Transmission FIAT QUBO 2016 1.G Owners Manual

INSTALLING ELECTRICAL/
ELECTRONIC DEVICESElectrical and electronic devices installed after buying
the vehicle must carry the following label:
FGA S.p.A. authorises the installation of transceiving
devices provided that they are installed by a
specialised centre according to rules of good
engineering practice and in compliance with the
manufacturer's instructions.
IMPORTANT Traffic authorities may not allow the
vehicle on the road if devices are fitted that involve
modifications to the features of the vehicle. This may
also cause lapse of the warranty in relation to faults
caused by the change or either directly or indirectly
related to it.
FGA S.p.A. shall not be liable for damage caused by
the installation of accessories either not supplied
or recommended by FGA S.p.A. and/or not installed
in compliance with the provided instructions.RADIO TRANSMITTERS AND CELLULAR
PHONES
Transceiver apparatus (e.g. mobile phones, CB radios
etc.) should not be used inside the vehicle unless a
separate antenna is mounted on the roof.
IMPORTANT The use of such devices inside the
passenger compartment (without an external
antenna) may, in addition to potential damage to the
health of the passengers, cause malfunctions in the
vehicle electronic systems, compromising the safety
of the vehicle.
In addition, the transmission and reception of these
devices may be affected by the shielding effect of
the vehicle body.
With regard to EC-approved mobile phones (GSM,
GPRS, UMTS), you should adhere strictly to the
instructions provided by the mobile phone
manufacturer.
fig. 95
80KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX

❒visually inspect conditions of: engine, gearbox,
transmission, pipes and hoses (exhaust - fuel
system - brakes) and rubber elements (boots -
sleeves - bushes - etc.);
❒check battery charge status and fluid (electrolyte)
level (refer to "Battery - Check state of charge
and electrolyte level" paragraph in this chapter);
❒visually inspect condition of the auxiliary drive
belts;
❒check and, if necessary, replace pollen filter, in
particular it should be replaced if there is a
noticeable decrease in the passenger compartment
air intake flow rate.
❒check and, if necessary, replace air filter.
CHECKING LEVELS
When topping up, take care not to mix up
the various types of fluids: they are not
compatible with each other and could
seriously damage the vehicle.
WARNING
Never smoke while working in the
engine compar tment : inflammable gases
and vapours may be present , constituting a fire
risk.
172KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX

ENGINE CODES - BODYWORK
VERSIONSVersion Engine code
1.3 Multijet199A2000The following body version code and key are an
example that may be applied to all body version
codes.
Example:
225BXB1AAX
Key :225
Model
BBodyXB
Engine
1TractionA
Transmission
AX
VersionBODY
A
Qubo M1 (5 seat)
C
Qubo N1 (4 seats)
ENGINES
XA
1.4 petrol Euro 4
XB
1.3 Multijet 75 HP Euro 4
XC
Methane
XD
1.3 Multijet 75 HP Euro 5
XE
1.3 Multijet 95 HP Euro 5
XF
1.4 petrol Euro 5
DRIVE
1Front
TRANSMISSIONA
Mechanical gearbox
1Comfort/Dualogic gearbox
193KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONSINDEX

FUEL SYSTEMVersions Fuel system
1.3 Multijet 75 HPElectronically controlled Common Rail Multijet direct injection with turbocharger and
intercooler
WARNING
Modifications or repairs to the fuel supply system that are not carried out properly or do not
take the technical specifications of the system into account can cause malfunctions leading
to the risk of fire.
TRANSMISSIONVersions Gearbox Clutch Traction
1.3 Multijet 75 HPFive forward speed plus
reverse with synchronizers
for the engagement of the
forward speedsHydraulic drive Front
195KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONSINDEX

UseFluid and lubricant specifications for
correct operationGenuine fluids and
lubricantsApplications
Lubricants for
motion
transmissionSAE 75W-85 grade synthetic lubricant. Exceeds
API GL 4 PLUS specifications.
FIAT Qualification 9.55550-MX3TUTELA CAR
TECHNYX
Contractual Technical
Reference N. F010.B05Manual gearboxes and
differentials (diesel
versions)
Molybdenum disulphide grease, for use at high
temperatures.
Qualification FIAT 9.55580.Consistency
NL.G.I. 1-2TUTELA ALL STAR
Contractual Technical
Reference N. F702.G07Wheel side constant
velocity joints
Grease for constant velocity joints with low
friction coefficient.
Qualification FIAT 9.55580.Consistency
NL.G.I. 0-1TUTELA STAR 700
Contractual Technical
Reference N. F701.C07Differential-side
constant velocity
joints
Automatic transmission lubricant. Exceeding ATF
DEXRON III specificationsQualification FIAT
9.55550- AG2.TUTELA GI/E
Contractual Technical
Reference N. F001.C94Hydraulic power
steering
Brake fluidSynthetic fluid, NHTSA N. 116 DOT 4, ISO
4925, SAE J-1704, CUNA NC 956-01.
Qualification FIAT 9.55597.TUTELA TOP 4
Contractual Technical
Reference N. F001.A93Hydraulic brakes and
hydraulic clutch
controls
208KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX

– Wing mirrors ......................... 32
Rear window washer ................. 43
Rear window wiper ............. 43-184
Removable ceiling light ............. 154
Replacing the battery ................ 180
Replacing the rear window
wiper blade................................ 185
Replacing the windscreen
wiper blades .............................. 185
Rev counter.................................. 13
Right-hand indicator
warning light.............................. 128
Rim Protector............................. 199
Rims and tyres ............................ 197
Roof rack/ski rack ....................... 67
Roof rails....................................... 67
Rubber lines ................................ 184Saving fuel ................................... 113
Seat belt reminder ..................... 122
Seat belts
– Use ........................................... 85
Seats
– Accessing front seats............ 28
– Foldaway passenger seat...... 27
– Front seats .............................. 26Securing your load ...................... 64
Side bags .............................. 103-104
Side bags
– Side bag................................... 104
Side lights - tail lights
(changing a bulb) ...................... 146
Side lights - tail lights ................. 41
Side lights/tail lights ................... 146
– Warning light ......................... 127
Side/tail lights warning light ..... 127
Snow chains................................. 116
Snow tyres................................... 111
Spare wheel ................................. 197
Speedometer ............................... 12
Spray nozzles .............................. 186
Starting procedure for
diesel versions .......................... 107
Starting the engine.... 107-129-130
Steering ........................................ 196
Steering lock ................................ 12
Steering wheel ............................. 31
Stopping the engine ................... 109
Sun visors ..................................... 50
Suspension ................................... 196
Symbols ......................................... 5
Tail lights/rear fog light
(changing a bulb) ...................... 149
Third brake lights (changing
a bulb)......................................... 150
Third brake lights ....................... 150
Tool bag ....................................... 132
Towing the vehicle ..................... 165
Towing trailers ............................ 115
Traction Plus system .................. 75
Transmission ....................... 112-195
Trip Computer ............................ 23
Tyres ............................................. 197U
niversal Isofix seat
compliance with child seat
use................................................ 99
Useful advice for extending
the life of your battery ........... 181
Uzávěr palivové nádrže .............. 82
VIN plate .................................... 191W
arning lights and
messages .................................... 118
Washer fluid for
windscreen/rear window ....... 177
Water in diesel fuel filter
warning light.............................. 124
Weights ........................................ 204
Wheel geometry........................ 197
224KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX