spare tire FORD AEROSTAR 1996 1.G Owners Manual
[x] Cancel search | Manufacturer: FORD, Model Year: 1996, Model line: AEROSTAR, Model: FORD AEROSTAR 1996 1.GPages: 353, PDF Size: 2.87 MB
Page 185 of 353
204
*
[DR29151(ALL)01/95]
q
Use extra caution when driving your vehicle
while you tow. (SeeDriving while you towin
this chapter.)
*
[DR29201(ALL)01/95]
q
Service your vehicle more frequently if you
tow a trailer. (SeeServicing your vehicle if you
towin this chapter.)
[DR29250(ALL)03/90]
Standard length vehicles adapted for trailer tow
may require relocation of the underbody spare
tire. It is recommended that you secure the tire
under the rear-most seat using the hold-down
hardware located with the jack.
[DR29301(ALL)03/91]
one third page art:0020268-A
Spare tire stowage (standard length model)
*
[DR29350(ALL)05/94]
Do not tow a trailer until your vehicle has been
driven at least 500 miles (800 km).
File:10cpdra.ex
Update:Tue Aug 29 17:45:28 1995
Page 189 of 353
208
*
[DR30301(ALL)01/93]
q
GAWR (Gross Axle Weight Rating)
[DR30305(ALL)08/95]
q
GAWR F (Gross Axle Weight Rating Front)
[DR30307(ALL)08/95]
q
GAWR R (Gross Axle Weight Rating Rear)
*
[DR30310(ALL)06/92]
q
GCWR (Gross Combined Weight Rating)
*
[DR30320(ALL)06/92]
q
Maximum Trailer Weight Rating
*
[DR30330(ALL)06/92]
q
Maximum Trailer Weight
*
[DR30340(ALL)06/92]
q
Trailer Weight Range
*
[DR30351(ALL)03/91]
Base Curb Weight
*
[DR30401(ALL)03/94]
The Base Curb Weight is the weight of the
vehicle including fuel, coolants, lubricants,
emergency tools, spare wheel and tire. It also
includes any equipment that isstandardon that
model. It does not include passengers, cargo or
optional equipment installed by factory, dealer,
aftermarket supplier or customer.
*
[DR30451(ALL)03/91]
Payload
*
[DR30501(ALL)03/91]
Payload is the combined, maximum allowable
weight of cargo, occupants and optional
equipment that the truck is designed to carry. It
is Gross Vehicle Weight Rating minus the base
curb weight.
*
[DR30550(ALL)03/91]
Gross Vehicle Weight (GVW)
*
[DR30650(ALL)08/95]
It is important to remember that GVWis not a
limit or a specification.If an owner loads up a
vehicle and weighs it, that's the GVW at that
moment. If the owner piles on more of a load
and weighs it again, that becomes the GVW.
File:10cpdra.ex
Update:Tue Aug 29 17:45:28 1995
Page 203 of 353
222
*
[DR39600(ALL)11/89]
When turning, drive slightly beyond the normal
turning point so the trailer wheels will clear
curbs or other obstructions.
*
[DR39725(ALL)03/95]
When stopped in traffic for long periods of time
in hot weather, place the gearshift selector lever
in P (PARK) to increase the engine idle speed.
This aids in engine cooling and air conditioner
efficiency. If the engine overheats, move the
function selector knob to VENT to stop the
compressor and increase the engine speed for a
short time.
*
[DR39800(ALL)05/90]
RWARNING
Do not tow a trailer when using a
temporary spare tire.
*
[DR39900(ALL)05/90]
Vehicles with trailers should not be parked on a
grade. However, if you must park on a grade,
place wheel chocks under the trailer's wheels as
follows:
*
[DR40000(ALL)05/95]
q
Apply the brake pedal and hold.
*
[DR40100(ALL)11/89]
q
Have another person place the wheel chocks
under the trailer wheels.
*
[DR40200(ALL)08/95]
q
With the chocks in place, release the brake
pedal, making sure the chocks are holding.
[DR40350(ALL)08/95]
q
Apply the parking brake by pressing the
brake pedal down firmly with your right foot
while applying the parking brake with your
right hand.
*
[DR40575(ALL)06/95]
q
Shift the gearshift lever into P (Park).
File:10cpdra.ex
Update:Tue Aug 29 17:45:28 1995
Page 209 of 353
229
*
[RE03200(ALL)06/95]
3. Remove the positive (+) cable from the
booster battery.
*
[RE03400(ALL)05/95]
4. Remove the other end of the positive (+)
cable from the discharged battery.
*
[RE03500(ALL)04/95]
After the vehicle is started, let it idle for a while
to let the engine ªrelearnº its idle conditions.
Drive it around for a while with all electrical
accessories turned off to let the battery recharge.
You may need to use a battery charger to fully
recharge the battery.
*
[RE03550(ALL)03/95]
If you need to replace your battery, seeBattery
in theServicing Your Vehiclechapter.
%
*
[RE03600(ALL)03/95]
Changing a Tire
*
[RE03700(ALL)01/95]
If you get a flat tire while you are driving, do
not apply the brake heavily. Instead, gradually
decrease the speed. Hold the steering wheel
firmly and slowly move to a safe place on the
side of the road. Park on a level spot, turn off
the ignition, set the parking brake, and turn on
the hazard flashers.
%*
[RE03800(ALL)03/95]
The Conventional Spare Tire
*
[RE03900(ALL)01/95]
If you have the conventional spare tire, you can
use it as a spare or as a regular tire. This spare
tire is identical to the other tires that come with
your vehicle, although the wheel may not match.
%*
[RE04000(ALL)03/95]
The Temporary Spare Tire
*
[RE04100(ALL)03/95]
You may have a high pressure temporary spare
tire. This spare tire is smaller than a regular tire
and is designed for emergency use only. Use it
only when you get a flat tire and replace it as
soon as you can. This spare tire is marked with
the words ªTEMPORARY USE ONLYº so that
you can easily identify it.
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995
Page 210 of 353
230
*
[RE04200(ALL)01/93]
RWARNING
If you use the temporary spare tire
continuously or do not follow these
precautions, the tire could fail, causing
you to lose control of the vehicle, possibly
injuring yourself or others.
[RE04250(ALL)05/95]
RWARNING
The tire size on the E-4WD must be
maintained.
[RE04260(ALL)06/95]
Your vehicle may have a full diameter mini
spare or a full size tire. This full diameter mini
spare is special for the E-4WD and another mini
spare from another vehicle can not be
substituted without the possibility of damage to
your vehicle. All tires should be inflated to the
manufacturer's recommended pressures.
*
[RE04275(ALL)05/95]
RWARNING
To avoid injury, never run the engine
with one wheel off the ground, such as
when changing a tire.
*
[RE04280(ALL)10/94]
Extended use of other than matching size spare
tires on a Traction-Lok axle could result in a
permanent reduction in effectiveness. This loss of
effectiveness does not affect normal driving and
should not be noticeable to the driver.
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995
Page 211 of 353
231
*
[RE04300(ALL)01/95]
When you drive with the temporary spare tire,
DO NOT:
*
[RE04400(ALL)01/95]
q
exceed 50 mph (80 km/h) under any
circumstances.
*
[RE04500(ALL)01/95]
q
load your vehicle so that it is heavier than
the maximum vehicle load rating listed on
the tire decal.
*
[RE04600(ALL)01/95]
q
tow a trailer.
*
[RE04700(ALL)01/95]
q
use tire chains on this tire.
*
[RE04800(ALL)01/95]
q
try to repair the temporary spare tire or
remove it from its wheel.
*
[RE04900(ALL)01/95]
q
use the wheel for any other type of vehicle.
*
[RE05000(ALL)01/95]
q
drive through an automatic car wash with
this tire. Because the temporary spare tire is
smaller than a conventional tire, it reduces
the ground clearance. Your vehicle may get
caught in the rails and it could be damaged.
%*
[RE05100(ALL)03/95]
Spare Tire Location
[RE05200(ALL)03/95]
If your vehicle is a standard length van model,
the spare tire is mounted inside a carrier at the
left rear quarter panel. To remove the spare tire,
remove the wing nut and plate. A flat tire can
be temporarily stowed in the same location.
[RE05300(ALL)01/89]
quarter page art:0020264-A
A side mounted spare tire
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995
Page 212 of 353
232 [RE05400(ALL)05/94]If your vehicle is the model with a standard
length body or extended length (all models), the
temporary spare tire is stowed at the rear of the
vehicle under the body.
[RE05450(ALL)05/94]
The standard length E-4WD model spare tire is
mounted on the floor.
[RE05500(ALL)08/95]
To remove underbody temporary spare tire:
[RE05600(ALL)11/89]
1. Insert lug nut wrench into the actuator hole
and turn counterclockwise until the cable
extends to allow the spare tire to be pulled
rearward from under the vehicle.
*
[RE05700(ALL)10/94]
2. Slide the spare tire to the rear and remove
the retainer from the wheel.
[RE05800(ALL)11/89]
3. To stow cable/retainer with spare tire
removed, insert cable fitting into carrier rear
wall slot, place wheel retainer against the
carrier, and turn lug nut wrench clockwise
until slack is removed.
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995
Page 213 of 353
233 [RE05900(ALL)08/95]
three fourths page art:0020265-A
Temporary spare tire location and assembly
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995
Page 214 of 353
234 [RE06000(ALL)08/95]To stow underbody temporary spare tire:
[RE06100(ALL)11/89]
1. Insert lug nut wrench into the actuator hole
and turn counterclockwise until the
cable/retainer is extended for insertion into
the wheel.
*
[RE06200(ALL)10/94]
2. Install the retainer through wheel center
with valve stem facing up.
[RE06300(ALL)11/89]
3. Rotate wrench clockwise until tire is secured.
(Raising mechanism will slip.)
*
[RE06400(ALL)03/91]
4. Check for proper seating against underbody
supports and retighten if necessary.
[RE06500(ALL)11/89]
half page art:0020266-B
Spare tire Ð underbody carrier
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995
Page 215 of 353
235 [RE06600(ALL)05/95]
RWARNING
Do not stow any conventional spare tire
or flat temporary spare tire in the
underbody position. Doing so may cause
damage to the tire, rear axle, or brake
lines. (Standard length only)
[RE06800(ALL)01/89]
A flat tire can be temporarily secured to the
floor pan under the rear-most seat. To
temporarily secure a flat tire:
[RE06900(ALL)01/89]
1. Remove the spare tire ªJº bolt, plate and
wing nut from their stowed location on the
jack.
[RE07000(ALL)01/89]
2. Position the flat tire, valve stem up, under
the rear-most seat and over the ªJº bolt
attaching bracket on the floor pan.
[RE07100(ALL)01/89]
3. Insert the ªJº hook bolt through the center of
the wheel and hook on bracket.
[RE07200(ALL)06/95]
4. Install plate over ªJº hook bolt and secure
with wing nut.
[RE07300(ALL)05/89]
quarter page art:0020267-A
Stowed position of ªJº bolt, plate and wing nut (Standard
length model)
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995