automatic transmission FIAT 500L 2016 2.G Owner's Manual

▫Euro Twin Clutch Transmission ............374
▫ Automatic Transmission .................375
 IGNITION KEY REMOVAL OVERRIDE .......376
 CAP-LESS FUEL FILL FUNNEL ............378
348 WHAT TO DO IN EMERGENCIES

FREEING A STUCK VEHICLE
If your vehicle becomes stuck in mud, sand or snow, it
can often be moved using a rocking motion. Turn the
steering wheel right and left to clear the area around the
front wheels. Then shift back and forth between DRIVE
and REVERSE (with Automatic or Euro Twin Clutch
Transmission) or 2nd gear and REVERSE (with manual
transmission), while gently pressing the accelerator. Use
the least amount of accelerator pedal pressure that will
maintain the rocking motion, without spinning the
wheels, or racing the engine.
NOTE:For vehicles with Euro Twin Clutch transmission:
Shifts between DRIVE and REVERSE can only be
achieved at wheel speeds of approximately 6 mph
(10 km/h) or less.
CAUTION!
Racing the engine or spinning the wheels may lead to
transmission overheating and failure. Allow the en-
gine to idle with the transmission in NEUTRAL for at
least one minute after every five rocking-motion
cycles. This will minimize overheating and reduce
the risk of clutch or transmission failure during
prolonged efforts to free a stuck vehicle.
NOTE: Push the ESC Off switch, to place the Electronic
Stability Control (ESC) system in Partial Offmode,
before rocking the vehicle. Refer to “Electronic Brake
Control” in “Starting And Operating” for further infor-
mation. Once the vehicle has been freed, push the ESC
Off switch again to restore ESC Onmode.
370 WHAT TO DO IN EMERGENCIES

TOWING A DISABLED VEHICLE
NOTE:This section describes procedures for towing a
disabled vehicle using a commercial towing service.
Towing Condition Wheels OFF The
Ground MANUAL TRANS-
MISSION EURO TWIN
CLUTCH TRANS- MISSION AUTOMATIC (AI-
SIN AW6F25)
TRANSMISSION
Flat Tow NONE Trans in NEUTRAL Trans in NEUTRAL NOT ALLOWED
Dolly Tow RearNOT ALLOWED NOT ALLOWED NOT ALLOWED
Front OKOK OK
Flatbed ALLBEST METHOD BEST METHOD BEST METHOD
Proper towing or lifting equipment is required to prevent
damage to your vehicle. Use only tow bars and other
equipment designed for this purpose, following equip-
ment manufacturer ’s instructions. Use of safety chains is
mandatory. Attach a tow bar or other towing device to
main structural members of the vehicle, not to bumpers or associated brackets. State and local laws regarding
vehicles under tow must be observed.
6
WHAT TO DO IN EMERGENCIES 373

section for instructions on shifting the transmission out of
PARK for towing.
CAUTION!
•Towing this vehicle in violation of the above re-
quirements can cause severe transmission damage.
Damage from improper towing is not covered un-
der the New Vehicle Limited Warranty.
Automatic Transmission
• Vehicle can be towed with the front wheels elevated.
• Vehicle can be towed on a flatbed truck (all wheels off
the ground).
If the ignition key is unavailable, or the battery is
discharged, refer to “Shift Lever Override” in this section for instructions on shifting the transmission out of PARK
in order to move the vehicle.
CAUTION!
•
DO NOT flat tow any vehicle equipped with a
conventional automatic transmission. Damage to
the drivetrain will result. If these vehicles require
towing, make sure all drive wheels are OFF the
ground.
• Towing this vehicle in violation of the above re-
quirements can cause severe transmission damage.
Damage from improper towing is not covered un-
der the New Vehicle Limited Warranty.
6
WHAT TO DO IN EMERGENCIES 375

▫Euro Twin Clutch Transmission —
If Equipped ........................ .407
▫ Automatic Transmission — Aisin AW6F25
Transmission — If Equipped .............409
▫ Appearance Care And Protection From
Corrosion ...........................411
 FUSES ............................. .418
▫ Underhood Fuses ..................... .419
▫ Interior Fuses ....................... .422
▫ Rear Interior Fuses .....................426
 VEHICLE STORAGE ....................427
 REPLACEMENT BULBS .................428
 BULB REPLACEMENT ..................430 ▫
Headlamps Low Beam and High Beam ......430
▫ Front Turn Signal, Parking And Daytime Running
Lamps ............................ .433
▫ Front Fog Lamps ..................... .433
▫ Front, Rear Roof Lamps .................433
▫ Rear Tail, Stop, Backup And Turn Signal
Lamps ............................ .433
▫ Center High-Mounted Stop Lamp (CHMSL) . .434
 FLUID CAPACITIES ....................434
 FLUIDS, LUBRICANTS, AND GENUINE
PARTS ............................. .435
▫ Engine ............................ .435
▫ Chassis ........................... .437
380 MAINTAINING YOUR VEHICLE

CAUTION!
If a transmission fluid leak occurs, visit your autho-
rized dealer immediately. Severe transmission dam-
age may occur. Your authorized dealer has the proper
tools to adjust the fluid level accurately.
Fluid Changes
Under normal operating conditions, the fluid installed at
the factory will provide satisfactory lubrication for the
life of the vehicle. However, if the vehicle is used for
police, fleet, taxi, etc., change the fluid as indicated in the
Maintenance Schedule. In addition, change the fluid if it
becomes contaminated (with water, etc.), or if the trans-
mission is disassembled for any reason.
Automatic Transmission — Aisin AW6F25
Transmission — If Equipped
Selection Of Lubricant
It is important to use the proper transmission fluid to
ensure optimum transmission performance and life. Use
only the manufacturer ’s specified transmission fluid.
Refer to “Fluids, Lubricants, And Genuine Parts” in this
section for fluid specifications. It is important to maintain
the transmission fluid at the correct level using the
recommended fluid. No chemical flushes should be used
in any transmission; only the approved lubricant should
be used.
CAUTION!
Using a transmission fluid other than the manufac-
turer ’s recommended fluid may cause deterioration
(Continued)
7
MAINTAINING YOUR VEHICLE 409

CAUTION!(Continued)
in transmission shift quality and/or torque converter
shudder. Refer to “Fluids, Lubricants, And Genuine
Parts” in this section for fluid specifications.
Special Additives
The manufacturer strongly recommends against using
any special additives in the transmission.
Automatic Transmission Fluid (ATF) is an engineered
product and its performance may be impaired by supple-
mental additives. Therefore, do not add any fluid addi-
tives to the transmission. The only exception to this
policy is the use of special dyes for diagnosing fluid
leaks. Avoid using transmission sealers as they may
adversely affect seals.
CAUTION!
Do not use chemical flushes in your transmission as
the chemicals can damage your transmission compo-
nents. Such damage is not covered by the New
Vehicle Limited Warranty.
Fluid Level Check
The fluid level is preset at the factory and does not
require adjustment under normal operating conditions.
Routine fluid level checks are not required, therefore the
transmission has no dipstick. Your authorized dealer can
check your transmission fluid level using special service
tools. If you notice fluid leakage or transmission malfunc-
tion, visit your authorized dealer immediately to have
the transmission fluid level checked. Operating the ve-
hicle with an improper fluid level can cause severe
transmission damage.
410 MAINTAINING YOUR VEHICLE

Chassis
ComponentFluid, Lubricant, or Genuine Part
Manual Transmission – If Equipped We recommend you use MOPAR C Series Manual &
Dual Dry Clutch Transmission Fluid.
Euro Twin Clutch Transmission – If Equipped Gearbox:Use only MOPAR C Series Manual & Dual
Dry Clutch Transmission Fluid or equivalent.
Control System: Use only MOPAR C Series DDCT SAE
75W Hydraulic Fluid or equivalent. Failure to use the
correct fluid may affect the function or performance of
your transmission.
Automatic Transmission – Aisin AW6F25 Transmission
– If Equipped Use only MOPAR AW-1 Automatic Transmission Fluid
or equivalent. Failure to use the correct fluid may affect
the function or performance of your transmission.
Brake Master Cylinder We recommend you use MOPAR DOT 4. If DOT 4 brake
fluid is not available, then DOT 3 is acceptable.
7
MAINTAINING YOUR VEHICLE 437

Adding Engine Coolant (Antifreeze)............401
Adding Fuel ............................ .342
Adding Washer Fluid ..................... .397
Additives, Fuel .......................... .340
AirBag.................................43 Advance Front Air Bag ....................44
Air Bag Operation .......................46
Air Bag Warning Light ....................56
Driver Knee Air Bag ......................47
Enhanced Accident Response ................54
Event Data Recorder (EDR) .................58
FrontAirBag...........................43
If A Deployment Occurs ...................53
Knee Impact Bolsters .....................47
Maintaining Your Air Bag System ............58
Side Air Bags ...........................48
Air Bag Deployment ........................43
Air Bag Light ...................... .56, 83, 170
Air Bag Maintenance .......................58 Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .387
Air Conditioner Maintenance
.................389
Air Conditioning Filter .....................390
Air Conditioning Refrigerant ..............389, 390
Air Conditioning System ....................389
Air Pressure, Tires ........................ .319
Alarm (Security Alarm) ......................15
Alarm System (Security Alarm) ................15
Alfa Twin Clutch Transmission Fluid Type ........................... .408
Alterations/Modifications, Vehicle ...............8
Antifreeze (Engine Coolant) ...............400, 434
Capacities ........................... .434
Disposal ............................. .403
Anti-Lock Brake System (ABS) ................297
Appearance Care ..........................411
Arming System (Security Alarm) ...............15
Audio Systems (Radio) .....................226
Automatic Dimming Mirror ...................91
458 INDEX

Automatic Transmission...........270, 283, 409, 411
Adding Fluid ...................... .410, 411
Autostick ............................ .289
Fluid And Filter Changes ..................411
Fluid Change ..........................411
Fluid Level Check ...................... .410
Fluid Type ........................... .437
Gear Ranges .......................... .284
Special Additives ...................... .410
Autostick .............................. .289
Auto Up Power Windows ....................27
Battery ................................ .388
Jump Starting ......................... .365
Belts, Seat ...............................83
Body Mechanism Lubrication .................392
B-Pillar Location ......................... .313
Brake Assist System ...................... .298
Brake Fluid ............................ .437Brake, Parking
.......................... .294
Brakes ................................ .405
Brake System ........................ .296, 405
Anti-Lock (ABS) ....................... .297
Master Cylinder ....................... .405
Parking ............................. .294
Warning Light ........................ .166
Brake/Transmission Interlock .................272
Bulb Replacement ..................... .428, 430
Bulbs, Light .......................... .85, 428
Camera, Rear ........................... .131
Capacities, Antifreeze (Engine Coolant) ..........434
Capacities, Fluid ......................... .434
Caps, Filler Fuel ................................ .378
Oil (Engine) .......................... .386
Carbon Monoxide Warning ................82, 342
Car Washes ............................ .412
10
INDEX 459