fuel filter FIAT GRANDE PUNTO 2009 199 / 1.G Owners Manual

84
SAFETY
STARTING
AND DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
SERVICE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
CONTROLS
AND DEVICES
REFUELLING THE CAR
PETROL ENGINES
Use only unleaded petrol.
To avoid mistakes, the diameter of the fu-
el tank opening is too small to insert the
nozzle of a leaded petrol pump. The petrol
octane rating (RON) must not be lower
than 95.
IMPORTANT An inefficient catalytic con-
verter leads to harmful exhaust emissions,
thus contributing to air pollution.
IMPORTANT Never use leaded petrol,
even in small amounts or in an emergency,
as this would damage the catalytic con-
verter beyond repair.DIESEL ENGINES
If the outside temperature is very low, the
diesel thickens due to the formation of
paraffin clots and could clog the diesel fu-
el filter.
In order to avoid these problems, differ-
ent types of diesel are distributed ac-
cording to the season: summer type, win-
ter type and arctic type (cold, mountain
areas).
If refuelling with diesel fuel whose speci-
fications are not suitable for the usage
temperature, it is advisable to mix in the
TUTELA DIESEL ART additive in the pro-
portions shown on the container. Pour
the additive into the tank before the fuel.
When using or parking the vehicle for
a long time in the mountains or cold ar-
eas, it is advisable to refuel using locally
available diesel.
In this case, it is also advisable to keep the
tank over 50% full.For diesel engines, use only
diesel fuel for motor vehicles
in accordance with EN590
European specifications. The
use of other products or mixtures may
damage the engine beyond repair and
consequently invalidate the warranty,
depending on the damage caused. If
you accidentally introduce other types
of fuel into the tank, do not start the
engine. Empty the tank. If the engine
has run, even for a very short time, you
will need to have the entire fuel system
emptied in addition to the tank.
072-086 ACTUAL 1ed EN 28-08-2009 8:55 Pagina 84

85
SAFETY
STARTING
AND DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
SERVICE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
CONTROLS
AND DEVICES
FUEL TANK CAP fig. 101
To carry out refuelling, open lid Aand un-
screw cap B; the cap is fitted with a de-
vice Cwhich fastens it to the lid so it can-
not be mislaid.
In some versions, cap Bmay be provided
with a lock and key; use the ignition key
to access the flap A, turn it anti-clockwise
and unscrew the cap itself.
The hermetic seal may cause a slight in-
crease in pressure in the tank. A suction
noise when you release the cap is there-
fore entirely normal.
When refuelling, hook the cap onto the
device inside the lid as shown in fig. 101.
fig. 101F0M0138m
Do not place naked flames
or lit cigarettes near to the
fuel tank opening: fire risk. Keep your
face away from the fuel tank open-
ing to avoid breathing in harmful
vapours.
WARNING
Filling the tank
To fill the tank completely, top up twice
after the first click of the trigger. Further
top ups could cause faults in the fuel sup-
ply system.
PROTECTING
THE ENVIRONMENT
The devices for reducing petrol engine
emissions are the following:
❒three-way catalytic converter;
❒Lambda sensors;
❒fuel evaporation prevention system.
In addition, do not let the engine run, even
for a test, with one or more spark plugs
disconnected.
The following devices are used for reduc-
ing diesel fuel engine emissions:
❒oxidising catalytic converter;
❒exhaust gas recirculation system (E.G.R.);
❒diesel particulate filter (DPF) (for ver-
sions/markets where provided).
072-086 ACTUAL 1ed EN 28-08-2009 8:55 Pagina 85

117
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
SERVICE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
CONTROLS
AND DEVICES
WARNING
LIGHTS AND
MESSAGES
GENERAL WARNINGS ..................................................... 118
LOW BRAKE FLUID LEVEL .............................................. 118
HANDBRAKE ON .............................................................. 118
AIRBAG FAULT ................................................................... 119
OVERHEATED ENGINE COOLANT ............................ 119
LOW BATTERY CHARGE ................................................ 120
LOW ENGINE OIL PRESSURE ........................................ 120
DEGRADED OIL .................................................................. 120
“DUALDRIVE” ELECTRIC POWER
STEERING FAULT ............................................................... 121
DOOR OPEN ....................................................................... 121
LOW ENGINE OIL LEVEL ................................................ 121
EBD FAULT ........................................................................... 121
INJECTION SYSTEM FAULT
(DIESEL VERSIONS) ............................................................ 122
ENGINE CONTROL SYSTEM FAULT (EOBD)
(PETROL VERSIONS) ......................................................... 122
FRONT PASSENGER AIRBAG DEACTIVATED .......... 123
ABS FAULT ........................................................................... 123
FUEL RESERVE ...................................................................... 123
SEAT BELT NOT FASTENED ........................................... 123
GLOW PLUG HEATING ................................................... 124
GLOW PLUG HEATING FAULT .................................... 124WATER IN DIESEL FILTER ............................................... 124
FIAT CODE CAR PROTECTION SYSTEM FAULT .... 125
EXTERIOR LIGHTS FAULT .............................................. 125
REAR FOG LAMPS .............................................................. 125
GENERIC WARNING ........................................................ 125
PARTICULATE FILTER CLOGGED
(Multijet versions) ................................................................. 126
ESP SYSTEM FAULT ............................................................ 126
WORN BRAKE PADS ........................................................ 126
HILL HOLDER FAULT ....................................................... 126
SIDELIGHTS AND DIPPED BEAM HEADLIGHTS ...... 127
FOLLOW ME HOME .......................................................... 127
FOG LIGHTS ........................................................................ 127
LEFT-HAND DIRECTION INDICATOR ....................... 127
RIGHT-HAND DIRECTION INDICATOR ................... 127
“DUALDRIVE” ELECTRIC POWER STEERING ON ... 127
MAIN BEAM HEADLIGHTS .............................................. 127
POSSIBLE ICE ON ROAD ................................................. 128
LIMITED RANGE ................................................................. 128
ASR SYSTEM ......................................................................... 128
SPEED LIMIT EXCEEDED .................................................. 128
W W
A A
R R
N N
I I
N N
G G
L L
I I
G G
H H
T T
S S
A A
N N
D D
M M
E E
S S
S S
A A
G G
E E
S S
117-128 ACTUAL 1ed EN 28-08-2009 8:56 Pagina 117

124
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
SERVICE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
CONTROLS
AND DEVICES
WARNING
LIGHTS AND
MESSAGES
GLOW PLUG HEATING
(Multijet versions
– amber)
GLOW PLUG
HEATING FAULT
(Multijet versions
– amber)
Glow plug heating
The warning light comes on when the key
is turned to MAR. It goes out as soon as
the glow plugs have reached the preset
temperature. Start the engine as soon as
the warning light goes out.
IMPORTANT In hot outside tempera-
tures, the warning light may stay on for
only a very short time.
Glow plug heating failure
The warning light flashes if there is a fault
in the preheating system. Go to a Fiat
Dealership as soon as possible.
A specific message is displayed on certain
versions.
m
WATER IN DIESEL
FILTER
(Multijet versions
– amber)
When the ignition key is moved to MAR,
the warning light turns on but should go
off after a few seconds.
The warning light turns on when there is
water in the diesel filter.
A specific message is displayed on certain
versions.
c
The presence of water in the
fuel circuit may cause severe
damage to the injection sys-
tem and irregular engine op-
eration. If warning light
ccomes on
(with a message on the display on some
versions), go to a Fiat Dealership as
soon as possible to have the system
bled. Water may have entered the tank
if this appears immediately after refu-
elling: if this happens, switch the engine
off immediately and contact a Fiat
Dealership.
117-128 ACTUAL 1ed EN 28-08-2009 8:56 Pagina 124

166
SAFETY
STARTING
AND DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
CONTROLS
AND DEVICES
SERVICE
AND CARE
Thousands of kilometres
Check operation of engine management systems
(using diagnostic socket)
Replace accessory drive belt/s
Replace fuel filter
Replace air filter cartridge
Change engine oil and oil filter (Multijet versions without DPF)
(or every 24 months)
Change engine oil and oil filter
(Multijet versions with DPF) (**)
Change brake fluid (or every 24 months)
Replace pollen filter (or every 24 months)
(*) Regardless of the distance covered, the timing belt must be changed every 4 years for particularly demanding use (cold climates, city driving, long periods of
idling) or at least every 5 years.
(**) The engine oil and the filter must be replaced when the warning light on the dashboard comes on (see the “Warning lights and messages” section) or at least
every 24 months.
If the car is mainly used in towns and cities, change the engine oil and filter every 12 months.
30 60 90 120 150 180
●●●●● ●
●
●● ●
●●●●● ●
●●●●● ●
●● ●
●●●●● ●
161-180 ACTUAL 1ed EN 28-08-2009 8:19 Pagina 166

167
SAFETY
STARTING
AND DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
CONTROLS
AND DEVICES
SERVICE
AND CARE
DEMANDING USE
OF THE CAR
Should the car be used predominantly in
one of the following particularly demand-
ing conditions:
❒trailer or caravan towing;
❒dusty roads;
❒short (less than 7-8 km) and repeated
journeys in sub-zero temperatures;
❒ frequently idling engine or long-dis-
tance, low-speed driving (e.g. door-to-
door deliveries) or lengthy inactivity;
❒ driving in towns and cities;
you should perform the following inspec-
tions more frequently than shown on the
Scheduled Servicing Plan:
❒ check front disc brake pad conditions
and wear;
❒check cleanliness of bonnet and boot
locks, and cleanliness and lubrication of
linkages;
❒ visually inspect the conditions of: en-
gine, gearbox, transmission, pipes and
tubes (exhaust – fuel – brakes), rubber
parts (boots, sleeves, bushes, etc.);
❒check battery charge and liquid level
(electrolyte);
❒visually inspect the condition of the ac-
cessory drive belts;
❒check pollen filter and replace, if re-
quired;
❒check air filter and replace, if required.
REGULAR CHECKS
Every 1,000 km or before long journeys,
check and, if necessary, top up:
❒engine coolant fluid level;
❒brake fluid level;
❒windscreen washer level;
❒tyre pressure and conditions.
❒operation of lights (headlights, direction
indicators, hazard lights, etc.);
❒operation of the windscreen
wiper/washer system, position and
wear of the windscreen and rear win-
dow wiper blades;
Every 3,000 km, check and top up, if re-
quired, the engine oil level.
You are recommended to use PETRONAS
LUBRICANTS products, which have been
designed and produced specifically for
Fiat cars (see table “Capacities” in the
“Technical specifications” section).
161-180 ACTUAL 1ed EN 28-08-2009 8:19 Pagina 167

194
SAFETY
STARTING
AND DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
SERVICE
AND CARE
INDEX
CONTROLS
AND DEVICES
TECHNICAL
SPECIFICATIONS
1.3 Multijet
–
–
45
5 ÷ 7
7.3
–
–
3.0
3.2
1.7
0.5
2.2
4.5 1.4
45
5 ÷ 7
–
–
5.27
2.4
2.6
–
–
1.5
0.5
2.2
4.5 1.2
45
5 ÷ 7
–
–
5.27
2.4
2.6
–
–
1.5
0.5
2.2
4.5Recommended fuels
and original lubricants
Unleaded petrol with no less
than 95 R.O.N.
(EN 228 Specification)
Diesel for motor vehicles
(EN590 Specification)
50-50 mixture of water and
PARAFLU
UPliquid (❒)
SELENIA K P.E.
SELENIA WR P.E.
TUTELA CAR TECHNYX
TUTELA TOP 4
Mixture of water and
TUTELA
PROFESSIONAL SC 35
CAPACITIES
Fuel tank: litres
including a reserve of: litres
Fuel tank: litresincluding a reserve of: litres
Engine cooling
system: litres
Engine sump: litres
Engine sump and filter: litres
Engine sump: litres
Engine sump and filter: litres
Gearbox/differential
casing: kg
Hydraulic brake circuit: kg
Windscreen/rear window
washer fluid reservoir: litres
with headlight washers: litres
(❒) For particularly harsh climate conditions, a mixture of 60% PARAFLUUPand 40% distilled water is recommended.
181-197 ACTUAL 1ed EN 31-08-2009 12:02 Pagina 194

198
SAFETY
STARTING
AND DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
SERVICE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
CONTROLS
AND DEVICES– version codes .......................... 184
Bonnet ............................................ 70
Boot ................................................. 67
– opening the boot
in an emergency ...................... 67
– opening and closing
the boot .................................... 67
– extension .................................. 68
Boot extension .............................. 68
Brake Assist (emergency
braking assistance) ..................... 75
Brake fluid level ............................. 172
Brakes
– properties ................................. 187
– fluid level ................................... 172
Bulb (replacement)
– general information ................ 141
– bulb types ................................. 142
Car inactivity ................................ 116
Card/CD holder ........................... 58Carrying children safely ............... 93
Ceiling lights ................................... 51
Changing a wheel .......................... 131
Chassis (marking) ......................... 182
Checking levels ............................. 168
Child lock ....................................... 64
Child seats
(suitability for use) ..................... 96
Cigarette lighter ............................ 58
Clutch .............................................. 186
CO
2emissions .............................. 197
Code Card ..................................... 8
Consumptions
– fuel ............................................. 197
– engine oil .................................. 170
Control buttons ............................ 53
Cup/can holder ............................. 58
Cup/can holders ............................ 58
Dashboard .................................... 5
Dashboard and controls ............. 4
Ability to install
navigation system ....................... 82
ABS .................................................. 74
ABS system .................................... 74
Accessories purchased
by the owner ............................... 82
Air filter .......................................... 173
Alarm .............................................. 10
Arm rest ......................................... 57
Ashtray ........................................... 59
ASR .................................................. 77
– activation/deactivation ............ 77
ASR system .................................... 77
Battery
– jump starting ............................ 130
– checking the charge ............... 173
– recharging ................................. 157
– replacement ............................. 173
Bodywork
– maintenance ............................. 178
I I
N N
D D
E E
X X
198-208 ACTUAL 1ed EN 31-08-2009 12:12 Pagina 198

200
SAFETY
STARTING
AND DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
SERVICE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
CONTROLS
AND DEVICES
Levels ............................................. 168
Lifting the car ................................. 158
Load limiters .................................. 90
Main beam headlights
– control ...................................... 47
– flashing ....................................... 47
– bulb replacement .................... 144
Manual climate
control system ............................ 41
Mirrors
– wing mirrors ............................. 36
– rear-view mirror ..................... 35
Multifunction display .................... 21
Number plate light ...................... 147
On-board instruments ............... 14
Paintwork ...................................... 178
Parking lights .................................. 54
Particulate filter ............................. 86
Passenger compartment
air vents ........................................ 38Passenger compartment
ventilation .................................... 37
Performance .................................. 191
Plates
– identification data ................... 182
– body paint ................................ 183
Pollen filter ..................................... 173
Power steering ..........................54-79
Pretensioners ................................ 90
Protecting the environment ....... 85
Radio transmitters
and mobile phones ..................... 83
Rear fog lights
– control button ......................... 54
– bulb replacement .................... 146
Rear window washer
– control ...................................... 50
Rear window wiper
– control ...................................... 50
– blades ........................................ 177
– nozzles ...................................... 178
Refuelling the car .......................... 84 Heated rear window ..........40-45-54
Heating and ventilation ................ 37
Heating/ventilation system ......... 37
Hill Holder system ....................... 76
Identification data ........................ 182
Ignition device ............................... 12
In an emergency ............................ 129
Installing the tow hook ................ 113
Instrument panel ........................... 13
Interior ............................................ 180
Interior fittings .............................. 56
Jack .................................................. 133
Key with remote control ........... 8
– Replacing the battery
of the key with remote
control ...................................... 9
– Replacing the cover
of the remote control ........... 9
Key without remote control ..... 10
Keys ................................................. 8
198-208 ACTUAL 1ed EN 31-08-2009 12:12 Pagina 200

Fiat Group Automobiles S.p.A. – Customer Services – Technical Services – Service Engineering – Largo Senatore G. Agnelli, 5 – 10040 Volvera – Torino (Italia)
Print no. 603.81.637 – 08/2009 – 1 edition
CHANGING ENGINE OIL
1.2 - 1.4 - 1.3 Multijet 75 HP
Tank capacity45
Reserve5 ÷ 7
Refuel petrol cars only with unleaded petrol with an octane rating (RON) of 95 or higher (EN 228 specifications).
Refuel diesel cars only with automotive diesel (EN 590 specifications).
REFUELLING (litres)
2.2 2.1
2.2 2.2
2.2 2.0
2.2 2.22.2 2.1
2.2 2.2
2.2 2.0
2.2 2.22.4 2.1
2.5 2.2
2.3 2.1
2.3 2.3
1.2 1.41.3 Multijet 75 HP
litres kg litres kg litres kg
Engine sump and filter 2.6 2.25 2.6 2.25 3.2 2.75
COLD TYRE INFLATION PRESSURE (bar)
Versions1.2 1.4 1.3 Multijet 75 HPFront Rear Front Rear Front Rear
175/65 R15 84T
Medium load
Full load
185/65 R15 88T
Medium load
Full load
Add +0.3 bar to the prescribed pressure when the tyres are warm. However, recheck that the value is correct with the tyre cold.
With snow tyres, add +0.2 bar to the pressure recommended for standard tyres.
When running at speeds higher than 160 km/h, inflate tyres at full-load pressures.
198-208 ACTUAL 1ed EN 31-08-2009 12:12 Pagina 208