steering FIAT CROMA 2008 2.G Owner's Guide

216
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
STEERING WHEEL/GEAR LEVER
KNOB WITH GENUINE
LEATHER COVERING
These components shall only be cleaned
with water and neutral soap. Never use
spirit or alcohol-based products.
Before using special products for clean-
ing interiors, read carefully label instruc-
tions and indications to make sure they
are free from spirit and/or alcohol-based
substances.
If when cleaning the windscreen with spe-
cial glass products, some drops fall on the
leather covering of the steering wheel/gear
lever knob remove them immediately and
then clean with water and neutral soap.
IMPORTANT Take the utmost care when
engaging the steering lock to prevent
scratching the leather covering.INTERIOR PLASTIC PARTS
Use appropriate products designed to
preserve the appearance of components.
IMPORTANT Never use spirit or petro-
leum to clean the instrument panel. If the stain persists, use specific products,
carefully following the instructions for use.
IMPORTANT Never use spirit or alcohol-
based products.
Never use flammable prod-
ucts like oil ether or rectified
petrol for cleaning car interiors. Elec-
trostatic discharges generated by rub-
bing during cleaning operations could
cause fire.
WARNING
Do not keep aerosol cans in
the car: they might explode.
Aerosol cans must never be exposed
to a temperature above 50°C. The
temperature inside the car exposed
to the sun may go well beyond that
figure.
WARNING
193-216 Croma TRW GB 28-05-2008 15:19 Pagina 216

217
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IDENTIFICATION DATA ................................................. 218
ENGINE CODES - BODYWORK VERSIONS............... 220
ENGINE .................................................................................. 221
FUEL FEED/IGNITION ....................................................... 223
TRANSMISSION .................................................................. 223
BRAKES................................................................................... 224
SUSPENSIONS....................................................................... 224
STEERING............................................................................... 224
WHEELS.................................................................................. 225
DIMENSIONS......................................................................... 230
PERFORMANCE................................................................... 231
WEIGHTS............................................................................... 232
CAPACITIES........................................................................... 234
FLUIDS AND LUBRICANTS.............................................. 236
FUEL CONSUMPTION....................................................... 238
CO
2EMISSIONS .................................................................. 240
RADIO FREQUENCY REMOTE CONTROL:
MINISTERIAL CERTIFICATIONS .................................... 241
TT T
E E
C C
H H
N N
I I
C C
A A
L L
S S
P P
E E
C C
I I
F F
I I
C C
A A
T T
I I
O O
N N
S S
217-242 Croma TRW GB 10-11-2008 13:16 Pagina 217

224
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
Disc, self-ventilating
Disc, self-ventilating
Controlled by hand lever,
it works on rear brakes
BRAKES
1.8 - 2.2 - 1.9 Multijet 8V2.4 Multijet 20Va.t.1.9 Multijet 16V
Service brakes:
– front
– rear
Parking brake
IMPORTANT Water, ice and antifreeze salt on roads may deposit on the brake discs thus reducing braking efficiency at first brak-
ing.
SUSPENSIONS
1.8 - 2.2 - Multijet
Front
RearMcPherson independent wheels
Multilink independent wheels Disc, self-ventilating
Disc
Controlled by hand lever,
it works on rear brakes
STEERING
1.8 - 2.2 - Multijet 2.4 Multijet 20Va.t.
Type
Minimum steering
cycle mElectro-hydraulic power steering
11,45Electro-hydraulic power steering
11,80
217-242 Croma TRW GB 10-11-2008 13:16 Pagina 224

234
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
CAPACITIES
Fuel tank:
including a reserve of:
Engine cooling system– with climate control:
Engine sump and filter:
Mechanical gearbox and
differential:
Automatic transmission
Hydraulic brake circuit
with ABS:
Electrohydraulic power
steering circuit:
Windscreen/rear window
/headlight washer fluid reservoir: (*)
(*) The values in brackets refer to versions with headlight washers.
(▲) For particularly hard climate conditions, we recommend use of a 60% PARAFLU UPand 40% demineralized water mixture.
(
●) Total quantity of oil in the gearbox.
1.8
litres kg
62 –
7 - 9 –
7.4 –
4.5 –
1.6 1.3
––
– 0.750
0.7 0.59
3 (5) –2.2
litres kg
62 –
7 - 9 –
7.4 –
5–
1.8 1.5
––
– 0.750
0.9 0.75
3 (5) –2.2 a.t.
litres kg
62 –
7 - 9 –
7.4 –
5–
––
– 6.400(
●)
– 0.750
0.9 0.75
3 (5) –Recommended products and
genuine lubricants
Unleaded petrol
with no less than 95 R.O.N
(EN228 Specification)
Mixture of 50% demineralised wa-
ter and 50% PARAFLU UP
(▲)
SELENIA K P.E.
TUTELA CAR MATRIX
TUTELA GI/V
TUTELA TOP 4
TUTELA GI/R
TUTELA PROFESSIONAL
SC 35
217-242 Croma TRW GB 10-11-2008 13:16 Pagina 234

235
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
Fuel tank:including a reserve of:
Engine cooling
system
– with climate control:
Engine sump and filter:
Mechanical gearbox and
differential:
Automatic transmission
Hydraulic brake circuit
with ABS:
Electrohydraulic power
steering circuit:
Windscreen/rear window/
headlight washer
fluid reservoir: (*)
(*) The values in brackets refer to versions with headlight washers.
(▲) For particularly hard climate conditions, we recommend use of a 60% PARAFLU UPand 40% demineralized water mixture.
(
●) Total quantity of oil in the gearbox.
(❑) Versions pur-O2.
Recommended products and
genuine lubricants
Diesel fuel for motor vehicles
(Specification EN 590)
Mixture of 50% demineralised
water and 50% PARAFLU UP
SELENIA WR/WR P.E. (
❑)
TUTELA CAR MATRIX
TUTELA GI/VI
TUTELA TOP 4
TUTELA GI/R
TUTELA PROFESSIONAL
SC 35 1.9 Multijet
8V
litres kg
62 –
7 - 9 –
7.7 –
4.5 –
1.9 1.6
––
– 0.750
0.7 0.59
3 (5) –1.9 Multijet
16V
litres kg
62 –
7 - 9 –
7.7 –
4.5 –
1.9 1.6
––
– 0.750
0.7 0.59
3 (5) –1.9 Multijet
16Va.t.
litres kg
62 –
7 - 9 –
7.7 –
4.5 –
––
–
6.110(●)
– 0.750
0.7 0.59
3 (5) –2.4 Multijet
20V a.t.
litres kg
62 –
7 - 9 –
8.4 –
5.4 –
––
–
6.110(●)
– 0.750
0.7 0.59
3 (5) –
217-242 Croma TRW GB 10-11-2008 13:16 Pagina 235

237
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
Lubricants
and greases for
transmissions
Protective
agent
for radiators
Windscreen/
rear window/
headlight
washer fluid Brake
fluid
Additive for
diesel fuelSynthetic-based oil, grade SAE 75W-85 that passes API GL-4
specifications
Special lubricant for 5 seed automatic transmissions with limited
slip torque converter.
Specification FIAT 9.55550-AV1
Special lubricant for 6 speed automatic transmissionswith limited
slip torque converter.
Specification FIAT 9.55550-AV2
Specifc grease to be used for constant-velocity joints with low
friction coefficient. N.L.G.I. 0-1 consistency.
Grease containing Molybdenum bisulphide for high temperature
appliances. N.L.G.I. 1-2 consistency.
Synthetic fluid for hydraulic and electrohydraulic systems.
Specification FIAT 9.55550-AG3
Synthetic fluid, FMVSS n° 116 DOT 4, ISO 4925 SAE J1704,
CUNA NC 956-01
Protective with antifreeze action, red colour based on inhibited
monoethylen glycol and organic formula, that passes
CUNA NC 956-16, ASTM D 3306 specifications.
Additive for diesel fuels with protective action for Diesel engines
Mixture of alcohol and surfactants CUNA NC 956-11Mechanical gearbox
and differential
5 speed automatic gearboxes
6 speed automatic gearboxes
CV joints on differential side
CV joints on wheel side
Electrohydraulic
power steering
Brake and clutch hydraulic
controls
Radiator antifreeze
proportion:
50% distilled water and
50% PARAFLU UP(❑)
To be used diluted
or undiluted
To be mixed with diesel fuel
(25 cc per 10 litres) TUTELA CAR
MATRYX
Contractual Technical
Reference N. F108.F02
TUTELA CAR GI/V
Contractual Technical
Reference N. F333.I05
TUTELA CAR GI/VI
Contractual Technical
Reference N. F336.G05
TUTELA STAR 700
Contractual Technical
Reference N. F701.C07
TUTELA ALL STAR
Contractual Technical
Reference N. F702.G07
TUTELA CAR GI/R
Contractual Technical
Reference N. F428.H04
TUTELA TOP 4
Contractual Technical
Reference N. F001.A93
PARAFLU UP (●)
Contractual Technical
Reference N. F101.M01
TUTELA DIESEL ART
Contractual Technical
Reference N. F601.L06
TUTELA
PROFESSIONAL SC 35
Contractual Technical
Reference N. F201.D02
Use Fluid and lubricant specifications Genuine fluids Applicationsfor correct car operation and lubricants
(●) IMPORTANT Do not add or mix fluids having different specifications from that already existing.
(❑) For particularly hard climate conditions, we recommend use of a 60% PARAFLU UPand 40% demineralized water mixture.
217-242 Croma TRW GB 10-11-2008 13:16 Pagina 237

Rear fog light......................................... 72
– rear fog light warning light........... 152
Rear optical units
– fixed side optical unit.................... 176
– lamp replacement.......................... 175
– optical unit on boot hatch ........... 175
Rear sunshade curtains....................... 78
Rear view mirrors
– electrochromic interior .............. 44
– exterior .......................................... 44
– interior ........................................... 44
Rear window washer-wiper
– control............................................. 67
– liquid level....................................... 205
Rear window wiper
– brush................................................ 212
– control............................................. 67
– sprayers........................................... 213
Reconfigurable multifunctional
display ................................................. 25
– control buttons.............................. 25
– display functions............................. 28
– setup menu .................................... 25
– standard screen.............................. 26
Refuelling............................................... 234
Regulations for vehicle handling at
the end of its life cycle..................... 247
Roof rack/ski rack................................ 92
Rubber piping (warnings)................... 211
S.B.R. (system).................................... 109
Safety...................................................... 107
Saving fuel.............................................. 138Seat belts
– general warnings............................ 111
– load limiters.................................... 110
– maintenance.................................... 112
– seat belts not fastened warning
light................................................... 147
– use.................................................... 108
Seats
– adjustment “at the table”............. 40
– cleaning............................................ 215
– electrically adjusted front ........... 41
– manually adjusted front ............... 39
– rear .................................................. 42
Side air bags.......................................... 122
– front and rear side chest
protection air bags (Side bags) .. 122
– head protection side air bags
(Window Bags).............................. 122
– general warnings............................ 124
– turning off the front and rear side
chest protection air bags
(Side bags) ...................................... 123
– rear side chest protection air bag
warning lights (Rear Side Bags)
off .....................................................156
Smokers kit........................................... 76
Snow chains.......................................... 143
Spark plugs
– spark plug preheating failure
warning light................................... 150
– spark plug preheating warning
light................................................... 150
Spark plugs (type)................................ 221
Speedometer........................................ 21
Starting and driving.............................. 127 Performance......................................... 231
Plates
– body paint....................................... 219
– identification data.......................... 218
Pollen filter (replacement)................. 207
Position lights
– control............................................. 62
– front lamp replacement................ 174
– position light warning light .......... 154
– rear lamp replacement................. 177
Power steering
– failure warning light ....................... 149
– liquid................................................. 205
Power steering liquid
– level check....................................... 205
Power steering liquid level................. 205
Power supply
– Technical data................................ 223
Presetting for “Isofix Universale”
car seat installation .......................... 117
Pretensioners........................................ 110
– load limiters.................................... 110
– warnings........................................... 111
Provided tools...................................... 162
Radio frequency remote control:
Ministerial Certification................... 241
Radio transmitters and cell phones . 101
Rain sensor............................................ 66
Rear armrest......................................... 75
Rear ceiling lights
– control............................................. 70
– lamp replacement.......................... 181
246
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
243-256 Croma TRW GB 11-11-2008 11:39 Pagina 246

Transmission
– Technical data................................ 223
Transporting children safely.............. 112
Trip computer...................................... 36
Turn signals
– control............................................. 63
– cornering lights.............................. 63
– front lamp replacement................ 174
– lane change function..................... 63
– left turn signal warning light ........ 154
– rear lamp replacement................. 176
– right turn signal warning light ..... 154
– side lamp replacement.................. 175
Tyre pressure....................................... 228
Tyres
– correct tyre reading...................... 225
– provided ......................................... 227
– snow................................................. 142
– wheel replacement........................ 159
User purchased accessories............ 101
Vehicle inactivity................................. 144
Vehicle lifting......................................... 190
Vehicle refuelling.................................. 103
Vehicle towing...................................... 191
Volumetric protection........................ 15
Warning lights and messages .......... 145
– general warnings............................ 146
Weight................................................... 232
Wheel
– Fix & go automatic rapid tyre
repair kit ......................................... 165– replacement.................................... 159
– spare (characteristics).................. 227
Wheel alignment.................................. 225
Wheel rims
– correct rim reading....................... 226
Wheels and tyres................................. 210
– cold inflating pressure................... 228
– correct rim reading....................... 226
– correct tyre reading...................... 225
– rims and tyres................................ 225
– rims and tyres................................ 227
– spare wheel..................................... 225
– wheel alignment............................. 225
Window cleaning................................. 65
Windows (cleaning)............................ 215
Windscreen washer
– control............................................. 65
– liquid level....................................... 205
Windscreen washer/rear window
washer-wiper/headlight
washer-wiper liquid
– level check....................................... 205
Windscreen washer/rear window
washer-wiper/headlight
washer-wiper liquid level................. 205
Windscreen wiper
– brushes............................................ 212
– control............................................. 65
– rain sensor...................................... 66
– sprayers........................................... 213
Windscreen wiper and rear window
wiper brushes.................................... 212 Starting the engine............................... 128
– coasting startup.............................. 159
– heating the just started engine.... 130
– ignition device................................ 17
– procedure for gasoline versions ... 128
– procedure for Multijet versions ... 129
– startup with an auxiliary battery... 158
– turning off the engine................... 130
Steering (characteristics).................... 224
Steering lock......................................... 19
Steering wheel (adjustment).............. 43
Storage box........................................... 76
Sun roof................................................. 78
Sun visor................................................ 77
Suspensions (characteristics)............. 224
Symbols.................................................. 8
T.P.M.S. system
(tyre pressure control).................... 99
Table (seat)........................................... 40
Tachometer.......................................... 20
Technical data....................................... 217
Trailer towing....................................... 139
– assembly diagram........................... 141
– tow hook installation.................... 140
– warnings........................................... 139
Transmission
– automatic transmission failure
warning light................................... 155
– maximum automatic transmission
oil temperature warning light ..... 155
– using the automatic electronic
transmission.................................... 133
– using the manual transmission .... 132
247
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IINDEX
243-256 Croma TRW GB 11-11-2008 11:39 Pagina 247

RIGHT HAND DRIVE VERSIONS
DASHBOARD
The presence and the position of the instruments and warning lights may vary according to the versions.
1. Side air vent - 2. Right steering column stalk: windscreen, rear window wiper and trip computer controls - 3. Instrument panel
and warning lights - 4. Left steering column stalk: external lights - 5. Central air vents - 6. Sound system - 7. Front passenger air bag -
8. Glovebox - 9. Heating/ventilation/climate controls - 10. Gearshift lever - 11. Cruise control lever - 12. Driver’s knees air bag -
13. Driver’s air bag - 14. Control unit access door - 15. Control plate.
F0L0517mfig. 1
248
243-256 Croma TRW GB 11-11-2008 11:39 Pagina 248