warning light FIAT 500 ABARTH 2015 2.G Service Manual

ADDING FUEL
Fuel Filler Cap (Gas Cap)
The gas cap is located on the passenger side of the
vehicle. If the gas cap is lost or damaged, be sure the
replacement cap is the correct one for this vehicle.
CAUTION!
•Damage to the fuel system or emission control
system could result from using an improper fuel
filler cap. A poorly fitting cap could let impurities
into the fuel system. Also, a poorly fitting aftermar-
ket cap can cause the “Malfunction Indicator Light
(MIL)” to illuminate, due to fuel vapors escaping
from the system.
•To avoid fuel spillage and overfilling, do not “top
off” the fuel tank after filling.
WARNING!
•Never have any smoking materials lit in or near the
vehicle when the gas cap is removed or the tank is
being filled.
(Continued)Fuel Filler Cap
300 STARTING AND OPERATING

WARNING!
To avoid the risk of forcing the vehicle off the jack,
do not fully tighten the wheel bolts until the vehicle
has been lowered. Failure to follow this warning may
result in personal injury.
7. Install the wheel and wheel bolts with the cone shaped
end of the bolts toward the wheel. Lightly tighten the
bolts. To avoid the risk of forcing the vehicle off the
jack, do not tighten the bolts fully until the vehicle has
been lowered.
8. Lower the vehicle by turning the jack screw to the left.
9. Finish tightening the bolts. Push down on the wrench
while tightening the wheel bolts. Alternate bolts until
each bolt has been tightened twice. Refer to “Torque
Specifications” in this section for proper lug bolt
torque. If you doubt that you have tightened the bolts
correctly, have them checked with a torque wrench by
your authorized dealer or service station.
10. Disassemble the jack and tools and place them in the
bag. Stow it under the driver’s seat and secure the
bag to the floor with the straps attached to the floor
of the vehicle.
11. Check the tire pressure as soon as possible. Correct
the tire pressure as required.
JUMP-STARTING PROCEDURE
If your vehicle has a discharged battery, it can be jump-
started using a set of jumper cables and a battery in
another vehicle or by using a portable battery booster
pack. Jump-starting can be dangerous if done improperly
so please follow the procedures in this section carefully.
6
WHAT TO DO IN EMERGENCIES 327

•If frequent engine coolant (antifreeze) additions are
required, the cooling system should be pressure tested
for leaks.
•Maintain engine coolant (antifreeze) concentration at a
minimum of 50% OAT coolant (conforming to
MS.90032) and distilled water for proper corrosion
protection of your engine which contains aluminum
components.
•Make sure that the coolant expansion bottle overflow
hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean.
•Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install ONLY
the correct type thermostat. Other designs may result in
unsatisfactory engine coolant (antifreeze) performance,
poor gas mileage, and increased emissions.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
WARNING!
Riding the brakes can lead to brake failure and
possibly a collision. Driving with your foot resting or
riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. Riding the brakes may also
reduce braking capacity in an emergency.
Brake Master Cylinder
The fluid level in the master cylinder should be checked
when performing under hood services, or immediately if
the “Brake Warning Light” is on.
364 MAINTAINING YOUR VEHICLE

Interior Care
Use MOPAR® Total Clean to clean fabric upholstery and
carpeting.
Use MOPAR® Total Clean to clean vinyl upholstery.
MOPAR® Total Clean is specifically recommended for
leather upholstery.
Your leather upholstery can be best preserved by regular
cleaning with a damp soft cloth. Small particles of dirt
can act as an abrasive and damage the leather upholstery
and should be removed promptly with a damp cloth.
Stubborn soils can be removed easily with a soft cloth
and MOPAR® Total Clean. Care should be taken to avoid
soaking your leather upholstery with any liquid. Please
do not use polishes, oils, cleaning fluids, solvents, deter-
gents, or ammonia-based cleaners to clean your leather
upholstery. Application of a leather conditioner is not
required to maintain the original condition.
WARNING!
Do not use volatile solvents for cleaning purposes.
Many are potentially flammable, and if used in
closed areas they may cause respiratory harm.
CAUTION!
Do not use Alcohol and Alcohol-based and/or Keton
based cleaning products to clean leather seats, as
damage to the seat may result.
Cleaning Headlights
Your vehicle has plastic headlights that are lighter and
less susceptible to stone breakage than glass headlights.
Plastic is not as scratch resistant as glass and therefore
different lens cleaning procedures must be followed.
7
MAINTAINING YOUR VEHICLE 373

training to assure that you are absolutely delighted with
the ownership experience. You will be pleased with their
sincere efforts to resolve any warranty issues or related
concerns.
WARNING!
Engine exhaust (internal combustion engines only),
some of its constituents, and certain vehicle compo-
nents contain, or emit, chemicals known to the State
of California to cause cancer and birth defects, or
other reproductive harm. In addition, certain fluids
contained in vehicles and certain products of compo-
nent wear contain, or emit, chemicals known to the
State of California to cause cancer and birth defects,
or other reproductive harm.
WARRANTY INFORMATION
See the Warranty Information Booklet, located on the DVD,
for the terms and provisions of FIAT Group Automobiles
warranties applicable to this vehicle and market.
REPORTING SAFETY DEFECTS
In The 50 United States And Washington, D.C.
If you believe that your vehicle has a defect that could
cause a crash or cause injury or death, you should
immediately inform the National Highway Traffic Safety
Administration (NHTSA) in addition to notifying the
manufacturer.
If NHTSA receives similar complaints, it may open an
investigation, and if it finds that a safety defect exists in
a group of vehicles, it may order a recall and remedy
9
IF YOU NEED CONSUMER ASSISTANCE 401

Adding Engine Coolant (Antifreeze)............360
Adding Fuel.............................300
Adding Washer Fluid......................355
Additives, Fuel...........................298
Air bag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39
Air Bag
Air bag Operation.......................42
Air Bag Warning Light....................52
Driver Knee Air Bag......................44
Enhanced Accident Response................50
Event Data Recorder (EDR).................55
Front Air Bag . . . . . . . . . . . . . . . . . . . . . . . . . . .39
If A Deployment Occurs...................48
Knee Impact Bolsters.....................43
Maintaining Your Air Bag System............54
Air bag Deployment........................39
Air bag Light.............................52
Air bag Maintenance........................54
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .346
Air Conditioner Maintenance.................349
Air Conditioning..........................212
Air Conditioning Controls...................212
Air Conditioning Filter.....................350
Air Conditioning, Operating Tips..............220
Air Conditioning Refrigerant.................349
Air Conditioning System....................212
Air Pressure, Tires.........................273
Alterations/Modifications, Vehicle...............8
Antifreeze (Engine Coolant)..................359
Capacities............................387
Disposal..............................362
Anti-Lock Brake System (ABS)................252
Anti-Lock Warning Light....................148
Appearance Care.........................369
Automatic Dimming Mirror...................90
Automatic Door Locks......................23
Automatic Temperature Control (ATC)..........215
Automatic Transaxle........................11
408 INDEX

Automatic Transmission....................233
Adding Fluid..........................368
Fluid and Filter Changes..................369
Fluid Change..........................369
Fluid Level Check.......................368
Fluid Type............................390
Gear Ranges...........................237
Special Additives.......................368
Autostick...............................242
Battery.................................347
Jump Starting..........................327
Keyless Transmitter Replacement (RKE)........18
Belts, Seat...............................79
Body Mechanism Lubrication.................353
B-Pillar Location..........................267
Brake Assist System.......................254
Brake Fluid.............................388
Brake, Parking...........................248
Brakes.................................364
Brake System............................252
Anti-Lock (ABS)........................252
Master Cylinder........................364
Parking..............................248
Warning Light.........................148
Brake/Transmission Interlock.................235
Bulb Replacement.........................382
Bulbs, Light..............................81
Capacities, Antifreeze (Engine Coolant)..........387
Capacities, Fluid..........................387
Caps, Filler
Fuel.................................300
Oil (Engine)...........................345
Carbon Monoxide Warning...................78
Cargo Area Features.......................137
Car Washes.............................370
CD (Compact Disc) Player...................182
10
INDEX 409

Emergency, In Case of
Hazard Warning Flasher..................307
Jacking...............................320
Jump Starting..........................327
Towing..............................334
Emission Control System Maintenance..........340
Engine
Air Cleaner...........................346
Break-In Recommendations.................76
Checking Oil Level......................344
Compartment..........................339
Cooling..............................358
Exhaust Gas Caution.....................78
Fails to Start...........................229
Flooded, Starting.......................229
Fuel Requirements......................295
Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..344
Oil Filler Cap..........................345
Oil Selection...........................345
Overheating...........................307
Starting..............................227
Enhanced Accident Response Feature............50
Euro Twin Clutch Transmission
Fluid Type............................367
Event Data Recorder........................55
Exhaust Gas Caution........................78
Exhaust System...........................78
Exterior Lights............................81
Filters
Air Cleaner...........................346
Air Conditioning.......................350
Engine Oil............................346
Engine Oil Disposal.....................346
Flashers
Turn Signal............................81
Flash-To-Pass............................110
Flooded Engine Starting....................229
412 INDEX

Latches.................................81
Hood................................107
Lead Free Gasoline........................295
Leaks, Fluid..............................81
Life of Tires.............................282
Liftgate (Sedan)...........................25
Light Bulbs..............................81
Lights..................................81
Airbag................................52
Anti-Lock.............................148
Brake Assist Warning....................260
Brake Warning.........................148
Bulb Replacement.......................383
Check Engine (Malfunction Indicator).........148
Engine Temperature Warning...............148
Exterior...............................81
Fog . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..148
High Beam............................110
High Beam Indicator.....................148
Low Fuel.............................148
Oil Pressure...........................148
Park.................................110
Seat Belt Reminder......................148
Service...............................383
Tire Pressure Monitoring (TPMS)............148
Traction Control........................260
Turn Signal............................81
Voltage..............................148
Warning (Instrument Cluster Description)......148
Loading Vehicle
Ti re s . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..267
Locks
Automatic Door.........................23
Door.................................20
Power Door............................22
Lubrication, Body.........................353
Lug Nuts...............................319
10
INDEX 415

Sun Roof...............................129
Supplemental Restraint System - Airbag..........39
Temperature Control, Automatic (ATC)..........215
Tilt Steering Column.......................117
Tire and Loading Information Placard...........267
Tire Markings............................261
Ti re s . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 1
Aging (Life of Tires).....................282
Air Pressure...........................272
Chains...............................284
Changing.............................320
Compact Spare.........................279
General Information.....................272
High Speed...........................275
Inflation Pressures.......................273
Jacking...............................320
Life of Tires...........................282
Load Capacity.........................267
Pressure Monitor System (TPMS)............286
Pressure Warning Light...................148
Quality Grading........................403
Radial...............................275
Replacement...........................283
Rotation..............................285
Safety...............................261
Sizes................................262
Snow Tires............................277
Spinning.............................281
Tread Wear Indicators....................281
Tire Safety Information.....................261
Tire Service Kit...........................308
To Open Hood...........................107
Towing................................301
Disabled Vehicle........................334
Recreational...........................302
Towing Vehicle Behind a Motorhome...........302
Traction................................244
420 INDEX