......................165
Oil Change Indicator, Reset..................165
Oil, Engine..............................344
Capacity.............................387
Change Interval........................345
Checking.............................344
Disposal..............................346
Filter................................346
Filter Disposal.........................346
Recommendation.......................345
Viscosity.............................345
Oil Filter, Selection........................346
Onboard Diagnostic System..................340
416 INDEX

Replacement Keys.........................14
Replacement Parts.........................342
Replacement Tires.........................283
Reporting Safety Defects....................401
Restraints, Child...........................56
Restraints, Occupant........................26
Rotation, Tires...........................285
Safety Checks Inside Vehicle..................79
Safety Checks Outside Vehicle.................81
Safety Defects, Reporting....................401
Safety, Exhaust Gas.........................78
Safety Information, Tire.....................261
Safety Tips...............................77
Schedule, Maintenance.....................392
Seat Belt
Disengage The Automatic Locking Mode.......38
Energy Management Feature................36
Engage The Automatic Locking Mode.........38
Lap/Shoulder Belts.......................29
Lap/Shoulder Belt Untwisting...............34
Pregnant Women........................35
Seat Belt Extender.......................34
Seat Belt Pretensioner.....................35
Seat Belt System.........................26
Seat Belt Maintenance......................375
Seat Belts................................28
Child Restraint..........................56
Extender..............................34
Front Seat.............................28
Inspection.............................79
Operating Instructions....................32
Pregnant Women........................35
Pretensioners...........................35
Rear Seat..............................29
Reminder.............................148
Untwisting Procedure.....................34
418 INDEX