air conditioning FIAT 500C 2013 2.G User Guide

CAUTION!
•It is essential when replacing the cables on the
battery that the positive cable is attached to the
positive post and the negative cable is attached to
the negative post. Battery posts are marked positive
(+) and negative (-) and are identified on the
battery case. Cable clamps should be tight on the
terminal posts and free of corrosion.
•If a “fast charger” is used while the battery is in the
vehicle, disconnect both vehicle battery cables be-
fore connecting the charger to the battery. Do not
use a “fast charger” to provide starting voltage.
Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized studio
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance
test. Drive belt tension should also be checked at this
time.
CAUTION!
Do not use chemical flushes in your air conditioning
system as the chemicals can damage your air condi-
tioning components. Such damage is not covered by
the New Vehicle Limited Warranty.
346 MAINTAINING YOUR VEHICLE

WARNING!
•Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause the
system to fail, requiring costly repairs. Refer to
Warranty Information Book, located on the DVD,
for further warranty information.
•The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced technician.
Refrigerant Recovery And Recycling
R-134a Air Conditioning Refrigerant is a hydrofluoro-
carbon (HFC) that is endorsed by the Environmental
Protection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by authorized studio or other
service facilities using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C system
sealers, stop leak products, seal conditioners, compressor
oil, and refrigerants.
A/C Air Filter
WARNING!
Do not remove the A/C air filter while the blower is
operating or personal injury may result.
The A/C air filter is located in the fresh air inlet on the
lower right of center console. Perform the following
procedure to replace the filter:
7
MAINTAINING YOUR VEHICLE 347

Points To Remember
NOTE:When the vehicle is stopped after a few miles/
kilometers of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant expansion bottle.
•Check the coolant freeze point in the radiator and in the
coolant expansion bottle. If engine coolant (antifreeze)
needs to be added, the contents of the coolant expansion
bottle must also be protected against freezing.
•If frequent engine coolant (antifreeze) additions are
required, the cooling system should be pressure tested
for leaks.
•Maintain engine coolant (antifreeze) concentration at a
minimum of 50% OAT coolant (conforming to MS-12106)
and distilled water for proper corrosion protection of
your engine which contains aluminum components.
•Make sure that the coolant expansion bottle overflow
hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean.
•Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install ONLY
the correct type thermostat. Other designs may result in
unsatisfactory engine coolant (antifreeze) performance,
poor gas mileage, and increased emissions.
7
MAINTAINING YOUR VEHICLE 361

CavityMaxi
FuseMini Fuse Description
F07 40 Amp
Orange
Radiator Fan -
High Speed
F08 30 Amp
Green
Blower Motor
F0910 Amp
Red
Powertrain
F1010 Amp
Red
Horn
F1115 Amp
Blue
Powertrain
F1110 Amp
Red
Powertrain (Multi-
air – If Equipped)
F145 Amp
Ta n
High beam
(Shutter)
CavityMaxi
FuseMini Fuse Description
F1515 Amp
Blue
Cigar Lighter
F167.5 Amp
Brown
Transmission
F1725 Amp
White
Powertrain (Multi-
air – If Equipped)
F1715 Amp
Blue
Powertrain
F1815 Amp
Blue
Powertrain
F185 Amp
Ta n
Powertrain (Multi-
air – If Equipped)
F197.5 Amp
Brown
Air Conditioning
378 MAINTAINING YOUR VEHICLE

VEHICLE STORAGE
If you are leaving your vehicle dormant for more than 21
days, you may want to take these steps to protect your
battery.
•Disconnect the negative cable from the battery.
•Anytime you store your vehicle, or keep it out of
service (i.e., vacation) for two weeks or more, run the
air conditioning system at idle for about five minutes
in the fresh air and high blower setting. This will
ensure adequate system lubrication to minimize the
possibility of compressor damage when the system is
started again.
REPLACEMENT BULBS
Interior Bulbs
Bulb Number
Overhead LampC5W
Courtesy LampW5W
Exterior Bulbs
Bulb Number
Front Low and High
Beam Headlamp
HIR2
Front Parking/Daytime
Running Lamps
W21/5W
Front Fog Lamps H11
Front Side Marker Lamps W3W
Front Turn Signal Lamps WY21W
380 MAINTAINING YOUR VEHICLE

Adding Engine Coolant (Antifreeze)............358
Adding Fuel.............................291
Adding Washer Fluid......................353
Additives, Fuel...........................288
Airbag..................................42
Airbag Deployment........................55
Airbag Light.............................50
Airbag Maintenance........................56
Airbag, Side..............................45
Airbag, Window (Side Curtain)................46
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .344
Air Conditioner Maintenance.................346
Air Conditioning..........................208
Air Conditioning Controls...................208
Air Conditioning Filter.....................347
Air Conditioning Refrigerant.................346
Air Conditioning System....................208
Air Pressure, Tires.........................269
Alterations/Modifications, Vehicle...............8
Antifreeze (Engine Coolant)..................357
Capacities............................385
Disposal..............................360
Anti-Lock Brake System (ABS)................248
Anti-Lock Warning Light....................156
Appearance Care.........................367
Automatic Dimming Mirror...................93
Automatic Door Locks......................26
Automatic Temperature Control (ATC)..........210
Automatic Transaxle........................11
Automatic Transmission....................229
Adding Fluid..........................366
Fluid and Filter Changes..................367
Fluid Level Check.......................366
Fluid Type............................365
Gear Ranges...........................232
Special Additives.......................366
Autostick...............................237
406 INDEX

Exhaust Gas Caution........................29
Exhaust System...........................80
Exterior Lights............................83
Filler Location Fuel........................159
Filters
Air Cleaner...........................344
Air Conditioning.......................347
Engine Fuel...........................386
Engine Oil............................344
Engine Oil Disposal.....................343
Flashers
Turn Signal............................83
Flooded Engine Starting....................224
Fluid, Brake.............................387
Fluid Capacities..........................385
Fluid Leaks..............................83
Fluid Level Checks
Automatic Transmission..................366
Fluids, Lubricants and Genuine Parts...........386
Fog Lights..............................117
Freeing A Stuck Vehicle.....................324
Fuel...................................285
Adding..............................291
Additives.............................288
Capacity.............................385
Clean Air.............................286
Cutoff................................53
Filler Cap (Gas Cap).....................159
Filler Door (Gas Cap)....................159
Gasoline..............................285
Gauge...............................159
Light................................149
Materials Added........................288
Octane Rating..........................285
Requirements..........................285
Tank Capacity..........................385
410 INDEX