transmission oil FIAT 500L 2016 2.G Owners Manual
[x] Cancel search | Manufacturer: FIAT, Model Year: 2016, Model line: 500L, Model: FIAT 500L 2016 2.GPages: 476, PDF Size: 3.67 MB
Page 82 of 476
WARNING!
•An incorrectly anchored tether strap could lead to
increased head motion and possible injury to the
child. Use only the anchorage position directly
behind the child seat to secure a child restraint top
tether strap.
• If your vehicle is equipped with a split rear seat,
make sure the tether strap does not slip into the
opening between the seatbacks as you remove
slack in the strap.
Transporting Pets
Air Bags deploying in the front seat could harm your pet.
An unrestrained pet will be thrown about and possibly
injured, or could injure a passenger during panic braking
or in a collision.
Pets should be restrained in the rear seat in pet harnesses
or pet carriers that are secured by seat belts.
ENGINE BREAK-IN RECOMMENDATIONS
A long break-in period is not required for the engine and
drivetrain (transmission and axle) in your vehicle.
Drive moderately during the first 300 miles (500 km).
After the initial 60 miles (100 km), speeds up to 50 or
55 mph (80 or 90 km/h) are desirable.
While cruising, brief full-throttle acceleration within the
limits of local traffic laws contributes to a good break-in.
Wide-open throttle acceleration in low gear can be detri-
mental and should be avoided.
The engine oil installed in the engine at the factory is a
high-quality energy conserving type lubricant. Oil
changes should be consistent with anticipated climate
conditions under which vehicle operations will occur. For
the recommended viscosity and quality grades, refer to
“Maintenance Procedures” in “Maintaining Your Ve-
hicle.”
80 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE
Page 281 of 476
During extremely cold temperatures, the transmission
will not operate if the oil temperature is -22°F (-30°C) or
below. Allow the engine to idle briefly with the transmis-
sion in PARK in order to warm the fluid. Normal
operation will resume once the transmission temperature
has risen to a suitable level.Instrument Cluster Messages
Messages will be displayed in the instrument cluster to
alert the driver when certain unusual conditions occur.
These messages are described below.
MESSAGE
DESCRIPTION
GEAR UNAVAILABLE In AutoStick mode, the gear selected by the driver is
not available due to a fault condition. See your autho- rized dealer for diagnosis and service.
SHIFT NOT ALLOWED The gear position requested by the driver is currently
blocked. This occurs if REVERSE is requested while
moving (at 6 mph [10 km/h] or faster), or if DRIVE is requested while moving backwards (at 6 mph
[10 km/h] or faster). Make sure the vehicle is stopped before engaging DRIVE or REVERSE.
5
STARTING AND OPERATING 279
Page 381 of 476
MAINTAINING YOUR VEHICLE
CONTENTS
ENGINE COMPARTMENT — 1.4L TURBO . . . .381
ONBOARD DIAGNOSTIC SYSTEM — OBD II . .382
▫ Onboard Diagnostic System (OBD II)
Cybersecurity ....................... .382
REPLACEMENT PARTS ..................383
DEALER SERVICE ..................... .383
MAINTENANCE PROCEDURES ...........384
▫ Engine Oil ......................... .385
▫ Engine Oil Filter ..................... .387
▫ Engine Air Cleaner Filter ................387 ▫
Maintenance-Free Battery ...............388
▫ Air Conditioner Maintenance .............389
▫ Body Lubrication .....................392
▫ Wiper Blades ....................... .393
▫ Adding Washer Fluid ..................397
▫ Exhaust System ..................... .397
▫ Cooling System ..................... .399
▫ Brake System ....................... .405
▫ Manual Transmission — If Equipped .......407
7
Page 387 of 476
CAUTION!(Continued)
transmission, or air conditioning. Such damage is
not covered by the New Vehicle Limited Warranty.
If a flush is needed because of component malfunc-
tion, use only the specified fluid for the flushing
procedure.
Engine Oil
Checking Oil Level
To assure proper engine lubrication, the engine oil must
be maintained at the correct level. Check the oil level at
regular intervals, such as every fuel stop. The best time to
check the engine oil level is approximately five minutes
after a fully warmed engine is shut off. Do not check oil
level before starting the engine after it has sat overnight.
Checking engine oil level when the engine is cold will
give you an incorrect reading. Checking the oil while the vehicle is on level ground, and
approximately five minutes after a fully warmed engine
is shut off, will improve the accuracy of the oil level
readings. Maintain the oil level between the range mark-
ings on the dipstick. The safe range is indicated by a
crosshatch zone. Adding 1 quart (0.9 Liters) of oil when
the reading is at the low end of the indicated range will
result in the oil level at the full end of the indicator range.
CAUTION!
Do not overfill the engine with oil. Overfilling the
engine with oil will cause oil aeration, which can
lead to loss of oil pressure and an increase in oil
temperature. This loss of oil pressure and increased
oil temperature could damage your engine.7
MAINTAINING YOUR VEHICLE 385
Page 461 of 476
Automatic Transmission...........270, 283, 409, 411
Adding Fluid ...................... .410, 411
Autostick ............................ .289
Fluid And Filter Changes ..................411
Fluid Change ..........................411
Fluid Level Check ...................... .410
Fluid Type ........................... .437
Gear Ranges .......................... .284
Special Additives ...................... .410
Autostick .............................. .289
Auto Up Power Windows ....................27
Battery ................................ .388
Jump Starting ......................... .365
Belts, Seat ...............................83
Body Mechanism Lubrication .................392
B-Pillar Location ......................... .313
Brake Assist System ...................... .298
Brake Fluid ............................ .437Brake, Parking
.......................... .294
Brakes ................................ .405
Brake System ........................ .296, 405
Anti-Lock (ABS) ....................... .297
Master Cylinder ....................... .405
Parking ............................. .294
Warning Light ........................ .166
Brake/Transmission Interlock .................272
Bulb Replacement ..................... .428, 430
Bulbs, Light .......................... .85, 428
Camera, Rear ........................... .131
Capacities, Antifreeze (Engine Coolant) ..........434
Capacities, Fluid ......................... .434
Caps, Filler Fuel ................................ .378
Oil (Engine) .......................... .386
Carbon Monoxide Warning ................82, 342
Car Washes ............................ .412
10
INDEX 459
Page 464 of 476
Electronic Throttle Control Warning Light........172
Electronic Vehicle Information Center (EVIC) . .131, 186 Exit Trip ............................. .192
Start Of Trip Procedure ...................192
Emergency Deck Lid Release ..................29
Emergency, In Case Of Hazard Warning Flasher ..................349
Jacking .............................. .357
Jump Starting ......................... .365
Towing ............................. .373
Emergency Trunk Release ....................29
Engine Air Cleaner .......................... .387
Break-In Recommendations .................80
Checking Oil Level ..................... .385
Compartment ......................... .381
Cooling ............................. .399
Exhaust Gas Caution ..................82, 342 Fails To Start
......................... .267
Flooded, Starting ...................... .267
Fuel Requirements ..................... .338
Oil ............................. .385, 434
Oil Filler Cap ......................... .386
Oil Filter ............................ .387
Oil Selection .......................... .386
Overheating .......................... .349
Starting ............................. .265
Enhanced Accident Response Feature ............54
Ethanol ............................... .339
Euro Twin Clutch Transmission .........270, 272, 382
Fluid Type .....................407, 409, 437
Gear Ranges .......................... .274
Event Data Recorder ........................58
Exhaust Gas Caution ....................82, 342
Exhaust System ....................... .82, 397
Exterior Lights ............................85
462 INDEX
Page 465 of 476
FiltersAir Cleaner .......................... .387
Air Conditioning ...................... .390
Engine Fuel .......................... .435
Engine Oil ........................... .387
Engine Oil Disposal .....................387
Flashers Turn Signal ........................ .85, 184
Flooded Engine Starting ....................267
Fluid, Brake ............................ .437
Fluid Capacities ......................... .434
Fluid Leaks ..............................85
Fluid Level Checks Automatic Transmission ..................410
Fluids, Lubricants And Genuine Parts ...........435
Fog Lights ..............................113
Fold And Tumble Rear Seat ..................101
Freeing A Stuck Vehicle .....................370
Fuel .................................. .338Adding
............................. .342
Additives ............................ .340
Capacity ............................ .434
Clean Air ............................ .339
Ethanol ............................. .339
Gasoline ............................. .338
Light ............................... .177
Materials Added ....................... .340
Methanol ............................ .339
Octane Rating ......................... .338
Requirements ......................... .338
Tank Capacity ......................... .434
Fueling ............................... .342
Fuses ................................. .418
Garage Door Opener (HomeLink) ..............133
Gasoline, Clean Air ....................... .339
Gasoline (Fuel) ....................... .338, 434
Gasoline, Reformulated .....................339
10
INDEX 463
Page 468 of 476
LocksChild Protection .........................25
Door .................................22
Lubrication, Body ........................ .392
Lug Nuts .............................. .350
Maintenance Free Battery ....................388
Maintenance, General ..................... .384
Maintenance Procedures ....................384
Maintenance Schedule ..................... .440
Malfunction Indicator Light (Check Engine) .......178
Manual, Service ......................... .453
Manual Transmission ...................268, 407
Fluid Level Check ...................... .407
Frequency Of Fluid Change ................407
Lubricant Selection ...................407, 437
Master Cylinder (Brakes) ....................405
Methanol .............................. .339
Mirrors .................................90 Automatic Dimming
......................91
Electric Powered .........................92
Electric Remote .........................92
Heated ...............................93
Rearview ..............................90
Modifications/Alterations, Vehicle ...............8
Monitor, Tire Pressure System ................333
MTBE/ETBE ........................... .339
Multi-Function Control Lever .................111
New Vehicle Break-In Period ..................80
Occupant Restraints ........................31
Octane Rating, Gasoline (Fuel) ................338
Oil Change Indicator ...................... .190
Oil Change Indicator, Reset ..................190
Oil, Engine ...................... .385, 434, 435
Capacity ............................ .434
Change Interval ....................... .386
466 INDEX