engine overheat FIAT 500X 2022 User Guide
[x] Cancel search | Manufacturer: FIAT, Model Year: 2022, Model line: 500X, Model: FIAT 500X 2022Pages: 312, PDF Size: 13.26 MB
Page 233 of 312

IN CASE OF EMERGENCY231
6. Insert a small screwdriver or similar tool down into the gear selector override access hole (at
the right front corner of the gear selector
assembly), and push and hold the override
release lever down.
Gear Selector Override Location
7. Move the gear selector to the NEUTRAL position.
8. The vehicle may then be started in NEUTRAL.
9. Reinstall the gear selector bezel.
FREEING A STUCK VEHICLE
If your vehicle becomes stuck in mud, sand, or
snow, it can often be moved using a rocking
motion. Turn the steering wheel right and left to
clear the area around the front wheels. Then shift
back and forth between DRIVE (D) and REVERSE (R), while gently pressing the accelerator. Use the
least amount of accelerator pedal pressure that
will maintain the rocking motion, without spinning
the wheels or racing the engine.
Shifts between DRIVE and REVERSE can only be
achieved at wheel speeds of 5 mph (8 km/h) or
less. Whenever the transmission remains in
NEUTRAL for more than two seconds, you must
press the brake pedal to engage DRIVE or
REVERSE.
NOTE:Push the ESC OFF button to place the Electronic
Stability Control (ESC) system in “Partial OFF”
mode, before rocking the vehicle Ú
page 176.
Once the vehicle has been freed, push the ESC OFF
button again to restore “ESC On” mode.
CAUTION!
Racing the engine or spinning the wheels may
lead to transmission overheating and failure.
Allow the engine to idle with the transmission
in NEUTRAL for at least one minute after every
five rocking-motion cycles. This will minimize
overheating and reduce the risk of clutch or
transmission failure during prolonged efforts
to free a stuck vehicle.
When “rocking” a stuck vehicle by shifting
between DRIVE/SECOND gear and REVERSE,
do not spin the wheels faster than 15 mph
(24 km/h), or drivetrain damage may result.
Revving the engine or spinning the wheels too
fast may lead to transmission overheating and
failure. It can also damage the tires. Do not
spin the wheels above 30 mph (48 km/h)
while in gear (no transmission shifting occur -
ring).
WARNING!
Fast spinning tires can be dangerous. Forces
generated by excessive wheel speeds may
cause damage, or even failure, of the axle and
tires. A tire could explode and injure someone.
Do not spin your vehicle's wheels faster than
30 mph (48 km/h) or for longer than 30 sec -
onds continuously without stopping when you
are stuck and do not let anyone near a spinning
wheel, no matter what the speed.
7
22_FD_OM_EN_USC_t.book Page 231
Page 249 of 312

SERVICING AND MAINTENANCE247
(Continued)
Under normal operating conditions, the catalytic
converter will not require maintenance. However, it
is important to keep the engine properly tuned to
ensure proper catalyst operation and prevent
possible catalyst damage.
NOTE:Intentional tampering with emissions control
systems can result in civil penalties being
assessed against you.
In unusual situations involving grossly
malfunctioning engine operation, a scorching odor
may suggest severe and abnormal catalyst
overheating. If this occurs, stop the vehicle, turn off
the engine and allow it to cool. Service, including a
tune-up to manufacturer's specifications, should
be obtained immediately. To minimize the possibility of catalytic converter
damage:
Do not interrupt the ignition when the transmis
-
sion is in gear and the vehicle is in motion.
Do not try to start the vehicle by pushing or
towing the vehicle.
Do not idle the engine with any ignition compo -
nents disconnected or removed, such as when
diagnostic testing, or for prolonged periods
during very rough idle or malfunctioning oper -
ating conditions.
COOLING SYSTEM
Engine Coolant Checks
Check the engine coolant (antifreeze) protection
every 12 months (before the onset of freezing
weather, where applicable). If the engine coolant is
dirty, the system should be drained, flushed, and
refilled with fresh Organic Additive Technology
(OAT) coolant (conforming to MS.90032) by an
authorized dealer. Check the front of the A/C
condenser for any accumulation of bugs, leaves,
etc. If dirty, clean by gently spraying water from a
garden hose vertically down the face of the
condenser.
Check the engine cooling system hoses for brittle
rubber, cracking, tears, cuts, and tightness of the
connection at the coolant recovery bottle and
radiator. Inspect the entire system for leaks. DO
NOT REMOVE THE COOLANT PRESSURE CAP
WHEN THE COOLING SYSTEM IS HOT.
Damage to the catalytic converter can result if
your vehicle is not kept in proper operating
condition. In the event of engine malfunction,
particularly involving engine misfire or other
apparent loss of performance, have your
vehicle serviced promptly. Continued opera -
tion of your vehicle with a severe malfunction
could cause the converter to overheat,
resulting in possible damage to the converter
and vehicle.
CAUTION!
WARNING!
You or others can be badly burned by hot
engine coolant (antifreeze) or steam from your
radiator. If you see or hear steam coming from
under the hood, do not open the hood until the
radiator has had time to cool. Never open a
cooling system pressure cap when the radi -
ator or coolant bottle is hot.
Keep hands, tools, clothing, and jewelry away
from the radiator cooling fan when the hood is
raised. The fan starts automatically and may
start at any time, whether the engine is
running or not.
When working near the radiator cooling fan,
disconnect the fan motor lead or turn the igni -
tion to the OFF position. The fan is tempera -
ture controlled and can start at any time the
ignition is in the ON position.
WARNING!
8
22_FD_OM_EN_USC_t.book Page 247
Page 251 of 312

SERVICING AND MAINTENANCE249
(Continued)
damage. If any coolant is needed to be added to
the system, please contact a local authorized
dealer.
Mixing engine coolant types is not recom
-
mended and can result in cooling system
damage. If HOAT and OAT coolant are mixed in
an emergency, have a authorized dealer drain,
flush, and refill with OAT coolant (conforming to
MS.90032) as soon as possible.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of
engine coolant (antifreeze), and to ensure that
engine coolant will return to the radiator from the
coolant expansion bottle/recovery tank (if
equipped).
The cap should be inspected and cleaned if there
is any accumulation of foreign material on the
sealing surfaces.
Disposal Of Used Coolant
Used ethylene glycol-based coolant (antifreeze) is
a regulated substance requiring proper disposal.
Check with your local authorities to determine the
disposal rules for your community. To prevent
ingestion by animals or children, do not store
ethylene glycol-based coolant in open containers
or allow it to remain in puddles on the ground,
clean up any ground spills immediately. If ingested
by a child or pet, seek emergency assistance
immediately.
Coolant Level
The coolant expansion bottle provides a quick
visual method for determining that the coolant
level is adequate. With the engine off and cold, the
level of the coolant (antifreeze) in the bottle should
be between the “MAX” and “MIN” lines marked on
the bottle.
As long as the engine operating temperature is
satisfactory, the coolant bottle need only be
checked once a month. When additional coolant is needed to maintain the
proper level, it should be added to the coolant
bottle. Do not overfill.
See an authorized dealer for service.
Cooling System Notes
NOTE:When the vehicle is stopped after a few miles/kilo
-
meters of operation, you may observe vapor
coming from the front of the engine compartment.
This is normally a result of moisture from rain,
snow, or high humidity accumulating on the
radiator and being vaporized when the thermostat
opens, allowing hot engine coolant (antifreeze) to
enter the radiator.
If an examination of your engine compartment
shows no evidence of radiator or hose leaks, the
vehicle may be safely driven. The vapor will soon
dissipate.
Do not overfill the coolant expansion bottle.
Check the coolant freeze point in the radiator
and in the coolant expansion bottle. If engine
coolant needs to be added, the contents of the
coolant expansion bottle must also be protected
against freezing.WARNING!
Do not open hot engine cooling system. Never
add engine coolant (antifreeze) when the
engine is overheated. Do not loosen or
remove the cap to cool an overheated engine.
Heat causes pressure to build up in the
cooling system. To prevent scalding or injury,
do not remove the pressure cap while the
system is hot or under pressure.
Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or
engine damage may result.
WARNING!
8
22_FD_OM_EN_USC_t.book Page 249
Page 294 of 312

292TECHNICAL SPECIFICATIONS
FUEL SYSTEM CAUTIONS
NOTE:Intentional tampering with the emissions control system can result in civil penalties being assessed against you.
FLUID CAPACITIES
CAUTION!
Follow these guidelines to maintain your vehicle’s performance:
The use of leaded gasoline is prohibited by Federal law. Using leaded gasoline can impair engine performance and damage the emissions control system.
An out-of-tune engine or certain fuel or ignition malfunctions can cause the catalytic converter to overheat. If you notice a pungent burning odor or some
light smoke, your engine may be out of tune or malfunctioning and may require immediate service. Contact an authorized dealer for service assistance.
The use of fuel additives, which are now being sold as octane enhancers, is not recommended. Most of these products contain high concentrations of meth -
anol. Fuel system damage or vehicle performance problems resulting from the use of such fuels or additives is not the responsibility of the manufacturer
and may void or not be covered under the New Vehicle Limited Warranty.
US Metric
Fuel (Approximate)
1.3L Turbo 12.7 Gallons48 Liters
Engine Oil With Filter
1.3L Turbo 4.8 Quarts4.5 Liters
Cooling System *
1.3L Turbo 8.8 Quarts8.3 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
22_FD_OM_EN_USC_t.book Page 292
Page 303 of 312

301
Disposal Antifreeze (Engine Coolant)
....................... 249Disturb........................................................... 159Door Ajar.......................................................... 71Door Ajar Light................................................. 71Door LocksAutomatic.................................................... 24Remote Keyless Entry................................. 22Drag & Drop................................................... 140Driver Memory Presets.................................. 147Driver’s Seat Back Tilt..................................... 26DrivingThrough Flowing, Rising, Or Shallow Standing Water
..................................... 120
E
Electric Brake Control System....................... 175Anti-Lock Brake System............................. 174Traction Control System............................ 178Electric Park Brake.......................................... 82Electric Parking Brake..................................... 82Electrical Outlet, Auxiliary (Power Outlet)......... 52Electrical Power Outlets................................... 52Electronic Stability Control (ESC)...................176Electronic Throttle Control Warning Light........ 71Emergency Refueling..................................... 229Emergency, In Case OfHazard Warning Flasher............................ 218Jacking...................................................... 218Jump Starting............................................ 226
Overheating.............................................. 229Towing...................................................... 232Emission Control System Maintenance........... 78Engine........................................................... 240Air Cleaner................................................ 243Break-In Recommendations........................ 82Checking Oil Level.................................... 241Compartment........................................... 240Coolant (Antifreeze).................................. 293Cooling..................................................... 247Exhaust Gas Caution....................... 216, 217Fails To Start............................................... 81Flooded, Starting......................................... 81Jump Starting........................................... 226Oil........................................... 242, 292, 293Oil Filler Cap............................................. 240Oil Filter.................................................... 243Oil Selection.................................... 242, 292Overheating.............................................. 229Starting........................................................ 80Enhanced Accident Response
Feature................................................ 201, 234Ethanol......................................................... 291Exhaust Gas Cautions.......................... 216, 217Exhaust System................................... 216, 246Exterior Lighting............................................... 36Exterior Lights.........................................36, 216
F
FiltersAir Cleaner
................................................ 243Air Conditioning................................. 49, 244Engine Oil........................................ 243, 293Engine Oil Disposal................................... 243FlashersHazard Warning........................................ 218Turn Signals................................ 38, 77, 216Flash-To-Pass...................................................37Flooded Engine Starting...................................81Floor Console...................................................51Fluid Capacities............................................ 292Fluid Leaks.................................................... 216Fluid Level ChecksEngine Oil................................................. 241Fluid, Brake................................................... 293Fog Lights........................................................38Folding Rear Seats...........................................26Freeing A Stuck Vehicle................................. 231Front And Rear Park Assist System............... 102Fuel............................................................... 290Adding...................................................... 111Additives................................................... 290Clean Air................................................... 290Ethanol..................................................... 291Gasoline................................................... 29011
22_FD_OM_EN_USC_t.book Page 301
Page 306 of 312

304 Monitor, Tire Pressure System
....................... 185Mopar Parts................................................... 296MP3 Control.................................................... 51
N
New Vehicle Break-In Period............................ 82
O
Occupant Restraints...................................... 188Octane Rating, Gasoline (Fuel)............ 290, 293Oil Change Indicator........................................ 65Reset........................................................... 65Oil Filter, Change........................................... 243Oil Filter, Selection......................................... 243Oil Pressure Light............................................ 71Oil, Engine........................................... 242, 293Capacity.................................................... 292Checking................................................... 241Dipstick..................................................... 241Disposal.................................................... 243Filter................................................ 243, 293Filter Disposal........................................... 243Identification Logo..................................... 242Materials Added To................................... 243Pressure Warning Light............................... 71Recommendation............................ 242, 292Viscosity.................................................... 292Onboard Diagnostic System............................ 78Operating Precautions..................................... 78
Operator Manual Owner's Manual........................................ 296Outside Rearview Mirrors................................ 34Overheating, Engine...................................... 229
P
Paint Care..................................................... 286Pair (Link) Uconnect Phone To A Mobile
Phone
S
..................................................... 154Park Assist.................................................... 102Park Assist System, Front And Rear.............. 102Parking Brake.................................................. 82Personalized Main Menu Bar........................ 140Pets.............................................................. 215Phone Mode................................................. 152Pinch Protection.............................................. 55Placard, Tire And Loading Information.......... 273PowerBrakes...................................................... 289Mirrors......................................................... 34Sunroof........................................................ 55Power Folding Roof.......................................... 57Pregnant Women And Seat Belts.................. 193Preparation For Jacking................................ 218Presets......................................................... 147
R
Radial Ply Tires............................................. 277Radiator Cap (Coolant Pressure Cap)........... 249
RadioPresets..................................................... 147Radio Controls.............................................. 142Radio Mode................................................... 142Radio Operation................................... 142, 173Radio Remote Controls................................. 141Rain Sensitive Wiper System...........................41Rear Camera................................................. 110Rear Cross Path............................................ 181Rear Seats, Folding..........................................26Rear Window Defroster....................................42Rear Wiper/Washer.........................................42Recreational Towing...................................... 119Reformulated Gasoline................................. 290Refrigerant.................................................... 244Release, Hood..................................................58Reminder, Lights On........................................37Reminder, Seat Belt...................................... 189Remote ControlStarting System...........................................18Remote Keyless Entry......................................14Arm The Alarm.............................................21Disarm The Alarm........................................21Keyless Enter-N-Go......................................23Remote Sound System (Radio) Control......... 141Remote StartingUconnect Customer ProgrammableFeatures
..................................................20Uconnect Settings.......................................20Remote Starting System..................................18
22_FD_OM_EN_USC_t.book Page 304